Pellets work so well with the ease of use of a pellet grill because they’re 100% all-natural. They don’t have binders, chemicals, fillers, or petroleum products within them. They serve as a source of compact energy (8,500 BTU per pound) and smoke flavor. Most importantly, there’s little to no ash from them. Compared to coals, there are no flare-ups involved.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
This review is just a repeat of many already submitted.  Got my Traeger Elite 34 this summer at a trade show.  It would not get up to temperature, wouldn't go about 360deg with food inside.  Empty it would hit 390 max.  Most of the 'infamous' Traeger recipes call for 400+.  If you raise the lid, the temp falls to the low 300's and takes 15 minutes to recover.  I called Traeger and they claimed their grills 'never do this'.  After reading dozens of reviews since, the truth is that they seem to 'usually do this'.  The big grilles just do not have enough BTUs to heat up properly.
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
From among these 65 products, we have selected the top class pellet smokers out there shortlisting 18 of the best candidates. Then, we have conducted a secondary research and compared their features against each other to find the best 10. Finally, we have compiled this review list of top 10 best rated pellet smokers considering their features, reviews, ratings, review frequencies and how great they were when we tested them out during BBQ parties.
Hey Tom, first, thank you so much for reading the article and expressing your approval of it. It means a lot to me that the information posted on this site is useful for the people. To your question about pellet grills, yes. You must always use BBQ grilling pellets with these cookers. You cannot use raw wood with them. However, should you find yourself with access too hard woods like Hickory or maple, or fruit woods like apple, cherry, or peach – this is something that could be readily used in a charcoal smoker.
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.
As another one of the most important criteria to consider, we read a lot of the reviews that individuals had to say about the controller system and how simple they are to use. With that said, we can say that all of the grills we have shared have a simple digital controller design that makes the grill simple to use and easy to adjust. Now, the digital controller is the way in which an individual will be able to adjust the temperature of the grill, which can range from an incredibly low temperature to as high as 450 degrees. Now, another really cool aspect of a digital temperature reader is that most brands have an LED display that makes it easy to read the temperature of the grill.
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
You aren’t limited to basic barbecuing. For us, what really stood out was its ability to deliver pro chef-level cooking even at home. This smoker lets you explore all there is about cooking, letting you braise, grill, smoke, bake, roast, braise and BBQ all kinds of food. Using only the best and the purest hardwood pellets, you’re sure to have the juiciest and tastiest meats and vegetables every time you host your outdoor parties. If you think you have to give up quality because of the quantity of foods it can cook, that’s not the case. Quality is maintained whatever it is you’re cooking.
I have owned this pit for over a year and a half now. I previously had a stick smoker which I achieved really good results with but it was time-consuming. But this baby takes it up to a whole new level.everything comes out amazing competition quality. My Family and friends are amazed by these results , The ribs and pulled pork are the best I have ever eaten. My brisket used to always come out average not on this machine.It's extremely juicy and mouthwatering. I would definitely recommend the top shelf and two side probe ports. The heavy duty cover is also top notch I have extremely Highwinds where I live here and the cover works perfect.everything that I have smoked has come out amazing. The juiciest turkey and chicken and even ham first class.I use mine all year even when it's 0° outside just amazed. Pull the trigger and buy this baby you'll never look back. Thank you Yoder for making a great product.
The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.
PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.
Loved the idea of a "pellet smoker" - less stress, delicious meat. Bought mine at Costco 1 year ago and have used it many times with mixed results, not exactly stress less. Last time using it the pellet hopper caught on fire, turns out the auger chamber is packed full of pellets and won't move. Attempted to open chamber to clear and with this model it is extremely difficult (with unit sold thru Costco - newer ones look easier...) so I called customer service hotline. Called different 4 times and talked with a different live person each time and was promised a call back to schedule an in house repair. Never received one call back so I tried to email and again never received a return email. I have no choice but to return smoker to Costco.
I haven’t posted here before, but have been reading and finding a lot of good information on this site. I am in the market for a pellet grill so have been researching some of them listed on this site. Out of Yoder, Green Mountain, Memphis and MAK I really like price, features and looks of the Yoder YS640. I was wondering if anyone has used Louisianna pellet grills? For example, the CS680? I don’t see it mentioned much on bbq blog sites so not sure if it is a good brand. Thanks for any advice.

