So Kevin here is where you come in. Been wanting to make getting consistent Q on the table regularly and easily. Been looking at pellet poopers for about 5 years now and decided to take the plunge. Had already done enough looking a few years ago Traeger’s issues had scared me off. Several friends had them and raved but always mentioned problems. I decided from my work I don’t want to be buying someone’s, ‘we know the problems and are fixing them’ if you can find something solid for similar cost. Yoder and FEC were pretty much my finalists. So I was doing my final thoughts and found your article.
PID controllers: PID controllers are considered by many to be the gold standard of grill controllers. Using complex algorithms, temperatures are accurate to within a few degrees. The pellet feed is constantly adjusted to maintain the correct temperature, and this type of controller can even accommodate programmable meat probes that work in tandem with the controller to lower the temperature when the meat is done. They also feature LCD and one touch buttons.
I bought my second Traeger Grill around Thanksgiving (my last one died after 3 months), spent most of the day assembling it only to find it didn't work. Customer service told me to reset the thermostat, I did and it shut down.  I did this routine a few more times with customer service and it kept shutting down, day after day.  Traeger reluctantly sent me a replacement grill and promised it would be Fully assembled (I have little use of my left hand and can't work with small parts)  Well it showed up unassembled in a bunch of little boxes. Customer service told me 4 times that they would call back with a local Traeger dealer to assemble it. Four promises to have someone come out and not even a phone call.
If the metal is too thick, you will also use a lot of pellets. The walls of a thick-bodied smoker act as a “heat sink”. Heat is taken away from the cooking area and stored in the walls of the cooker. So, it will take a lot of pellets to get the cooking area up to the desired temperature. While thick walls are desirable for some types of cookers, they are not required in pellet smokers.
I have had a Traeger Junior Elite for 4 years. In that time I have used it < 50 times. I have replaced a fan motor, a fuse, and now I have been trying to get a thermometer replaced. First time, the service guy dropped the ball and never sent it. Second time- the thermometer got sent around to multiple post offices. Third time, never got to me- apparently they sent it to the wrong address. Fourth time- still waiting. It's been 5 weeks now, and I cannot get the part, and have no idea if the part will fix the grill. Everyone in service has been polite, but incompetent as well. I have had 2 flash fires in the grill from the auger pushing too many pellets into the hot pot, the temperature fluctuates wildly. Save yourself the frustration: avoid Traeger at all costs!
Secondly, make sure you pay attention to the controls and temperature settings. As well as a thermostat, higher quality smokers come with meat thermometers built in. As you cook, the internal temperature of your meat is going to rise, and unless you’ve got a meat thermometer, there’s no way of knowing exactly how hot it’s got. If you don’t know why this is bad, when you let food sit too hot for too long, you run the risk of drying it out. You’ll undo all of your good work, plus it just tastes bad.
PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.
Computers Electronics Appliances Automotive Beauty & Health Furniture Sports & Outdoors Kids Goods Home & Garden Computers Softwares Fitbit Galaxy Gaming Chairs Smartphones Perfumes Shoes Digital Cameras Iphone Headphones Juicers Smart Watches E-Readers Iphone 6 Scooters mopeds Used crossbows Propane gas refrigerator TV Ultra 4k Clothing accessories
Is it common to have a lot of ash blowing throughout these pellet smokers? I thought it was supposed to be minimal ash and that it’s supposed to stay in the firepot. I noticed after two short cooks I have ash everywhere. The pellets are Perfect Mix from cookingpellets.com, but by “perfect mix” I don’t think they mean to mix ash from their product with your BBQ. Also, didn’t put off a lot of smoke, and really couldn’t taste any smoke at all.

After an hour on tech support, taking the thing apart, they acknowledged the auger motor was bad and they would send me one. This would be FANTASTIC if I had owned the grill for a year or so and the company was standing by their product... but to insist on sending me a part to a BRAND NEW GRILL and having me replace it...Unacceptable. When I asked for a new replacement hopper system (I get it ... things break... and I'm willing to meet them halfway) they said no... just the motor. I would have kept it had they allowed me to swap out the entire hopper system but I shouldn't have to do surgery on a brand new piece of equipment. Please don't buy this poorly made (China) piece of trash.
For beginner outdoors chefs and guys buying their first smoker, that’s an invaluable bit of knowledge. Knowing that no matter what you do, as long as you follow the standard set up, you’re going to produce professional quality meat with ease, which is why smokers like the ones below are the best choice for anyone looking at buying their first pellet smoker.

