Wattage – With the right amount of wattage by your side, you will easily reach the temperature required, and it will stay there provided that you are providing enough pellets for it to make use of. Anything north of 1200W will easily be able to cover all your requirements, but as a rule, it’s ideal to be sheltered than sorry, so it can’t hurt to purchase a unit with a bigger Wattage than you might suspect you’ll require.
I've had the Yoder for about 4 years now. Never looked back. It made my old Traeger look like a dime-store trinket. Thick metal. Built like a tank. Hold temps perfectly. I used to monitor grill temp. Realized quickly there was no need. Not even in the wind and cold. Eats less pellets than my old Traeger. Don't get me wrong, the Traeger works great when conditions are perfect, but in Omaha, NE, things are rarely perfect. It's true that compared to an offset you won't realize as strong of smoke flavor. That's good and bad, depending on what you're going for. When you're after dense smoke flavor, a simple smoke tube is all you need to get it to where you need.
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.
Seeking to produce the pellet cooker that is both a great smoker and a powerful grill. The truth is that burning pellets in a controlled way is not the best method for producing high grilling temperatures. Most pellet grills top out at 500 degrees F while the hottest units can hit 600 degrees F. This pellet cooker is in reality, a combination grill with a large smoking space, and a small but powerful direct grilling area. Reasonably priced with quality construction, this is definitely a pellet grill to look at.
The greatest thing about pellet smokers is that you don’t have to do much to get perfectly smoked dishes. Simply set the digital controller to the desired temperature and the smoker will do the rest. These smokers are pretty much set-and-forget, which means that you’ll be able to spend more time with your guests and still serve them food that has wonderful smoked flavor. It’s this convenience that’s led to the recent rise in pellet grills and other electric smokers.
I did a lot looking around at pellet smokers before buying the ys 640. This thing is amazing! I have been cooking BBQ for about 15 years. I owned a Gator pit entertainer which is made in Houston Texas (stick burning pit) and I currently own a $25,000 Ole Hickory Pit EL-EDX which can cook 700 lbs of BBQ at once. I wanted something smaller to cook for family. The ys 640 turns out PERFECT Q every time! The amount of smoke is just right. Plenty of smoke flavor without over smoking which is very easy to do in my other pit. This is an EXCELLENT product which I strongly recommend.
The Rainier is also hearty as hell. It survived banging around in the bed of my truck for four years. And I didn’t exactly baby it, cramming it into the limited storage space in my truck with paddles, helmets, and all manner of gear. But I never worried that it wouldn’t fire up to cook another meal. Once, one of the stubby rubber legs popped off as I was pulling the Rainier out of my truck. The stove sat crooked for a weekend, but I eventually found the leg and simply screwed it back on.
I had an American made Traeger for 6 years and after it rusted out I was looking something built for the long haul. The YS 640 is it. Built like a tank it will hold up for years and the extra steel helps retain the heat. Temperature control is spot on and recoverey after opening the lid is amazing. I thoroughly researched all my options and I could not be happier. I cooked steaks the other night in 40 degree weather and had no issues whatsoever. The grille grates are a must and leave beautiful lines. Before you buy anything else, investigate what the other cookers are made of. There really is no comparison.
With a massive 700 square inches of primary grilling space, this grill impressed us when compared to other Pit Boss grills we reviewed. Its size is large enough to cook for large groups of people. It features a Flame Broiler that uses slide-plates which allow for direct flame grilling, which means you get an even cast-iron cooking each time. If the 700 square inches isn’t enough, you can make use of the additional upper cooking rack space. The racks are made of porcelain-coated cast iron for optimum grilling as well as easier maintenance.
The Camp Chef Griddle FG-26 is well-suited for cooking for larger groups. This Two Burner Griddle is made from heavy gauge polishe...d steel, and it has sides that are slightly inclined, giving the chef more control over the cooking process and surface. This Heavy Gauge Polished Steel Fry Griddle covers two burners, and it comes with handles for convenient carrying. read more
This is the most important aspect you should look into when buying a new pellet grill. You always hear people saying that a product will cost more money if it’s built with better quality materials and that is absolutely true when it comes to pellet grills. Let’s start with the basics – the most common material that is used when producing a pellet grill is steel. There are many different types of steel from high-grade stainless steel to lower grades that aren’t as sturdy. Cheap pellet grills will be constructed of a decent grade of steel when creating the outer appearance so that it’s sharp to look at. However, the inner parts of the grill are made out of lower-grade metals. Do you see the problem here? Even though the grill may look aesthetically pleasing from the outside, these nice looks won’t make up for thelow-quality materials that are used inside. This can quickly lead to the inner components of the grill deteriorating and in need of replacements. This ultimately results in you spending additional money to replace these parts once they are no longer functional.
When you think of a pellet smoker, what comes to mind is the rich taste of BBQ, better manipulation and convenience. These are exactly what the best pellet smoker should give you. To find out the best, among the many out there, you should think of various features. A burner that can give you control, comfort, long service, and great flavor in food is something a top rated pellet smoker should have. Let’s take a look at all the factors you should consider when making your purchase.
Take your outdoor cooking to the next level with Camp Chef's newest and largest Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking. With the extra large grilling area you will be ready to grill for all your family and friends. For best performance use Camp Chef Pellets. Camp Chef pellets burn hotter, meaning they last longer and are purer wood so they leave a better flavor.