What’s also really great is that the price isn’t too bad and that most people will be able to afford this product. If you’re not convinced yet you should check out the reviews on Amazon. There’s hundreds of them and most are overwhelmingly positive. If you want to see what other customers are saying about the GMG Davey Crockett Pellet Grill, click below:
Cooking Area – Search for one with a substantial cooking region. Keep in mind that pellet barbecues arrive in an extensive variety of sizes. In this manner, pick a unit that can meet your size necessities in light of its cooking territory. You don’t need to purchase an additional extensive unit in case you’re utilizing the grill for your home. Check for the physical measurements of the item and figure out which one can fit your space and stay aware of your cooking style and lifestyle.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!
After owning this grill for six months I can honestly say I don't regret my purchase. I was waiting for low temp weather to really test this grill and i must be honest i was very surprised. I grilled 400 degrees with the outside temp at 38 degrees and the grill came up to temp within 20 minutes. Last night I started a brisket in 31 degree weather cooking at 225. No problem at all, and I haven't use a thermal jacket. We have done every thing from low and slow to baking and just have been amazed at outcome. Got a couple of more tests that i want to do, but six months, it's great. Stop thinking about it, stop worrying about the price, and prepare to make some great wood fire food.
With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.
Igniter: An igniting rod, heated up to a red hot level, ignites wood pellets as they fall inside the firebox. A cooling fan blows air into the pellet smoker from behind the pellet auger to prevent heat backdraft, while the fan underneath the firebox fans the flame – distributing heat evenly throughout the smoker. This heat is used to smoke and slow cook food in the smoker to give it the best flavors possible.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean. 

SquareTrade Protection Plans are only valid for new or Amazon certified refurbished products purchased at Amazon in the last 30 days. By purchasing this Protection Plan you agree to the Protection Plan Terms & Conditions (http://www.squaretrade.com/terms-standard). Your Protection Plan Terms & Conditions will be delivered via email within 24 hours of purchase
Pellet grills have electronic temperature controls that (should) keep the heat consistent. Top quality pellet grills can maintain temperatures within 5 degrees or less for hours at a time, with the auger releasing pellets as needed into the fire box to do so. A consistent temperature means less guess work and fantastic food! (If you read words like “heat zones” or “baffle”, that means that you’ll need to be playing with the heat to keep it consistent… so steer clear of those!)
Traeger pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger's wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.
Cook bacon and eggs for breakfast and grilled burgers for lunch. Versatility is important when it comes to outdoor cooking and the... Reversible Cast Iron Grill and Griddle can do it all. This cast iron grill/griddle heats evenly and holds heat well, making it easy to cook your food to perfection. Pre-seasoned with Camp Chef's True Seasoned Finish, "this grill/griddle has a natural cooking surface that is ready to use out of the box.Highlights:Double-sided grill/griddle combo lets you griddle breakfast, then flip it over and grill dinnerOut of the box ready to cook in secondsTrue Seasoned Finish cast iron grill/griddle holds the heat and sears the meat to cook betterCast iron grilling ridges allow you to grill like on a BBQMolded on handles for easy gripping while movingFits all Camp Chef 14" & 16" stovesSpecifications:Cooking Surface Dimensions: 14" x 16"Cooking area: 224 sq. in. read more

You can whip up a delicious meal in no time with the Camp Chef Dutch Oven Stand. This cooking stand is especially convenient for t...hose who want to do tabletop cooking, as the stand gets your oven to just the right level so that you can make your food with ease. The heavy-duty steel platform of this Dutch stand ensures durability. This stand is designed to hold a 14 inch Dutch oven and should be placed only on a non-combustible surface. read more
One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.
This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).

