Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
The Camp Chef Camp Table is the perfect companion to any table top stove or dutch oven. The camp table will hold two 14 inch dutch... ovens and provides extra preparation and serving space to keep your food up off the ground. Works great with the Mountain Series stoves from Camp Chef and is a great accessory piece to your free standing stove. Side shelves* (Model LS60P) can be added for even more space. read more

For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT

It lowers its temperature by 5° Fahrenheit Increments by lowering the feed rate of the pellets and raises the temp by increasing the feed rate. As for thermostatically controlled grills, the thermostat cycles heat on and off like with the refrigerator as required by your given setting. Some digital temperature controls are so advanced they even include a WiFi setting.


Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.
What sets Z Grills apart significantly from the rest of competitive grills is a completely different construction that is more resembling of something like gas grills, which means a door in the front that one can keep grilling accessories behind. Usually most of manufacturers leave the front of the grill open and don’t make use of the space underneath the grill which gives Z Grills huge thumbs up for using this space in a nice and creative way.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
I only just learned about “wood pellets” recently when my husband and I were researching ways to heat the small mountain cabin we just moved into a few months ago, and I had no idea there were so many options for pellet grills. Wow! I hadn’t even know these existed to consider them, and now your reviews have me wanting to try one out. You’ve offered amazingly detailed and positive information on each model listed to help buyers make an informed decision. Your writing style is so fun and upbeat, I can only imagine that your backyard and backyard gatherings rock! Thanks for giving me food for thought on our next grill, Nate. (And for making me hungry, too! lol)
Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.
Bring the savory simplicity of the SmokePro XT Pellet Grill to your back patio and change the way you cook outdoors. Just like your kitchen oven, the SmokePro XT automatically maintains whatever temperature you set, so you don't have to worry about over or under-cooking your meal. The SmokePro XT Pellet Grill comes standard with Smart Smoke Technology to evenly distribute wood-fired flavor into every bite. Skip the tedious cleaning routine associated with traditional pellet grills thanks to the Simple Ash-Cleanout System. Simply dump the ash after every cook and save yourself hours of cleaning and enjoy better flavor on your next meatsterpiece as a result. The SmokePro XT can tackle anything from fatty pork butts to quick and easy burgers. Shop the Camp Chef SmokePro XT today and see for yourself why Camp Chef is the way to cook outdoors.
Do you enjoy hassle and stress-free living? If you want to enjoy the juicy smoked BBQ ribs with your friends and family without feeling disturbed, then the automatic smoker is the top choice for you. The automatic smoker, a pellet smoker, makes for an ideal choice. Do you know why it has it has earned the reputation of the best among all the easy to use smokers? You will find the automatic features incredibly easy to use and this convenient product’s simplicity stands out.
Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:

The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.
Using accurate digital thermometers to monitor cooking and internal meat temperatures is essential to being all that you can be in the backyard. Unlike the caveman-era heat estimators built into the lids of most grills and smokers, modern pellet smoker LED displays will give you the real story of what's happening in your smoker. Of course, if your smoker doesn't come with a dual-display system that monitors both cooking and meat temps, you'll still need an accurate digital meat thermometer.
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more
A pellet hopper is what you put your pellets in. The grill will automatically help itself from the hopper and use it to maintain the temperature you want it to. More heat requirement will use more pellet, and less heat will use less. What you need to make sure is that you have a good sized pellet hopper so that your grill can keep using from it and you do not have to keep refilling the hopper too often. There are pellet grills out there that are powerful and gentle enough to be cooking for hours, and sometimes overnight, all thanks to its large pellet hoppers that keep replenishing and refueling the fire all throughout.

Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.


Your choice of the pellet can also dictate how much cleanup you’ll have to deal with (even though generally 10 pounds of pellets can produce at most half a cup of ash, but this varies from pellet variant to pellet variant). Just be warned that when the temperature is high, there’s not much smoke happening, so you need to smoke out your meats at lower temperatures to get that smoky flavor.