I purchased a Traeger 34 inch smoker a month ago and it has never worked correctly. I called customer service several times and the bottom line is that if I want to have it serviced, I have to load it into my car and drive it to Long Beach. There isn't a service dealer in the entire City of Los Angeles! Going to return it to Home Depot. Buy any smoker other than a Traeger.
The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.

Like the Z GRILLS Wood Pellet Smoker, the REC TEC Grills Mini Portable Pellet Grill is capable of going up or down by 5° Fahrenheit increments, leading it to heat up from 180° Fahrenheit to 550° Fahrenheit. At full power, it can reach a temperature of 600° Fahrenheit. The mini size is enough to fit in a turkey or maybe three slabs of ribs, so that’s portability without sacrificing quality and capacity too much.
When it comes to construction, few companies can beat Traeger. Its grills come with construction features like cast-iron grates with a clear and nontoxic coating that prevents food from sticking to the grill and fireboxes made from a similar material. Though Pit Boss grills feature similar elements, many look flimsy, and most will not keep up with your grilling and smoking demands.

Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.


In reading through the comments section, it seems the recommendations have shifted over time. As it stands today, which smoker would you go with and why: GMG Jim Bowie, Traeger Pro 34, or the RecTec? I like the cooking space of the Traeger Pro 34, but the other 2 seem to have more bells and whistles. I’ve been smoking about 5yrs, so not a pro but not a beginner. Currently have a 10+ year old Traeger Lil Tex elite hand-me down that is ready to give up the ghost. Would appreciate your thoughts!
Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
My experience with the seller has not been as pleasant. The Amazon product page indicates these are sold by Outdoor Cooking. Outdoor Cooking is listed on the Camp Chef website as an online sales partner. My order was not fulfilled by Outdoor Cooking, it was fulfilled by "deguns" (2.5 stars). I received my grill via UPS. The box was in rough shape, but still intact. The grill itself had some minor damge. I sent a message to the seller thru Amazon. Their response was basically, contact Camp Chef, if you have any issues we can contact them also. Not really the kind of response I was expecting.

Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.
The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.
And #3, good bbq or grilled meats should taste great without a ton seasonings or sauce. Beef especially can be excellent with simple salt! Make sure your seasonings enhance flavor. Another great read, the late (and much grieved at our house) Paul Prudhomme’s ‘Louisiana Kitchen’ again available on Amazon used for a couple of bucks and a masterpiece! Paul was a master of seasoning. Don’t kill it with seasonings and sauce, enhance the foods flavors. Barks on meat are great if they are right. However burnt, sugar and many other seasonings detract from the meats natural flavor. I personally love a meat you can eat without a sauce and then sauce if you want some added flavors going on!

Today I grilled up a T-Bone steak. And I used the Grill Grates. I upped the temps to 600 degrees. The T-Bone came out FABLULOUS!!! Actually, it cooked faster than I expected, and the sear marks were way better than I expected. I have been using Weber Gas Grill for many years and way satisfied with the results, but the Yoder smoker kicks ass...BRAVO YODER!!
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly. 

I’ve seen a lot of pellet smokers over the years, and it’s easy to say that out of every one, the RecTec is without a doubt a beast. It combines exceptional cooking performance with fantastic build quality and a thoughtfulness of design that you just don’t see in other smokers. Or a lot of other products. Not only that, but it’s one of the easiest smokers I’ve ever used, with professional quality cooking literally at the push of a button

I purchased a Traeger Elite Grill from the website. I use the grill one time and it worked fine. A couple of weeks later we fired up the grill to cook some steaks. Approximately 10 minutes into cooking the auger stopped working. We had to finish our meal cooking it on the stove. I looked at the troubleshooting guide and the steps needed to be taken. To determine what was wrong you basically needed to dismantle the electric box and auger housing. I am not an electrician Nor a mechanic and feel this is excessive for a consumer to have to do.


You’re concerned with ongoing costs for fuel and power: The wood pellets used with Traeger grills are more expensive than propane or charcoal. You can expect to spend $1 to $3 per grilling session using wood pellets. Propane is far less expensive to operate in a grill, while charcoal fits somewhere in the middle of the cost range. And beware of cheap pellets from third-party manufacturers that contain softwoods like pine. They burn much faster than hardwoods, so the end cost won’t be that much different because you’ll use more of them. And they can introduce unwanted chemicals and contaminants to your food. You will also have some electrical power costs with these Traeger pellet grills.
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.
The Cast Iron Muffin Toppers Biscuit Pan by .Who doesn't love eating just the top off their muffin? With this cast iron muffin top...per pan, you wont have to waste the bottom of a muffin every again! Even distribution of heat throughout the cast iron ensures a perfect golden brown muffin every time! Pan makes six muffin toppers, perfect for an entire family. Our great pan is true-seasoned and is ready to use right out of the box! BTI trading was established in year of 2012.We are allocated at US WA.The transportation to our store is very convenient.we are selling only high quality products we also selling our products world wide .At BTI we sure you can find all the product that you want. read more
Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:

