If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
Three and a half months ago, my fiancée and I loaded all our worldly belongings into a trailer and drove that stuff to our new house in Montana. As one of my most-loved things, the Egg was in there, carefully packed inside and out to make sure no part of it would break. Worrying about it riding back there was one of the reasons my average speed on that drive was just 47 miles per hour. 

The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.
The Davy Crockett Pellet Grill offers open flame technology which uses infrared radiation to cook your food. The peaked lid not only allows for you to cook tall slabs of meat, but it also helps the convection process within the grill, making sure that your meat is thoroughly and evenly cooked. This top notch technology ensures that you get that consistent and authentic tasting BBQ every time you fire up the grill!
The wood pellet grill features a dual rack design with a 513 square inch main cooking surface and 187 square inch warming rack. With a 20-pound hopper capacity, the grill has plenty of space for wood pellets to keep grilling during long event and parties when you have many mouths to feed. An automatic pellet feeder makes it easy to maintain the desired temperature, so you can focus on just the grilling itself.  
Wattage – With the right amount of wattage by your side, you will easily reach the temperature required, and it will stay there provided that you are providing enough pellets for it to make use of. Anything north of 1200W will easily be able to cover all your requirements, but as a rule, it’s ideal to be sheltered than sorry, so it can’t hurt to purchase a unit with a bigger Wattage than you might suspect you’ll require.
Even seemingly perfect pellet grillers have trouble getting the cleanup part right even in light of how little ash is produced by pellets. You should search for pellet smokers and grills that efficiently keep the ash from building up on the heat deflector that’s located underneath the grates. The ash should remain on the ash cup and nowhere else. Meanwhile, major cleanup with soap and water is a hassle that requires an apron and gloves.
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
They are often called grills, but, at the time of this writing, I consider them to be primarily smokers. Almost all of them cook with indirect heat and those that try to grill over direct flame don't do it well. If you love steaks, there are far better ways to cook them. But if you love smoked turkey, ribs, salmon, pork chops, brisket, and smoked foods, a pellet smoker may be the best solution available.
Hi – my husband and I are really interested in a pellet smoker. We came across some when we were at a fair and are trying to find more information about the Traeger brand because the price seems affordable compared to all the others you mentioned. You started out talking about the Traeger but never gave any feedback on it? Little help please:) Thanks!
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
What sets Z Grills apart significantly from the rest of competitive grills is a completely different construction that is more resembling of something like gas grills, which means a door in the front that one can keep grilling accessories behind. Usually most of manufacturers leave the front of the grill open and don’t make use of the space underneath the grill which gives Z Grills huge thumbs up for using this space in a nice and creative way.
Has had auger issues from the beginning and a yr later continues. Once it gets running it does a good job of cooking but it takes average 20 minutes to continually unjamb the auger. Called CS after first use and the issue was recognized and it's looks to be poorly designed with a simi free floating impeller/ auger to keep the impeller from jamming into the side housing and this worked for that issue but now the auger just gets jammed up and I have to empty out the hopper tap on the auger then it will start again till it warms up.
Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
I have the larger Traeger smoker and have really liked it but not from the start. I had issues with the heating unit but the Traeger help people managed to get my “mechanical blondness” through this and all is well. The assistance center people at Traeger weres super supportive so I’m a loyal fan today. One thing I suggested to Traeger, and all who have a Traeger smoker, is to make the grill surface in two parts so it fits into a dishwasher. I cut my grill in half allowing it to fit in my dishwasher. Easy peasy to clean now!
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
Hey Jim, first – thank you for commenting on this post! As you probably know from reading the contents, pellet smokers are a great choice for set it and “nearly” forget it BBQ. Of course, you’re not going to get the same smoke profile with “pellet poopers” that you are likely getting with your other smokers. That said, the smokers listed here are all going to hold temp very well – even in lower temperature or windy weather. I do see instances where temps and wind effects pellet grills, but solutions including a fireproof blanket over the top of the smoker seem to mitigate things well enough.
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
×