Besides being able to smoke, roast, sear and bake your food, the Pit Boss 71700FB allows you to do one more thing – directly grill your meat. The unit comes with a flame broiler, a simple slide-plate, which gives you complete control of grilling on direct flame. This is one of the few models that will let you both smoke and grill, and it comes at a great low price.
As another one of the most important criteria to consider, we read a lot of the reviews that individuals had to say about the controller system and how simple they are to use. With that said, we can say that all of the grills we have shared have a simple digital controller design that makes the grill simple to use and easy to adjust. Now, the digital controller is the way in which an individual will be able to adjust the temperature of the grill, which can range from an incredibly low temperature to as high as 450 degrees. Now, another really cool aspect of a digital temperature reader is that most brands have an LED display that makes it easy to read the temperature of the grill.
It is different with REC TEC Wood Pellet Grill, here the solid construction is made of high quality materials. On the outside, high temperature powder coat and porcelain enamel finish. While inside, the manufacturers use stainless steel of very good quality for all the major parts. On the official website, we can read that you can find over 40 pounds of 304 stainless steel parts in this grill ( see for yourself ).

A pellet smoker with a primary cooking area of 500 square inches should be sufficient for an average-sized family who wants to have the occasional cookout. If you’re cooking for yourself or a couple, tailgating, or camping, we recommend going for smaller units. It all depends on your needs, keep in mind that bigger doesn’t always mean better. You don’t want to be paying extra money for space you won’t use at all.
This handsome KitchenAid 36 in. Built-In Island Gas This handsome KitchenAid 36 in. Built-In Island Gas Grill Head is constructed with premium corrosion-resistant materials for durability and ease of upkeep. Boasting 931 sq. in. of total cooking space this unit thrusts up to 71 000 BTUs of fire-roasting energy across four main stainless steel burners one ceramic infrared ...  More + Product Details Close

Please Note: Prices, promotions, styles and availability may vary by store and online. Inventory is sold and received continuously throughout the day; therefore, the quantity shown may not be available when you get to the store. This inventory may include a store display unit. Online orders and products purchased in-store qualify for rebate redemption. Rebates are provided in the form of a Menards® Merchandise Credit Check valid towards purchases at any Menards® retail store. Not valid for purchases on MENARDS.COM®. By submitting this rebate form, you agree to resolve any disputes related to rebate redemption by binding arbitration and you waive any right to file or participate in a class action. Terms and conditions available at www.rebateinternational.com®


Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?

Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
Got the Traeger Pro grill. I was so excited after seeing all of the commercials, unfortunately once I got it together it did not work. No heat on the glow rod no fan nothing. The only thing that worked was the auger and the front panel lights up. Called customer service spent 2 hours on the phone for them to tell me what I already knew they did not work. I told the man on the other end of the line that if it could not work out of the box I did not want it, he stated no returns. Now I am stuck with it. He says, "I will send you the parts needed you can replace them."
Although I marked price high. I would buy it again, tomorrow. I was a novice. I had never smoked anything when I bought this. It is amazing and if you asked my friends and family I should have opened a bar & grill. It's grills better than any gas grill u can buy. The YS640 only gets better with time you get good at using it. It's the best cooker on earth. If your considering paying over $800 for a cooker. Spend the money... you will not regret it. My cousins have Traegers.. and they smeared by them. One weekend at my cabin one has ordered his the other don't have the money yet. I have used it a minimum of 2 days a week and have already got my money out of it by not ruining meat. The guys at Yoder have a monopoly. No one makes a cooker that could stand up to it. THANK YOU YODER. YOU HAVE MADE SOME GREAT HOLIDAY MEMORIES FOR ME AND MY FAMILY. Remember if your on the borderline don't know if it's worth a little more. By the 12th month of owning it. You will look at your wife or girlfriend and say "I'm so glad I spent a little extra and got that. It's beautiful.
With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.
Well, if you get yourself a wood pellet smoker not only you can enjoy such an event in the summer, but also continue doing the same in the winter. Today, pellet smokers often come with the “turbo heating technology” that can help you fire up the grill even in the winter. Go get yourself a pellet smoker and don’t let something as trivial as seasons, limit your enjoyment. Because a smoking warm piece of marbled, top quality fatty meat is best enjoyed on a cold night.
Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.
Hey David – in my opinion, you’re going to find hot spots in any entry level pellet grill/ pellet smoker. I include GMG, Rec-Tec, Traeger, etc. When you start moving into the higher pellet smokers/grills – Memphis Grill, MAK, etc, you can minimize these to some extent. If you experience higher heat on one side, put the thicker cut of meat (pork butt, point of brisket) near that part.
Even and fast cooking – this is the common feedback of the new and past users of this pellet grill cooker. Although some of them would say that the temperature is inaccurate, they can still manage to adjust everything well by means of its digital temperature controller. Additionally, you may need to add more pellets if you will set the temperature on a high setting.
While the Green Mountain Grills Davy Crockett Pellet Grill is compatible with most iOS and Android devices, I want to stress, check the compatibility of your device with the grill before purchasing because it would suck to buy this grill only to find out that this feature is not compatible. Also, if you do not plan on using the grill on some elevated surface, the legs are not tall so the grill sits close to the ground. Regardless, this is a GREAT smoker: your meat will come out tender and juicy with that authentic BBQ taste we all love! Neither of these cons affects the quality of your BBQ and both can be worked around.
I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.
At present, pellet grills are mainstream products, with pellet refills filling the market versus having to find timber, sticks, and charcoal to start a fire (since these pellets are made of sawdust, it’s easier for them to cast fire and completely combust into smoke with minimal residue).  Old school pit masters dislike this product mostly because it’s too easy to use, like a microwave versus an oven.

