Thanks for the quick response and advice. I see a pellet pro hopper assembly is around $250 compared to the Memphis pro at over $2000. I didn’t realize that drafting isn’t important for the sake of temp regulation but what about how the smoke travels from the firebox towards the meat? I also would like to include an element of humidity, is simply putting a pan of water in the cooker or is there a better way?
Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.

Between me and my dad we've smoked on many different types of smokers- Lang 60 stick burner, green egg, Weber smokey mountain, Stump's vertical feed. To be perfectly honest, using those you might be able to get slightly better results (perfect bark, smoke ring etc) but at a much higher cost and much much more effort. If you're cooking for family cooking and fun this smoker will produce delicious BBQ just short of competition level but much better than almost any restaurant. If you'd rather turn a knob and drink a beer instead of starting fires for logs or charcoal and still get 90-95% results (I'm a BBQ snob) buy this!
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
Consistency is the key to having the best results. If you want to make a tender brisket, your cooking temperature should be close to 250 F during the entire 12-hour cooking period. The control board is responsible for precision. There are three types of controllers – PID multi-position, non-PID one-touch, and 3-position. Check out the different types of controllers for the one that is right for you.

Pellets work so well with the ease of use of a pellet grill because they’re 100% all-natural. They don’t have binders, chemicals, fillers, or petroleum products within them. They serve as a source of compact energy (8,500 BTU per pound) and smoke flavor. Most importantly, there’s little to no ash from them. Compared to coals, there are no flare-ups involved.
Camp Chef's Woodwind Pellet Smoker is a quality smoker and super searing grill wrapped up in one. As I mentioned above, though pellet smokers are often referred to as pellet grills, most have a limited grilling capability at best. To fill this gap, in 2017, Camp Chef introduced its optional LP gas Sear Box, which can be added to any of its current SmokePro pellet smokers. Woodwind is a package deal that comes standard with the Sear Box and sells for about $50 less than a SmokePro with the optional Sear Box. As a bonus, Camp Chef is one of the few brands on the market with an ash-removal system that deposits ash in a cup under the smoke box for easy disposal.
PID: For the most precise temperature control, some pitmasters feel that a grill with a proportional-integrative-derivative (PID) controller is the way to go. A PID controller uses algorithms to keep the temperature within a couple of degrees of the setting. It doesn’t use fixed cycles to release the pellets. Instead, the controller only adds pellets when it’s necessary to maintain the desired temperature.
Products listed as Out of Stock are currently not in stock at the store(s) being viewed. Note that in some instances, very limited inventory may be available in stores, but because of small quantities we are unable to reflect the availability online. Please remember to check back – if or when inventory is replenished and available, this will be reflected online.
While using and running a pellet grill is child’s play, catching the right offer on pellet grills can be a hassle for consumers who have little to know clue about it can prove a costly bargain. Knowing your facts prior to buying one is always a good a smart idea. My pellet grill review will do the best it can to educate you on the things you need to look out for when purchasing your perfect grill. Here are a few heads-up:

Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?


