OK. I’m rambling a bit. To your point regarding Traeger. I think that the models you can buy at big box stores (Costco etc) are OK. I still hear a few complaints about blistering paint etc. But… their Pro Series Models are a different story. The new management at Traeger has come a long way in their efforts to reaffirm the Traeger brand as a legitimate BBQ Pellet Smoker brand that everyone from the backyarder to competition pitmasters can get behind. To that end, they only allow specialty retailers carry the Pro Series models, which are built with a bit more heft and better PID controls, electronics, etc. You can find these at Ace Hardware stores, places like the Whiskey Bent BBQ Supply store we have here in Lakeland, FL (there is now one in Odessa, FL) as well. You can find a Traeger Pro model by going to http://www.traegergrills.com/dealers.


So if you want more of a smoke profile, cook at longer and lower temps in your pellet pit. I have found that is the best way to get a more distinct smoke profile in your food. Cook at 180–190 for the first several hours. That probably has the biggest impact. Next, make sure you are using a good, quality hardwood pellet. I can tell you that you will notice a very large difference in the flavor profile between say a Traeger pellet vs. say one of Candy’s [BBQers Delight pellets]. — Read more on PelletSmoking.com
With 440 square inches of cooking space, an auger-fed pellet delivery system, and a digital LED thermostat and controller, your cooking will be simple, whether it’s burgers, a whole turkey, or racks of ribs. The side shelf is a convenient place for cooking tools or plates while the bottom shelf can hold spare bags of pellets or jugs of sauces out of the way.
Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.

Third name to make it to my list of the best pellet grill review is The REC TEC Wood Pellet grill. It has a trademark Smart grill Technology, which maintains precise temperature. This amazing pellet grill has a whopping 702 square inch cooking area, and a 40 pound capacity pellet hopper. It is made out of high quality stainless steel. It comes with a drip pan.
My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
Many products have a problem at some time in their life. My Yoder 640 was one of those products. Here is what is different. You all know that sinking feeling when you have a problem....and get ready to call customer service. We sort of steel ourselves to be prepared for the response....or actually, lack thereof. NOT AT YODER. After fully explaining my problems to Joe, he and his company completely exceeded my expectations. My customer service experience was world class - rivaling famed LL Bean, Amica Insurance and other. This is old honor. They better be careful though.....this kind of customer service is going to create raving customers and more business!~
The Tailgater 20 Series Freestanding Grill is one of the best wood pellet grills from Traeger for those who like to cook away from home. It’s small and lightweight enough that you can load it in your car for tailgating before the big game, cooking while camping or grilling at the park. The ash bucket collects all ash created, which makes cleaning up before heading home easier.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment. 

Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.
Hey Tom, first, thank you so much for reading the article and expressing your approval of it. It means a lot to me that the information posted on this site is useful for the people. To your question about pellet grills, yes. You must always use BBQ grilling pellets with these cookers. You cannot use raw wood with them. However, should you find yourself with access too hard woods like Hickory or maple, or fruit woods like apple, cherry, or peach – this is something that could be readily used in a charcoal smoker.
This grill produces fall off the bone ribs. I've also cooked a brisket to perfection. My only issue is that I have to clean it after every use. If it isn't cleaned properly (I remove all of the grates and use a shop vac to suction all ashes and unburned pellets) the pellets will back up and when they finally push through, you will have a huge flare up that will potentially burn whatever you are cooking as well as take the paint off the grill itself. Also, I find it works better if you set the dial to OFF and then back to whatever temperature you want. Other than those few quirks, I love this grill. I did find a larger Pit Boss after I bought this one, but it was about $150 more.
Joe Traeger designed and developed pellet grills back in 1985 and he patented the design one year after. But these didn’t go into full commercial production until 1988. Because of the patented design, Traeger held a monopoly in the pellet grill market for twenty years. But being a small family-run company, they did not diversify and kept supplying their products only to a select network of stores.
I've been using a pellet grill for a LONG time (Traeger for ~15 years?), so I know an upgrade when I see it. I just picked up a YS640, and it's amazing. I love removing the diffuser, adding the Grill Grates, and doing so nice searing! My first cook was a batch of rid eyes, and they were both beautiful as well as delicious. My "guest list" of people wbo want to come over for food keeps growing... Nice problem to have. Good friends, good food, good times.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.
This grill is mounted on a bracket with a sawhorse design with wheels that provide it mobility in all terrains. It has a steel construction with a powder-coated finish, giving it a great look and a sturdy body. It has a hopper capacity of 18 pounds but it’s enough to continuously cook and smoke food in its 380 sq. inches of cooking area. Its porcelain-coated grill grates give you a no-rust and non-stick cooking experience that you won’t forget.

The cooking surface is relatively small – the grill surface 12” x 16” (192 square iches) with the hood being 7” tall at the highest point. This is just big enough to cook some larger cuts of meat like tri-tip or brisket. However, small size is not necessarily a downside. While you won’t host a 4th of July cookout with this pellet grill, the small capacity and the compact size of the Davy Crockett pellet smoker makes it a perfect choice for condo dwellers or for picnics.
×