I spent months checking out Memphis, Fast Eddy, Mak, and Yoder grills. I must say the Yoder is by far the most robust pellet grill of them all. I noticed many reviews with 3 or 4 star ratings for price and I must disagree; fit, finish, build quality, and material robustness of the Yoder was better than the Memphis Pro & Elite...and we all know how expensive the Memphis is.
Multi-position and digital controllers ( LED display ) - a much better solution, but it does have its flaws. First a multi-position controller, then a digital controller that allows to set the temperature at intervals of +/- 25 degrees F. It’s a controller that also has poor responses to weather. A great advantage of a digital controller is that it allowed to implement other innovative solutions. It helped introduce such technologies as alerts, timer or better meat control.
Rec Tec Wood Pellet Grill boasts a cooking area of over 1000 sq. inches. However, that area is calculated from its optional cooking shelf. Without it, the cooking area is roughly around 700 sq. feet. This removable shelf can allow you to increase your cooking area if you’re trying to cook patties, steaks, chicken pieces and items as such; or they can be removed for granting a greater volume of space for smoking brisket or whole turkeys.
Bought a YS-640 in 2012 and have been an avid supporter of Yoder pellet grills. Cooks great and very solid construction. Technical support started out phenomenal but seems to be less competent now. Have replaced the thermocouple every two years, almost to the month (pellet grill gets used 1-2 times per month, at low temp 275 deg F cooks). Really disappointing thermocouple life for a $1500 pellet grill. Still love the way it cooks but I have to keep a spare thermocouple in my tool box so I don't have an issue on my cooks.
You aren’t limited to basic barbecuing. For us, what really stood out was its ability to deliver pro chef-level cooking even at home. This smoker lets you explore all there is about cooking, letting you braise, grill, smoke, bake, roast, braise and BBQ all kinds of food. Using only the best and the purest hardwood pellets, you’re sure to have the juiciest and tastiest meats and vegetables every time you host your outdoor parties. If you think you have to give up quality because of the quantity of foods it can cook, that’s not the case. Quality is maintained whatever it is you’re cooking.
From USA,ItWalmartes to you in New and Fresh state What is an Aebleskiver you ask? The exact description can be found online and i...t says: "Æbleskiver (Danish meaning apple slices in English (singular: æbleskive) are traditional Danish cakes, somewhat similar in texture to American pancakes. A pan with several hemi-spherical indentations in the bottom of the pan. Batter is poured into the indentations and as it begins to cook it is flipped with a skewer to give the cakes their characteristic round shape." They were traditionally cooked with bits of apple (æble) or applesauce inside but these ingredients are not normally included in modern Danish forms of the dish. Æbleskiver are not sweet themselves but are traditionally sprinkled with powdered sugar, aWalmartpanied with raspberry or sometimes strawberry jam. The title you see is what you will get read more
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
You have some solid reviews out there. I have been in pursuit of getting exactly what I want for about 25 years now LOL. Started with a Weber Kettle cooked some great meals on it and made that tasted more like eating a chunk of lump coal 🙁 Over the years I have built a couple 55 gal barrel smokers they were challenging to hold the temp, an old Kenmore stove oven into a propane starter wood smoke unit, a monster 24″ pipeline pipe 5′ long and a warming oven, a 40″ stainless grill made from an industrial engine catalyst that I could direct and indirect cook on and a few other small grills. Working in the oil & gas business and having poor welding skills with a good welding machine in the garage made for some great experiences. Most generally have cooked for 2 to 4 people but have fed up to 70 a time or two.
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
Remote Accessibility: This level of control and observing is critical on the grounds that the container does not generally sustain the pellets into the wood screw accurately and the fire in the firepot can go out. The Davy Crockett will tell you that the container is not sustaining wood pellets and that the temperature is dropping. The Davy Crockett application will reveal to you something isn’t right.
Capacity Just like with other grills, cooking capacity is an important consideration. Will you only be using the grill for family dinners, or will you be hosting backyard parties where you’ll need to feed a crowd? While pellet grills cook food quickly, you don’t want to make your guests wait in line while you’re putting the second wave of burgers on the grill.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
The Rec Tec Bull is built for serious smoking. The stainless steel chamber doesn't have paint that will chip or peel, and the built-in Wi-Fi technology allows you to monitor your cook from anywhere in the house. And with two meat probes you'll have more flexibility when cooking different types of meals. The 40-lb. hopper and interior LED are features the backyard pros will love.

