This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
Hey Shannon – they all have their merits. Budget dictates a lot. If you’re in the $1000 or under range, Green Mountain and Rec Tec are great choices. Both have developed near cult followings, with GMG a little ahead of the curve on that front having been around a bit longer. I love the Yoders as far as moving up on the price range is concerned. Will last you forever and they offer a solid product with great support. MAK grills are just beautifully made. There’s no other way to put it. The “General” models are superbly crafted. Love that MAK offers built in cold smoking as a capability. Am I helping here or just making things worse? Hahaha.
Instead of logs, the pellet smoker is fed with food-grade cylinders of wood pellets that are an inch long and ¼-inch wide and are made of compressed hardwood sawdust. According to the best pellet smoker reviews, pellet grills are easy to use because it’s easier to maintain its temperature because of these sawdust pellets that are subjected to great heat and high pressure, which ignites lignin (natural wood glue).
Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.
Entertaining a large group of people at the barbeque party becomes easy with the Camp Chef Yukon YK60LW 2-Burner Stove. With a coo...king surface of 448 square inches, this camp stove makes it convenient for you to cook for a large or small group of people. This Camp Chef two-burner range stove has removable legs to make for convenient portability - take it along for your camping trips or simply use it for your other outdoor cooking needs. Appliance-style control knobs let you have complete control over the flame, whereas the 3-sided wind screen helps protect the flame from wind. This portable camp stove also comes with a hose and regulator for added convenience. read more

My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.

Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.

We purchased our wood pellet grill (Model TFB57CLB) from Costco in August 2017. It came with one bag of the gourmet blend pellets. We used the Traeger cookbook to try a few different recipes in the fall. Most of these involve a period of smoking followed by a period of grilling. The grill seemed to work fine at first. We used it a couple of times on warmer days in the winter and it had some trouble getting up to the desired heat level. We started using it regularly again in April 2018. I was careful to clean it and check the pellets etc. The smoking feature seemed to work alright, but when I would turn the heat up for grilling, the grill would usually struggle to get much over 225. I would resort to turning it up to 375 or more just to get it to 225 and then often it would sink back down to 180 or 160. I went to the troubleshooting guide on the manufacturer's website and checked all the components, which seemed to be working fine.


To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
Main products of our company :electric, home,toy,clother ,etc. Since its foundation ,the company keeps living up to the belief of ...:"honest selling ,best quality ,people-orientation and benefits to customers. "We are doing everything to offer our customers with best services and best products .We promise that we'll be responsible all the way to the end once our services begin The Stainless Steel Long Spatula is durable and sturdy to handle flipping your heartiest meals. A lengthier, ergonomic handle and a wider and longer blade mean you can flip more at once while controlling larger items easier. Made of durable stainless steel. If you have any further questions, please feel free to contact us. We look forward to serving you in the future. read more
When it comes to the material design of a pellet grill, the material is one of the most important aspects to consider for many reasons. First of all, the material has to be able to withstand extremely high temperatures and also be able to cook properly without the heat escaping the grill. With that said, the exterior or the grill has to be able to withstand high temperatures so the color does not peel, rust, or other defects. With that in mind, we discovered that all pellet grills have to be designed from some of the most important materials in the industry, so they can withstand the test of time. Alongside this, pellet grills are built to last so individuals can enjoy them for years to come. When it comes to the exterior craftsmanship of a pellet grill, the most common material is a powerful steel construction. Steel is also known as one of the most powerful and durable materials in the industry today. However, steel does rust if it is exposed to water. Therefore, many quality brands have powder coated the steel so it can be water resistant and does not rust easily.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
The smart-smoke technology in this grill uses an automatic electric feed system that is able to maintain a constant temperature from 180 to 450 degrees and has a hopper that can hold up to 20 pounds of pellets for extended cooking time. The digital control also handles igniting the pellets while fan-forced convection results in even cooking all around, much like rotisserie-cooked foods.

Central to all pellet cookers is a digital controller similar to the controllers on modern indoor ovens. You select a temp you want, and there is an LED display that tells you the actual temp. Some of the controllers also are programmable so you can cook at a certain temp for a determined time. Some have leave-in meat probes that can dial back the ovento a holding temp when the meat hits its mark.
The SG and ZG are not exactly the same though. Just from the pictures I can see that the bases are different. The SG has L-shaped legs and a bottom shelf while the ZG has square legs that are larger than the DLX legs but no bottom shelf. There were also different specs for many features. I took a picture of the ZG spec sheet at the store and compared it to the SG specs on the website and there are slight differences in capacities. For example ZG 3778 cubic inch - SG 4859, grilling area ZG 776- SG 811, hopper volume ZG 18 lbs - SG 22, ...
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting. 