When it comes to temperature range, Pit Boss 71700FB has a minimum temperature of 180°F and a maximum temperature of 500°F. This Pit Boss pellet smoker can be used for grilling, roasting, smoking, baking, searing, and braising. In addition, the Flame Broiler allows you to grill your food directly over an open flame. And with a hopper that can fit up to 12 pounds of wood pellets, you’ll be smoking all day without having to refill.
"The Camp Chef transaction aligns with Vista Outdoor's strategy to deliver long-term value through acquiring complementary, market-leading brands that will benefit from Vista Outdoor's balance sheet, distribution network, and sales and marketing expertise," said Chairman and Chief Executive Officer Mark DeYoung. "Led by an entrepreneurial management team, Camp Chef has a nimble and responsive product development process. Camp Chef continues to grow its market share in the outdoor cooking category, and the brand serves many of our current consumers who are engaged in a wide variety of outdoor pursuits. Acquiring Camp Chef strengthens our leadership position in outdoor recreation, allows us to enter the growing camping and outdoor cooking market, and the brand's effective multi-product, multi-channel strategy increases our presence across both brick-and-mortar and ecommerce distribution platforms."

Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.


SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase
I don’t know why these cookers are referred to as grills. By definition they are not grills. Grilling involves cooking with direct heat and none of the pellet cookers I’ve seen use direct heat; they all use indirect heat. They are more accurately described as smokers/convection ovens. For me what this means is they’re useless for cooking chicken since I like my chicken cooked with crispy/burned skin. I’ve done some experimenting to get the skin to crisp up but always end up with leather skin. They have their place in outdoor cooking but grilling ain’t it. I just bought a Green Mountain and I’m still debating if I’m going to hang on to it. Shame on me for not doing more thorough research first.
While the Green Mountain Grills Davy Crockett Pellet Grill is compatible with most iOS and Android devices, I want to stress, check the compatibility of your device with the grill before purchasing because it would suck to buy this grill only to find out that this feature is not compatible. Also, if you do not plan on using the grill on some elevated surface, the legs are not tall so the grill sits close to the ground. Regardless, this is a GREAT smoker: your meat will come out tender and juicy with that authentic BBQ taste we all love! Neither of these cons affects the quality of your BBQ and both can be worked around.
So, there they are: my pellet grill review of 2016-2017.These information are surely going to help you from going nuts when trying to purchase your own pellet grill. These pellet grill review will give you a clear straight forward understanding of the best and most conventional features in pellet grills in the market today. Now that you are all set thanks to the pellet grill review, go grab yours, call some friends over and have a great weekend! 

Craft amazing wood-fired creations with the Traeger Lil' Tex Elite 22 pellet grill. From grilled steak, to smoked ribs, and even a freshly baked apple pie, the set it and forget it ease of use allows any home chef to cook it all. Swap the gas and charcoal barbecue for 100% pure hardwood pellet flavor and grill, smoke, bbq, bake, roast, or braise a masterpeice.
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
Hey John! Thank you so much for your kind words. I try to do a good job here, and am pleased you are enjoying the site. Regarding electric smokers, I have friends who own them and love them. I’ll try to get a post out this summer on them. Folks seem to like Bradley smokers a good bit, so you might want to check them out. You can find a good selection of them on Amazon.com here.

PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.

This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.


Hey Chris, IMHO the Blazing Pellet Smoker looks like a solid unit. There’s a good review of it here. I think between the units I might give them a run. Yoder makes quality stuff, and if made in the USA is important to you, they fit as do the Blazings. All this said, if you’re basically using the pellet smoker like a Cambro, you could opt to save a little money and go with the Rec-Tec. Good customer service and solid following.
Although pellet smokers already have their own custom-made wood pellets with different flavor and blends, if you choose to moonlight your smoker as a charcoal smoker for some reason (maybe for a different experience or a cooking experiment), you can use it as a regular smoker using wood chips. Under such circumstances, it’s going to be worth learning a bit about the types of wood chips out there.
Complete with a variety of spectacular features, the Z Grills Wood Pellet Grill and Smoker redefines the whole concept of smoking. At a reasonable price, this smoker gives you more than what you paid for. It offers top technology-rich features that ensure consistent smoking for that great smoky flavor. Plus, many customers – including ourselves – have attested to its durability. This smoker will serve you without failure for a very long time.
×