The Pit Boss Grills 340 Wood Pellet Grill is a great grill with dial-in digital control and led read-out. Pellets are 100% natural hardwood. This grill has got an automatic start and cool down. It’s heavy duty with 16 gauge steel construction. It’s easy to assemble. It’s a little expensive. However, other grills are more expensive and seeing that I would recommend this to anyone.

I use to have a charcoal/wood fired smoker and it was a nightmare maintaining temperature especially on a long brisket cook. Instantly I've fallen in love my YS640 coupled with a fireboard. You literally set the temp load it up and walk away with no stress or worries about maintain temperature. It provides great smoke flavor too. Yes it is an expensive purchase but that is because this thing is built like a tank and will last for decades.
For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.

Temperature: Most of all, you have to pay attention to whether your pellet grill maintains a chosen temperature. People buy a pellet smoker because it makes it possible to smoke meat for long at fixed low temperatures. Very convenient and simple, and a grill that always maintains a selected temperature guarantees that the meat will be perfectly cooked.

We ended up going with the Memphis Pro. We were fortunate enough to be able to see all of the manufacturers and models I was most interested in, at Sam’s NW BBQ. (Yoder, MAK, Fast Eddy, GMG’s, a few others, and then, the one we ended up with, Memphis.) Sam took a good amount of time, providing us fantastic information about each model. We ended up with the Memphis Pro for the following reasons: 1) The construction, mainly the double-walled construction; 2) the preciseness of temperature, and being able to hold the temperature (due to reason #1); 3) the extreme ease of changing from smoking to grilling without a lot of effort or reconfiguration; 4) the double hoppers; 5) and another BIGGIE, the fact that grilled or baked foods taste like that, and not like smoked cookies, bread, pizza, etc.


Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
This grill is mounted on a bracket with a sawhorse design with wheels that provide it mobility in all terrains. It has a steel construction with a powder-coated finish, giving it a great look and a sturdy body. It has a hopper capacity of 18 pounds but it’s enough to continuously cook and smoke food in its 380 sq. inches of cooking area. Its porcelain-coated grill grates give you a no-rust and non-stick cooking experience that you won’t forget.
Third, we’re experienced: We have burnt our foods and fingers; and while we were at it, we learned from our mistakes. In doing so, we’ve managed to become the best and mastered the art to perfection. So, we went through the same learning curves that you did or might do. So, we’re aware of the things that matter and we’re going to impart that knowledge with you, so that you don’t make the same mistakes as us.
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.
Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?
Pellet grills have electronic temperature controls that (should) keep the heat consistent. Top quality pellet grills can maintain temperatures within 5 degrees or less for hours at a time, with the auger releasing pellets as needed into the fire box to do so. A consistent temperature means less guess work and fantastic food! (If you read words like “heat zones” or “baffle”, that means that you’ll need to be playing with the heat to keep it consistent… so steer clear of those!)
Make a wealth of delicious recipes while you're camping or tailgating with the help of this versatile 2-Piece Camp Chef Spatula Se...t. The blades are made of sturdy and durable stainless steel and the heavy-duty handles are contoured for ease of use. The pancake flipper in this cooking spatula set has a long surface for large pancakes and a rounded end for easy non-catch flipping. The turner/scraper is beveled for scraping the grill or griddle and cutting while cooking. In addition, each piece features a handy hanging hole that allows you to store without taking much space. This easy to care for set is ideal for use when camping, hunting or barbecuing and grilling in a backyard. read more

If you’re looking for very portable smoker on a budget, we recommend the Davy Crockett by Green Mountain Grills. However, if you’re looking for a small backyard smoker that you can use at the occasional picnic, tailgate, or cul-de-sac party, we recommend the Traeger Tailgater. We think the slight increase in cost is justified by the bigger grill space, which comes in handy if you’re using your smoker frequently or to cook for more than two people.