A pellet smoker with a primary cooking area of 500 square inches should be sufficient for an average-sized family who wants to have the occasional cookout. If you’re cooking for yourself or a couple, tailgating, or camping, we recommend going for smaller units. It all depends on your needs, keep in mind that bigger doesn’t always mean better. You don’t want to be paying extra money for space you won’t use at all.
If you’re looking for very portable smoker on a budget, we recommend the Davy Crockett by Green Mountain Grills. However, if you’re looking for a small backyard smoker that you can use at the occasional picnic, tailgate, or cul-de-sac party, we recommend the Traeger Tailgater. We think the slight increase in cost is justified by the bigger grill space, which comes in handy if you’re using your smoker frequently or to cook for more than two people.
Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born from love of crisp brick-oven style pizza. It’s been designed with the cooking ability of professional brick ovens but with the accessibility ease and size of a portable grill. Whether you’re holding an impromptu family pizza night inviting the friends over for ...  More + Product Details Close
It is different with REC TEC Wood Pellet Grill, here the solid construction is made of high quality materials. On the outside, high temperature powder coat and porcelain enamel finish. While inside, the manufacturers use stainless steel of very good quality for all the major parts. On the official website, we can read that you can find over 40 pounds of 304 stainless steel parts in this grill ( see for yourself ).
My wife and I were one of the first buyers of the YS640 in 2010. We had owned a couple of gas grills that, of course, eventually rust out. My wife saw the YS640 at the Kansas State Fair and called me and said that I HAD to look at this smoker! At first, the smoker had many problems--inaccurate temps, huge swings in temps, etc. Don and Joe kept working on the problems and installing updates--never charging us for updates or service calls. Finally, in about March of 2011, they installed the update that really was the solution. Since then, the YS640 has been a consistent workhorse that does everything as advertised. Built like a tank. built to last. Don and his staff stuck by his product and by his customers. In this day and age, customer service is uncommon. By the way, I thought the YS480 would have been big enough, but my wife said, "our family isn't getting smaller,".....I'm very glad we got the 640 and the second shelf. I have needed it many times. Thanks Don!
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.
Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.
Technology is a focus of many pellet grill manufacturers today including features such as Bluetooth temperature controls with an option to download an application on your smartphone. While these features are great, they can sometimes get in the way of the actual materials used to create the structure of the grill. At Grilla Grills, we’ve always put the focus on what we, and our customers, believe are the most important components of the grill. That means you’re paying for high-quality components in the places that tend to be most likely to fail on other cheaper grills, and many in the same price range that have more bells and whistles.
The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.

First, you have to figure out what your budget looks like. Of the pellet smokers I cover here, theRec Tec Grill Pellet Smoker is the most economical and best overall value — with solid construction and top end electronics controls. At just under $1,000 it’s a great buy that should last you a very long time. If you can move up from there cost wise, I’d go with the Yoder pellet smoker. While the Rec Tec looks like a beast, the YS640 absolutely IS one. Weighing in at 315 lbs and boasting solid control components and features, you won’t ever need another pellet smoker in your life unless you just want another one.
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.

The lid is a big complaint from some owners. It is thin and easily warped or bent. It can’t be shut very tightly all the time, causing the smoke and the heat to escape. Not only will this affect the flavor of your food, but will also cause a higher pellet consumption. The cost of wood pellets adds up over time, it is not worth burning through bags of them just so you could pay less for a smoker. Despite this flaw, the Camp Chef SmokePro DLX can still grill and smoke your food efficiently.
The higher the temperature range goes, the more your pellet smoker can do. For example, a pellet smoker with a temperature range of 500°F- 700°F is hot enough to sear food and even bake a pizza. Consider getting a good thermometer or even a meat probe so you could have an accurate reading and make sure you are cooking your food at the right temperature.
Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
Rest the cast iron press on your skillet or griddle to warm. Use the press on top of bacon to speed cooking times as it cooks from... both sides. Use as a hot press with your favorite sandwiches to turn them into a hot and melty favorite. The grill lines from the ridged bottom will sear the sandwich for a tasty presentation. The products are covered by the following warranty. Warranty covers all components of the stoves, fire pits, ovens and smokers to be free from defect in materials and workmanship for one year from the day of purchase (excluding finish). All accessories are covered for a full 90 days to be free of defect in materials and workmanship. read more

As you can see in this selection of pellet grill reviews, the act of heating pellets and generating smoke in any pellet smoker is pretty much the same. Yes, some pellet grills use thicker metal, have better thermostats, air flow, racks, drip flow, etc. But the ask any professional BBQ cooker who uses a pellet grill, and they’ll tell you that the quality of your smoke really does come down to the pellets themselves. Here’s what one very astute BBQ pro had to say over at the Pellet Smoke Ring:
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Ninth spot to make it to our compilation of the pellet grill review is the Louisiana pellet grill. It has 2 cooking levels and a total 1061 square inch cooking surface. The Louisiana pellet grill has got porcelain cast iron main grids and porcelain steel removable upper cooking grid. It also has a digital controller centre. This grill weighs around 173 pounds and is made with high quality material that is going to last you a life! 