While many people enjoy pellet grills, some find it difficult to use pellets to produce true, flavorful steaks and barbecue since the fuel often lacks the same flavors as traditional grills. That smoky, wood flavor many steaks have is not impossible to get with the right pellet grill however. The Z Grills Wood Pellet Grill sports a combined grill/smoker setup with temperature control for the best pellet grilling experience available.
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.
Loved the article and read the entire thing. Thank you so much for taking the time to write such an in-depth piece to help the rest of us out. With that said, I now want one of each!! It’s really so difficult to purchase one without being able to compare the taste side by side for each. We also just bought one of the Traeger’s on the last day of a Costco show. We have LOVED the taste, and aren’t looking back, from a pellet perspective that is. However, we’ve already had a couple of issues that concern me from a longevity and a safety perspective. So we’re going to return it, and ‘upgrade’ to something more substantial. I was leaning pretty hard toward Yoder, and then after reading the article, the Memphis really intrigued me (could have something to do with being born there, and raised on southern pulled pork). And then, Fast Eddy came into the picture. Any advise on how to make a decision without being able to conduct taste comparisons, which is really the most important thing. (We’ve been smoking a brisket and pork shoulders every week, with the occasional steak and veggies. So we’d like something that does both smoking and grilling, so both important, with the smoking component being the feature we’ll use a bit more of.)
Hi Jennifer, the Traeger grill you purchased should serve you well. You can see a picture of one of them installed here. I think this is the grill style you bought. One thing the sites you’ve researched (including my own article above) might not have stressed is that Traeger recently hired a new CEO and is actively working to attain the name, reputation, and reputation for quality that they once had. I’m confident should you have any problems with your unit that they will stand behind it and take care of them for you.
The MAK Pellet Boss will increase or decrease with the press of a button in 5°F increments and has a probe in the oven that keeps the temp pretty solid. As with any thermostatically controlled oven, even your indoor oven, the thermostat cycles heat on or off as needed. So it you set it for 225°F it cycles on til it hits 225°F, then off until it drops to 220°F, then on to 225°F. There are three meat probes and the Boss can be programmed to change the cooker temp when the meat hits a target. I've had one for several years outdoors in the Chicago winters and summers without a cover and no problems.

Pit Boss Wood Pellet Grills are filled by all regular BBQ wood pellets. The computerized control board lights the grill and permits you to set the cooking temperature from 180° to 500°F. Fan constrained convection cooking takes out the requirement for a rotisserie and makes an adaptable situation for grilling, simmering, smoking, braising and preparing. The Pit Boss 340 has 340 sq. in. total cooking surface with porcelain covered cooking grids. With complete structural quality and strength, the Pit Boss 340 is made to last.


When reviewing pellet smokers, we’ve gone through over 1000 different user reviews to get an accurate understanding of how useful the products have been to them. With that primary data in hand, we did an extensive online research on 65 products from 17 different brands popular brands. In fact, we even looked into three less known brands as well, but they failed to stand out. We left no stone unturned.
Bake, braise, grill, smoke, and sear – all of these cooking techniques can be fully experienced by just using one unit of backyard cooker! Yes, you can definitely do different kinds of cooking to your pork, beef, fish, pizza, or pie by just using the Camp Chef Smokepro STX Pellet Grill without burning charcoals and woods to start the cooking process.
For a large-sized smoker, the Camp Chef SmokePro SE delivers excellent, smoky-tasting flavor that even beginners can accomplish. This is largely due to its automatic temperature control features and grease management system, allowing you relax while it cooks for you. With minimal cons (only weight and pellet price), this is a definite hit among professionals and newbies. The SmokePro SE is an unquestionable bang for your buck kind of purchase.

Thank you so much for the kind words! I think you would be very happy with a smaller pellet grill / smoker. The wording changes depending on how you are using the device. For instance, if you are cooking at low temperatures you will get a stronger smoke profile then if you burn a pellet smoker / grill at its higher temperature range. One thing you could do for steaks is cook them at the higher range thus being able to get a sear much like you would on a direct heated Grill service, for instance on your Weber. Another option would be to cook the steak in the reverse see your method, by bringing it up to temperature at a lower smoker setting and adding some smoke flavoring that way, then removing it and bringing the smoker up to its higher settings so you can finish off the steak with some of the effect you would achieve on direct flame. I normally do this by bringing the steaks up to about 15 degrees below where I want them to finish. Then, I finish them off at the higher temperature to where they are about 5 degrees below my target. This usually means a few minutes on each side but I use a Thermapen to be sure.


PG24 by Camp Chef is the best choice for any expert smoker. Its reasonable price and amazing features make it a good prolonged investment. It comes with lots of nifty features that facilitate, smoking, grilling and searing in your backyard. For all these reasons, in our pellet smoker review, we consider this smoker as the top choice for the serious BBQ buffs.
The control panel is simple, uncomplicated and easy to use, no codes of crazy steps to remember. Turn the switch on, set the temp once it lights and you are ready to go. On the outside the controls may look simple but behind the scenes it is working to constantly monitor feed rates and temperatures to lock into your set temperature as close as possible. The longer you cook the smaller the adjustments , making this one of he most consistent cookers on the market.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
×