The Redwood Portable Fire Pit is an upgrade from the original Gas Fire Ring. A taller, more sturdy base stand, safety ring/carry h...andle, matchless ignition, and a laundry list of other features, the Redwood is the next step in portable propane fire pits. Camp Chef Gas Fire Pits are allowed for use in most fire ban restrictions, check with the local Ranger Station before use. read more
Let's just say I really love to cook! Especially BBQ. I've had the YS640 a couple months now and can't say enough great things about it! I've grilled ,smoked and high temp roasted with excellent results! After week's of comparing and watching videos I know I made the right decision. There's just no comparison to the Chinese makes and the over priced stainless steel models. I considered the MAK smokers but at double the price couldn't justify it. For the price and USA build quality there isn't anything that can touch the Yoder!
For as long as I can remember, the REC TEC RT-680 has been setting the standards for the best pellet smokers on the market, which is why REC-TEC is America’s fastest growing Pellet Smoker Company. And when they came up with the 2018 version of the REC TEC Pellet Grill, we knew it was going to be the very best pellet grill any barbecue lover could get their hands on.
The first thing to consider before purchasing a pellet smoker is your budget. This will allow you to buy the best pellet smoker for the money. If you are a beginner, you do not need to get an expensive unit in order to produce results. However, if you have some experience and you want to take your smoking to the next level, you may look into a more expensive model with the goal of getting some of the features you want.
Camp Chef is the company that perfected the pellet grill formula that Traeger made up, hence its introduction of an effective pellet auger that dispenses pellets only when needed and a large capacity hopper that reduces the need for pellet refills (that people find really annoying). It’s economical in terms of fuel rationing even though the griller itself is quite expensive.
The moment we found this as one of our most desired articles, we had to conduct extensive research on what a pellet grill is. With that said, if you are new to the pellet grill industry and want to know what it is, here we go! Pellet grills are often considered, ‘pellet smokers’, due to the construction quality and design. The reason is that pellet grills combine different cooking elements such as charcoal, gas grills, and a conventional kitchen oven. Now, they are fueled by wood pellets, hence the name. With that said, pellet grills can smoke, cook, and grill all in one simple mechanism and design. With an electronic control panel, an individual can control the wood pellets that fuel the fire to regulate airflow and maintain the proper cooking temperature. Did you get that? We hope so because it is time we share with you the criteria to evaluate the best pellet grills.
I have owned a Memphis Elite (built-in) for 16 months now. It is a very high quality product, and couldn’t be easier to use. The direct flame area is arguably a little small (effectively a bit smaller than 1 sq ft), but it does a great job. The temperature control is phenomenal, and includes a meat probe control that can put the grill into “hold” mode once the meat reaches the target internal temperature. A very happy owner here!

The PK-360, with 360 square inches of cooking space, this rust free, cast aluminum charcoal grill is durable and easy to use. Four-way venting means it's easy to set up for two zone cooking with more control than single vent Kamado grills. It is much easier to set up for 2-zone cooking than any round kamado. Beautifully designed and completely portable. Meathead says it is his preferrred grill.
This little smoker is just right for people who want small capacity and/or need a compact device for their condo patios; and despite its small size (or, perhaps, because of it) it's also one of the best pellet smokers for the money. Many of our readers who already have other outdoor cookers like to add Davy Crockett to their lineup, especially if they have everything but a pellet smoker.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.
This is the most important aspect you should look into when buying a new pellet grill. You always hear people saying that a product will cost more money if it’s built with better quality materials and that is absolutely true when it comes to pellet grills. Let’s start with the basics – the most common material that is used when producing a pellet grill is steel. There are many different types of steel from high-grade stainless steel to lower grades that aren’t as sturdy. Cheap pellet grills will be constructed of a decent grade of steel when creating the outer appearance so that it’s sharp to look at. However, the inner parts of the grill are made out of lower-grade metals. Do you see the problem here? Even though the grill may look aesthetically pleasing from the outside, these nice looks won’t make up for thelow-quality materials that are used inside. This can quickly lead to the inner components of the grill deteriorating and in need of replacements. This ultimately results in you spending additional money to replace these parts once they are no longer functional.

