After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
True blooded grill sweethearts out there might value this item. It is a minimized, full-included pellet barbecue that can take care of their grilling needs. You may need the item that accompanies all that you may require. When you have warmed it up, you can anticipate a perfect temperature and warmth in view of what you have chosen. Much the same as when you have found a reasonable latte machine for you, you would feel pleased with yourself for picking an extreme item that stays aware of your needs. Another element you may acknowledge in the item is that can keep the correct temperature all through the barbecuing or cooking process—regardless of whether you burn, grill, smoke or prepare. The cooking instrument is an exact griller that won’t make you stressed over any temperature variance. So whether you are an amateur or a pit ace, you might need to investigate this item that can take your grilling to the following level.
The smart-smoke technology in this grill uses an automatic electric feed system that is able to maintain a constant temperature from 180 to 450 degrees and has a hopper that can hold up to 20 pounds of pellets for extended cooking time. The digital control also handles igniting the pellets while fan-forced convection results in even cooking all around, much like rotisserie-cooked foods.
When you have owned your smoker grill for 5-6 years you start wondering if owning a new one would be the best idea. This might happen because you are facing problems with your machine and not getting the desired result. The first and primary advice in this situation remains to clean up your grill thoroughly. Open up each and every part then proceed to doing a thorough cleaning. Most of the problems like temperature inconsistency or jamming will get solved this way.

With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
Hi Dan, I had a Bradley some years ago and the quality of the smoke is somewhat comparable to that of a pellet unit. As I said in my earlier post, compressed sawdust does not create the wood flavor that permeates the meat— no matter what pellet you use. I recently bought a Lang reverse flow, and on my first cook the difference was spectacular. My nephew went to the trouble of adding a full size wood burning firebox to his pellet stove as an experiment. He piped the smoke from the firebox into the pellet unit while making some ribs and the results were obvious. The next day he was out looking for a new smoker. Wood burners are a lot of work compared to a pellet unit, as you say, so I understand your reluctance. Many like vertical units that burn charcoal with wood chunks. These units are much easier to manage than a stick burner and give good results. All I can say is that the first time you make BBQ in your backyard with a wood unit, you will know you made the right choice. There are many good BBQ forums that discuss these points. Good Queing to you.
Since wood chips are by-products of carpentry and woodwork, they are not only inexpensive but are also helpful for the environment since you’re using up all the parts of a tree. Its death wouldn’t go in vain! If you’re looking to learn more about the types of available wood chips and what kind of flavors they impart with, feel free to check out our post on that topic.
It offers 700 sq. in. of cooking space and a powerful thermostat for a higher price, but makes up for it as soon as you start cooking on it. Also, it has a stunning design with the bull horns, which sets it apart yet again. But if you find yourself not spending as much and could do with a lesser cooking space, then the Camp Chef PG24 is a no-brainer for you.
This is a great pellet smoker! With a few minor tweaks, this thing would be perfect. Ribs, brisket, chicken, pulled pork, sausage, you name it and it comes off of the grates awesome. I've had mine since 2012 and would recommend that you purchase a spare thermocouple in case your's bites the dust in the middle of a smoke (replaced my thermocouple twice since 2012). This thing is built solid with longevity as a guarantee. The customer support at Yoder is unbelievable as well. I have gotten phone calls from them at 8am on Sunday morning when my first thermocouple gave up in 2014. Made in the USA with a commitment on customer support that has been incomparable to anything I've ever purchased! It's a bit pricey compared to the competition but does an amazing job. "The Sauce", with Chef Tom, is a huge help for those just getting their feet wet in pellet smoking. He does an amazing job by keeping it simple and flavorful!
Explicitly designed as a tailgate smoker with maximum portability and accessibility, the Davey Crockett does what it does really well. It’s small, but it’s so easy to move and runs off of damn near any power source, so if you want a wood pellet smoker you can take literally anywhere with maximum portability and style, this is the one. That’s why in my opinion, this is the best pellet smoker out there for the money.
Local availability of pellets is only one problem though.  How are you, the consumer, supposed to know which is a good pellet brand versus a bad?  If you do a Google search for “where to buy pellets” you are likely only to see a lot of advertisements all proclaiming their product to be the best.  This situation is very akin to what consumers in the charcoal industry deal with as well.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.

love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….

Third name to make it to my list of the best pellet grill review is The REC TEC Wood Pellet grill. It has a trademark Smart grill Technology, which maintains precise temperature. This amazing pellet grill has a whopping 702 square inch cooking area, and a 40 pound capacity pellet hopper. It is made out of high quality stainless steel. It comes with a drip pan.