From everything I’ve been able to find online, Traeger Pellet Grills appear to be the very first pellet smokers to be offered on the market. Dating back to the early 1980s, Joe Traeger’s company first experimented with using wood pellets as fuel for a BBQ smoker as an offshoot of the home heating furnaces he was selling locally that used pellets. As time passed, a thermostat was added to the equation, and the production BBQ smokers fueled by pellets working in “set it and forget it” fashion was in full force. From this point, several manufacturers of pellet grills began to pop up, with a few key names like Yoder Smokers, Mak Grills, Green Mountain Grills, and Fast Eddy’s Cookshack grills being among the most notable.
The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
Technology is a focus of many pellet grill manufacturers today including features such as Bluetooth temperature controls with an option to download an application on your smartphone. While these features are great, they can sometimes get in the way of the actual materials used to create the structure of the grill. At Grilla Grills, we’ve always put the focus on what we, and our customers, believe are the most important components of the grill. That means you’re paying for high-quality components in the places that tend to be most likely to fail on other cheaper grills, and many in the same price range that have more bells and whistles.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat.

The wood pellet grill features a dual rack design with a 513 square inch main cooking surface and 187 square inch warming rack. With a 20-pound hopper capacity, the grill has plenty of space for wood pellets to keep grilling during long event and parties when you have many mouths to feed. An automatic pellet feeder makes it easy to maintain the desired temperature, so you can focus on just the grilling itself.  


The cooking surface is relatively small – the grill surface 12” x 16” (192 square iches) with the hood being 7” tall at the highest point. This is just big enough to cook some larger cuts of meat like tri-tip or brisket. However, small size is not necessarily a downside. While you won’t host a 4th of July cookout with this pellet grill, the small capacity and the compact size of the Davy Crockett pellet smoker makes it a perfect choice for condo dwellers or for picnics.
Many people misunderstand a pellet grill of consuming a large amount of power for its working. But it is not even remotely true. While it is true that a pellet grill will use up a good amount for power initially, but it only uses that to come to temperature and form. Once it is ready and in form, it power consumption drops so dramatically that some pellet grills use almost as little power as a light bulb; an ideal choice for keeping power costs to a minimum.
Camp Chef have been a notable and solid producer of grills for some time now, and have earned their position in the market, with straightforward, yet proficient outlines, which offer purchasers great outcomes. They had stated, prior to release, that the PG24 Pellet Grill and Smoker, would give clients brilliant elements and a high level of usefulness, with exact temperature readings, and I needed to see whether this genuine. This Camp Chef PG24 Review expects to give purchasers all the data they have to settle on an educated purchasing choice.
Wood pellets are an all natural product. No petroleum products in them, no fillers, chemicals, or binders. They are an excellent source of smoke flavor and compact energy, 8,500 BTU per pound. No hot coals, no flareups. There is also very little ash: 10 pounds of pellets will produce about 1/2 cup of ash. All the rest is converted to energy and combustion gases. I clean out the bottom of the ones I tested after about 10 cooks. At high temps there is very little smoke, at low temps the pellets smolder and produce superb but understated smoke flavors. Click here for more about pellets.
You want even grilling: One of the downsides of using a charcoal grill is ensuring that the entire grilling area is evenly heated. Spreading the charcoal evenly and avoiding hot spots is difficult. Traeger’s pellet grilling system overcomes this problem with a fan that evenly distributes the heat throughout the grilling area, much like a wood-fired oven would have.
With that being said, it’s necessary to understand how much wood pellet would last you and for how long. A 40-pound bag of wood pellets would last you for approximately 24 hours if burned at 250 F. Therefore, if you’re trying to slow-cook a large piece of brisket for 14 hours straight, your 6-9 lb hopper capacity just won’t cut it. You’re going to have to refill it in the middle if you wanted to continue cooking.
A pellet smoker with a primary cooking area of 500 square inches should be sufficient for an average-sized family who wants to have the occasional cookout. If you’re cooking for yourself or a couple, tailgating, or camping, we recommend going for smaller units. It all depends on your needs, keep in mind that bigger doesn’t always mean better. You don’t want to be paying extra money for space you won’t use at all.
×