I have been cooking Southern BBQ for 40 years, my Dad did the same. I have bought ever kind of grill on the market, built many of my own because none of the store bought grills cook very well and don't last because of cheap construction. Had been researching Pellet grills for some time and decided on the YS640. Received the grill yesterday and very impressed on everything from boxing to construction of the grill. Just fired it up to burn it in. Temp stays @350. This grill is well made, USA made ! Which is important to me. Cant wait to cook on it, know it will do the job. Thanks..All Things BBQ.....
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
With a massive 700 square inches of primary grilling space, this grill impressed us when compared to other Pit Boss grills we reviewed. Its size is large enough to cook for large groups of people. It features a Flame Broiler that uses slide-plates which allow for direct flame grilling, which means you get an even cast-iron cooking each time. If the 700 square inches isn’t enough, you can make use of the additional upper cooking rack space. The racks are made of porcelain-coated cast iron for optimum grilling as well as easier maintenance.
Typically, most portable grills would give up certain features just to maintain their portability, but this wood pellet grill from Traeger actually had more than what other top grills have to offer. Out of all of our features, it managed to tick 85% off the review. Its digital controls, versatile cooking features, and decent cooking space (perfect for outdoor adventures) all make it our best portable pick.
You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
Traeger Smoker – Buyer beware. My Traeger stopped working both times I’ve used it. It just stops after about 2 hours. Traeger’s response is their pillory is they don’t make refunds. The nearest service is 3 hours away and it’s just too far for them. They said the solution to it stopping is for me to partially disassemble it when it stops and vacuum out the burner pot. They said they would talk me through some troubleshooting. They offered to send me replacement parts but said they don’t think it will help. I can’t return it, they can’t determine a fix for it. I’m supposed to just eat the $830 cost for a smoker that doesn’t work.
This is the most important aspect you should look into when buying a new pellet grill. You always hear people saying that a product will cost more money if it’s built with better quality materials and that is absolutely true when it comes to pellet grills. Let’s start with the basics – the most common material that is used when producing a pellet grill is steel. There are many different types of steel from high-grade stainless steel to lower grades that aren’t as sturdy. Cheap pellet grills will be constructed of a decent grade of steel when creating the outer appearance so that it’s sharp to look at. However, the inner parts of the grill are made out of lower-grade metals. Do you see the problem here? Even though the grill may look aesthetically pleasing from the outside, these nice looks won’t make up for thelow-quality materials that are used inside. This can quickly lead to the inner components of the grill deteriorating and in need of replacements. This ultimately results in you spending additional money to replace these parts once they are no longer functional.
Hey Todd – what pellet grill do you have? Also, by short cooks, how long are you talking? Have you looked at the burn pot? If it’s overfilled, you may need to vacuum it out, along with the interior of the cooker. Then, put 10 or so pellets into the burn pot and start it up again. See if that helps. There should not be much if any ash in the food chamber area or on the food. At least not in my experience.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
When it comes to buying a new pellet grill, do yourself a favor and conduct some serious research on the grills you are looking to purchase before jumping into it. Just because a pellet grill looks sharp on the outside and has a cheap price tag to go along with it, doesn’t necessarily mean you’ll have spent less money over the course of three or four years compared to buying a well-built pellet grill with a good warranty.
I bought this grill in May 2018. Had to return it to Ace 9 days later because it wouldn’t keep temp or would go out and fill up with pellets. I had to have the GM of Ace fight for me to get a new grill from Traeger. Once I did the new one seemed to work for about a month. Since then this one does the same thing as far as heat and pellets. I thought this thing was supposed to be a set and forget grill. If I don’t watch the heat it will be 200+ degrees over the set heat or sometimes be at ambient temperature and I have to pull me meat, grill and grease tray out so I can empty the heat pot of all the Unburned pellets. This thing is nothing but trouble. Does it cook great meat? Yes! When it works and you babysit it the whole time. On top of that customer service is about as useless as ** on a boar! They will try and tell you it’s something you’ve done wrong. I will be buying another brand smoker and giving this one to someone who like to deal with troubles.

One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.


Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!

Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
First, you have to figure out what your budget looks like. Of the pellet smokers I cover here, theRec Tec Grill Pellet Smoker is the most economical and best overall value — with solid construction and top end electronics controls. At just under $1,000 it’s a great buy that should last you a very long time. If you can move up from there cost wise, I’d go with the Yoder pellet smoker. While the Rec Tec looks like a beast, the YS640 absolutely IS one. Weighing in at 315 lbs and boasting solid control components and features, you won’t ever need another pellet smoker in your life unless you just want another one.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.
Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.
Because most Traeger grills make use of an Ortech digital temperature controller that’s precise within about 15 degrees of your setting, they may not be precise enough for the type of cooking you want to perform. If so, some pellet grill manufacturers, such as MAK, Yader, and Memphis, can give you temperature control within about 5 degrees of the setting. These types of grills use multiple temperature probes inside the cooking area to guarantee the temperature remains consistent. And some of these high-end brands can reach a higher cooking temperature (such as 600 or 700 degrees Fahrenheit) versus the Traeger family of grills (usually around 450 or 500 degrees). Additionally, MAK, Memphis, and Yader grills are made in the United States, while some parts of Traeger grills are made in China. 
×