Larger, more expensive smokers run anywhere up to 900 square inches, which will basically let you feed your whole street. It’s also a whole lot more convenient when you’re planning on cooking multiple things to be able to throw every single sausage, joint of meat and rack of ribs on at once, flip ’em around and move things to the edge when they’re done.


The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.

The flame broiler uses a digitally controlled burn system. Its Digital Control Center lets you set the temperature ranging from 170F to 600F with ease. The desired temperature is set and maintained through an electric auto-start and fan-forced air mechanism. These, in addition, give that flavorful smoky taste to all of your foods. The auger automatically feeds pellets into the smoker, so you can pretty much let it take care of everything.
For beginner outdoors chefs and guys buying their first smoker, that’s an invaluable bit of knowledge. Knowing that no matter what you do, as long as you follow the standard set up, you’re going to produce professional quality meat with ease, which is why smokers like the ones below are the best choice for anyone looking at buying their first pellet smoker.
"The Camp Chef transaction aligns with Vista Outdoor's strategy to deliver long-term value through acquiring complementary, market-leading brands that will benefit from Vista Outdoor's balance sheet, distribution network, and sales and marketing expertise," said Chairman and Chief Executive Officer Mark DeYoung. "Led by an entrepreneurial management team, Camp Chef has a nimble and responsive product development process. Camp Chef continues to grow its market share in the outdoor cooking category, and the brand serves many of our current consumers who are engaged in a wide variety of outdoor pursuits. Acquiring Camp Chef strengthens our leadership position in outdoor recreation, allows us to enter the growing camping and outdoor cooking market, and the brand's effective multi-product, multi-channel strategy increases our presence across both brick-and-mortar and ecommerce distribution platforms."

Through the years, pellet smokers have gained popularity. The fact that they give you the convenience of being able to hold a barbecue from the comfort of your home is what makes them ideal. However, not all of them will match up to the needs that you have and this is why I put together this guide with reviews. Following this guide, you should be in a position to make a comprehensive decision on the specific model to buy.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
Another thing about pellet smokers which might impress you is that you can also use this type of smoker to grill your food. So, don’t be confused if you come across the term “pellet grill” in this article because it refers to a pellet smoker. When used as a grill, pellet smoker will start up quickly and cook your food with minimal supervision. Depending on your smoker, you can either use the small area above the fuel pot to grill your food or you can put a griddle on the pellet smoker when it is running on high heat.
We have reviewed the best pellet smokers on the market today after doing our extensive comparative research. However, there were some hidden gems that could not make it to our top 10 product list because of one reason or another e.g. due to their high prices, unavailabilities in some regions, and other factors. Also, some just failed to get in our top 10 list only because it was a top 10 list and not a top 20 list. Regardless of the reasons, here are a few honorable mentions that failed to make it to this top 10 best pellet smoker review, but are still worthy in their own rights:
Having the same problem as the rest of the group. Rec Tec, Yoder, Green Mountain, Pellet Pro, or MAK? All seem to be heavy gauge SS, Pellet Pro seems really good value, MAK and Green Mountain seem to have controllers with more features. Have a friend who bought Rec Tec 3 years ago, he cannot say enough about the good customer service and the grill. If you could only buy one (money not the issue among these 5), which one, and why?
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.

I'm using a ThermoWorks "Smoke" thermometer to send smoker temp info while I'm busy doing other things. So much easier to set it and not having to worry about it compared to grilling over charcoal (although I still like to do that for high temp California "BBQ"). Just come back when it's close to being done to give a quick visual check compared to the probe temperature. May consider adding the sear box in the future.


You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.
Cooking surface – Whole 702 square inches at our disposal, which is a lot. But if this is still not enough for you, you can buy a second shelf and expand the cooking surface by extra 352 square inches. That’s the total of 1052 square inches of meat grilling or smoking space. I think when it comes to this pellet grill, you can’t complain about insufficient space.
As I mentioned at the start of this post, there are a few pellet smokers that lead the pack in terms of name recognition. The ones featured here are those that come most highly recommended by friends of mine on the professional BBQ circuits with KCBS and FBA. As such, if you don’t see one of your favorites listed here and would like to offer up a review — please contact me via any of the social media links at the top of this blog’s sidebar, and we’ll see about getting a post up.
They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
×