4. Temperatures were constantly all over the place. For example, on 70-80 degree days I learned to set my controller at 180 if I wanted to cook at 225-230. It was not uncommon to see temperature swings of +/- 30 degrees. Some Traeger users will tell you "yeah but did you play with the p-settings?" Why? Why would I want to have to constantly adjust a setting to make it hold a temp within +/- 5 degrees. Let's be honest. Most people want to set it and forget it. I fall into that category. This particular problem was so frustrating I went and bought an igrill 2 to monitor the internal smoker temp. As a note to this, I also bought 3 different brand controllers to try and remedy this problem with no success. Beyond frustrating!!
One comment I see a lot in various forums like Pellet Heads Forum is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
Hi there i want to recommend the CAMP CHEF pellet smokers you get the bang for your buck with these smokers i know a lot of you out there are turning up your noses but these smokers have all the extras at a very good price well under a $1000 customer service second to none you get the pellet clean out in the hopper they have a ash tray under the body you just pull a lever and all your burnt ash is cleaned out digital temp for the food digital temp for the chamber lo smoke and high smoke setting and it goes up to 500 degrees at 25 degree increments mine coast me $359 out the door includes shipping it dose a wonderful job holding the temps with a 10 to 15 degrees swing i bought mine at CAMP SAVER.
Pellets work so well with the ease of use of a pellet grill because they’re 100% all-natural. They don’t have binders, chemicals, fillers, or petroleum products within them. They serve as a source of compact energy (8,500 BTU per pound) and smoke flavor. Most importantly, there’s little to no ash from them. Compared to coals, there are no flare-ups involved.
Hello Mark! Thanks for commenting here. The Kalamazoo Hybrid Grill looks like a BEAST! If you can swing it, I’d go for it. I truly enjoyed cooking on the Memphis Grill, which is to date the most high end pellet grill I’ve used. It offered a nice blend of professional grade convection with the wood fire taste of the pellets. The Kalamazoo hybrid really does seem to offer one step beyond with the addition of charcoal and wood chunks. I see that Derrick Riches of About.com stands behind the Kalamazoo brand. You’re hard pressed to get a better endorsement of a grilling product than that! Keep me posted at kevin@bbqbeat.com and let me know how your search goes! 🙂
Most grills feature a primary cooking area (the main grate) and a secondary cooking area (additional racks). In a pellet grill, there’s less difference between the two grilling areas because it mainly cooks by indirect heat, so the temperature is the same throughout the grill. It’s best to pay attention to a pellet grill’s total cooking area because it is the sum of the primary and secondary cooking areas.

Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
The Camp Chef Griddle FG-26 is well-suited for cooking for larger groups. This Two Burner Griddle is made from heavy gauge polishe...d steel, and it has sides that are slightly inclined, giving the chef more control over the cooking process and surface. This Heavy Gauge Polished Steel Fry Griddle covers two burners, and it comes with handles for convenient carrying. read more
WOW, that’s all I got. What an amazing piece of cooking equipment. I’ve owned mine now for a little over a year, and to be honest, each time I use it, I learn something new about it. I’ve cooked on Traeger’s and owned several Bradley smokers. But nothing compares to the versatility of the Yoder. This thing is well made (its heavy) and it cooks flawlessly. The worst thing about it is the need to empty the ashes, and it’s not that big of a deal. I will say, invest the money and buy the heat diffuser with the access door. It makes removing the ashes so much easier. Ask yourself this question, how many different flavors of propane can you use on your grill. Because with all of the different wood options for this, it’s almost limitless. Make the investment, you won’t be sorry
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 – using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Nothing says “you are welcome to my home” than some delicious and succulent baby back ribs; some beer can whole chicken cooked your special spice mix, and some wood smoked salmon. There is no better way to wins the appreciation of your favorite people than cooking up some wood grilled steaks and baked potatoes. But there is a catch, there always is.
Multi-position and digital controllers ( LED display ) - a much better solution, but it does have its flaws. First a multi-position controller, then a digital controller that allows to set the temperature at intervals of +/- 25 degrees F. It’s a controller that also has poor responses to weather. A great advantage of a digital controller is that it allowed to implement other innovative solutions. It helped introduce such technologies as alerts, timer or better meat control.
Now you can control your grill with wifi using the iOS or Android app, so you can attend to other cooking or put your feet up and relax. This grill can use either 110v or 12v and includes adaptors for three different power options. It has legs that fold for transportation, and double as handles, making this ideal for tailgating as well as home cooking.
The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.
Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
Has had auger issues from the beginning and a yr later continues. Once it gets running it does a good job of cooking but it takes average 20 minutes to continually unjamb the auger. Called CS after first use and the issue was recognized and it's looks to be poorly designed with a simi free floating impeller/ auger to keep the impeller from jamming into the side housing and this worked for that issue but now the auger just gets jammed up and I have to empty out the hopper tap on the auger then it will start again till it warms up.
Instead of logs, the pellet smoker is fed with food-grade cylinders of wood pellets that are an inch long and ¼-inch wide and are made of compressed hardwood sawdust. According to the best pellet smoker reviews, pellet grills are easy to use because it’s easier to maintain its temperature because of these sawdust pellets that are subjected to great heat and high pressure, which ignites lignin (natural wood glue).
×