Yoder Smokers are built for experienced pit masters and competitive cooking. So, you may be wondering why is the Yoder YS 640 the runner-up then? It’s simple – this is a pro level grill and it’s more than what many people actually need. And since it is built for competitive purposes it also happens to be the most expensive pellet grill on this list.
PG24 by Camp Chef Pellet Grill also brings along a digital controller which you could use to set your desired temperature and at one point the heat in the chamber will be automatically adjusted. It allows meat to be smoked for hours at a temperature of 150 degrees F. You could increase temperature to 500 degrees F for searing and grilling. With convection, the cold and hot areas of the grill can be replaced with even heat.
In the Grills Bull we have another large, unwieldy, but fully loaded grilling system. With a price that would make most grillers wince, this Pellet Grill comes complete with all sorts of bells and whistles. Aside from the large, wifi-enabled grill itself, Rec Tec throws in a terrific 6-year warranty as well as over 150 pounds of Pellets, which goes a long way towards justifying the cost. The Bull also has a large, 100% stainless steel cooking space which offers terrific durability long-term.
I purchased a Traeger 34 inch smoker a month ago and it has never worked correctly. I called customer service several times and the bottom line is that if I want to have it serviced, I have to load it into my car and drive it to Long Beach. There isn't a service dealer in the entire City of Los Angeles! Going to return it to Home Depot. Buy any smoker other than a Traeger.
One thing I’ll mention up front is that the Rec Tec Grill is not sold as a Made in America product. The REC TEC Grill is made in China, however, the heart and soul of the grill (the computer) is made here in the USA. The powder coat is also made in the USA and the final assembly along with quality control takes place at the REC TEC Grill facility in Georgia.
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
To see if ShippingPass is right for you, try a 30-day free trial. Also, with ShippingPass, there is no need to worry about commitment. If you decide you want to discontinue the service, you can cancel your subscription at any time. No matter what your shipping needs, Walmart's got you covered. Sign up for ShippingPass so you can shop more, save money and live better.
While many people enjoy pellet grills, some find it difficult to use pellets to produce true, flavorful steaks and barbecue since the fuel often lacks the same flavors as traditional grills. That smoky, wood flavor many steaks have is not impossible to get with the right pellet grill however. The Z Grills Wood Pellet Grill sports a combined grill/smoker setup with temperature control for the best pellet grilling experience available.
In reading through the comments section, it seems the recommendations have shifted over time. As it stands today, which smoker would you go with and why: GMG Jim Bowie, Traeger Pro 34, or the RecTec? I like the cooking space of the Traeger Pro 34, but the other 2 seem to have more bells and whistles. I’ve been smoking about 5yrs, so not a pro but not a beginner. Currently have a 10+ year old Traeger Lil Tex elite hand-me down that is ready to give up the ghost. Would appreciate your thoughts!
Something you may not have read in other Pellet grill reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills

Central to all pellet cookers is a digital controller similar to the controllers on modern indoor ovens. You select a temp you want, and there is an LED display that tells you the actual temp. Some of the controllers also are programmable so you can cook at a certain temp for a determined time. Some have leave-in meat probes that can dial back the ovento a holding temp when the meat hits its mark.

Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.

The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
The Yoder YS640 is 32 inches wide, weighs 313 pounds, and is said to have a cooking range of 150 to 600°F (65 to 315°C). Yoder is known for heavy-duty competition smokers, and the thick, 10-gauge-steel cooking chamber on this model is durable and great for heat retention. It comes with a sophisticated proprietary digital controller, which Yoder asserts is not based on any off-the-shelf temperature controller of any sort. Yoder states that it designed the board from scratch around a general-purpose micro-controller chip and wrote its own code from the ground up in an attempt to provide superior flexibility, efficiency, and accuracy.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.
This is a fantastic grill for the money that’s dependable for outdoor cooking and smoking (hence its name, “Camp Chef”). It’s not quite 9.9/10 that is the Camp Chef SmokePro DLX Pellet Grill got, but it has more than enough features and benefits to spare to honor the Camp Chef brand (even though at first glance the PG24 and the SmokePro are practically the same units with color differences).
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
I purchased a Traeger 34 inch smoker a month ago and it has never worked correctly. I called customer service several times and the bottom line is that if I want to have it serviced, I have to load it into my car and drive it to Long Beach. There isn't a service dealer in the entire City of Los Angeles! Going to return it to Home Depot. Buy any smoker other than a Traeger.
On the better models, a temperature probe in the oven area tells the controller what the temperature is and if it is below the target it tells the controller to feed more pellets and air. The best manufacturers, like MAK and Memphis, have designed their own versatile custom controllers that are easy to use and can hold a temperature within 5°F, tighter than many indoor ovens.
BBQ fan – If you’re a more demanding person, grill a lot of different meat using different methods. Then pellet grill will work great for you. Especially when it comes to smoking meat for many hours, all you have to do is set the temperature and do whatever you please in the meantime. You can leave it for the entire day with no worries and after a specified time expect very good results, as a pellet smoker is very good at maintaining desired temperature. To put it shortly, a pellet grill will make it easier for you to prepare a top quality meat at home.

