The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
I have used a pellet smoker for about five years, and looked at, or used, many different brands. I have added auxiliary smoke generators, and tried almost every way possible to create authentic BBQ on a pellet smoker— It can’t be done. When the vendors, or users, refer to subtle smoke they mean virtually no wood flavor. Do yourself a favor and try a simple test: go to a really good BBQ joint, or BBQ competition; try some of their Q and then compare it to pellet meat. There is no comparison. I wanted the pellet unit to produce good Q in the worst way because of the ease. You cannot duplicate the smoke created in a wood, or wood/charcoal firebox with compressed sawdust. It pains me to say it but it is true.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
Is it common to have a lot of ash blowing throughout these pellet smokers? I thought it was supposed to be minimal ash and that it’s supposed to stay in the firepot. I noticed after two short cooks I have ash everywhere. The pellets are Perfect Mix from cookingpellets.com, but by “perfect mix” I don’t think they mean to mix ash from their product with your BBQ. Also, didn’t put off a lot of smoke, and really couldn’t taste any smoke at all.
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
I don’t know why these cookers are referred to as grills. By definition they are not grills. Grilling involves cooking with direct heat and none of the pellet cookers I’ve seen use direct heat; they all use indirect heat. They are more accurately described as smokers/convection ovens. For me what this means is they’re useless for cooking chicken since I like my chicken cooked with crispy/burned skin. I’ve done some experimenting to get the skin to crisp up but always end up with leather skin. They have their place in outdoor cooking but grilling ain’t it. I just bought a Green Mountain and I’m still debating if I’m going to hang on to it. Shame on me for not doing more thorough research first.
Because most Traeger grills make use of an Ortech digital temperature controller that’s precise within about 15 degrees of your setting, they may not be precise enough for the type of cooking you want to perform. If so, some pellet grill manufacturers, such as MAK, Yader, and Memphis, can give you temperature control within about 5 degrees of the setting. These types of grills use multiple temperature probes inside the cooking area to guarantee the temperature remains consistent. And some of these high-end brands can reach a higher cooking temperature (such as 600 or 700 degrees Fahrenheit) versus the Traeger family of grills (usually around 450 or 500 degrees). Additionally, MAK, Memphis, and Yader grills are made in the United States, while some parts of Traeger grills are made in China.
Instead of logs, the pellet smoker is fed with food-grade cylinders of wood pellets that are an inch long and ¼-inch wide and are made of compressed hardwood sawdust. According to the best pellet smoker reviews, pellet grills are easy to use because it’s easier to maintain its temperature because of these sawdust pellets that are subjected to great heat and high pressure, which ignites lignin (natural wood glue).