To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.


Traeger sent me replacement; fan motor, auger motor, temp controller, then a whole burner module assembly.  None of these parts helped my problem at all.   After working with them thru about 10 phone calls, I finally talked to a second level supervisor named Jessie.  He agreed my grille wasn't working properly, but would not let me return it.  I told him I would accept a replacement 22 inch grille, which I believed would get up to temperature.  He agreed, but would not agree to refund the $200 difference in price.  I decided to cut my losses and accept this offer.  He said he would call and email back with shipping details.  That was over 2 months ago and no call.  I've since called them 3 times.  The phone help doesn't know Jessie and always claim to leave him a message...but still no call.   I'm way past the time limit to protest the charge with my credit card, so I guess I'm stuck with this piece of junk.  This kind of lack of integrity from a company does not deserve anyone's business.
Larger, more expensive smokers run anywhere up to 900 square inches, which will basically let you feed your whole street. It’s also a whole lot more convenient when you’re planning on cooking multiple things to be able to throw every single sausage, joint of meat and rack of ribs on at once, flip ’em around and move things to the edge when they’re done.
My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!

Joe Traeger designed and developed pellet grills back in 1985 and he patented the design one year after. But these didn’t go into full commercial production until 1988. Because of the patented design, Traeger held a monopoly in the pellet grill market for twenty years. But being a small family-run company, they did not diversify and kept supplying their products only to a select network of stores.
Cleaning up after grilling is every cook’s dreaded part of the process, but this pellet grill simplifies that. Its warming rack comes with a patented ash-catcher system, the Ash Can Cleanout System, that allows for an easier cleanup of the unit. Additionally, it also features a grease drip disposal system that comes with a bucket. You won’t have to waste precious time cleaning up afterward!
From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.
If you have faced or currently face the problem with common things like pellet feed jamming or wear and tear of your smoker, then replacing the exact component will solve your problem. Thus, without changing your whole smoker you can continue with some $40 – $50 changes. It might seem complicated for you if you face a problem with your digital control system. Adding the element of professional knowledge will help tremendously. Solving problem with $150 is much better than spending $500, right?
Grilla Grills are not only great with their puns, but also great with their products. Since we compiled a list of top 10, getting rid of this product from our review was a very difficult choice. Silverbac Pellet Grill, along with several others from our honorable mentions list, has been tied with our advanced pick. Therefore, we were forced to place this on our honorable mentions list. With its traditional barrel-shaped design and astounding colors, they’d look nice in your backyard should they be your top choice.
Coming over to the cooking area, you will find 2 stainless steel grill grates that give you 702 sq. in. of cooking space with an option of the second shelf that makes it 1054 sq. in. Its tall enough for turkeys and large enough to fit 6 large-sized racks of ribs. So, hosting a bunch of people for a BBQ party, and cooking delicious meat for them, would be as easy as it could get.
However, with a pellet smoker, you can ensure that new pellets are being fed into the fire automatically, ensuring that it burns for longer and while it burns, it imparts with its flavors. It doesn’t need to be soaked and fed into a burning pile of coal to work. Above that, sawdust, when separated by the heat and being burned, gets a larger surface area to burn with and thus sends out a bigger burst of flavor per pellet.
Currently, online retailers only have to charge customers sales tax who are located in the same state as the business which takes the original order. Camp Chef main offices and warehouse facilities are located in Utah in addition to Washington State. Therefore, only customers who purchase items from us and are also located in Utah, Colorado, Massachusetts, Indiana, Pennsylvania, and Washington will be charged sales tax.
The best pellet grill smoker has the benefit of being easy to light and easy to use. With a pellet smoker, you put the pellets in the hopper, light the heating unit, and you don’t have to worry about it. Conversely, with a charcoal smoker, you have the struggle to light the charcoal, and then throughout the entire cooking time, you need to check the backup on the unit to make sure that it’s functioning properly.

The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.
×