Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
Meanwhile, it also has a 15-pound pellet capacity comparable to Camp Chef SmokePro (not as large but big enough to eliminate continuous wood pellet refills) and folding legs for better portability. However, certain users who’ve already bought their own REC TEC Grills Mini Portable Pellet Grill have complaints about it, like inconsistent heat distribution of the grill and poor quality control (certain grills break down easily).
Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.
What about temperature control and a digital controller? It is much poorer in this regard than the competitive Camp Chef which is why I decided to give the second place to Z Grills as an alternative to Camp Chef PG24. Therefore the digital controller allows to set the temperature within the range of 180-450 degrees F. A pretty low maximum temperature but it shouldn’t be a problem to enthusiasts of long slow cooking, which usually takes place at lower temperatures.
Remember, you are paying for every little feature, attachments and details on any product. So do not end up paying you inheritance for a feature that you are probably never going to use. Instead, invest on a pellet grill that caters to your needs and has features that will actually enhance your experience when using it. So do not, I repeat: do not, fall for fancy marketing features that sound too drastic.

Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
Camp Chef Stainless Steel with Beveled Edge Large Spatula:Larger surface area to better handle larger amounts of foodsSturdy bevel...ed edge perfect for scraping griddlesLarge comfortable handle with hole for easy hangingDurable stainless steel constructionBlade size: 8.5" x 3.75"Blade width: 3.75"Handle length: 8.5"Overall length: 18.5"Blade material: stainless steel90-day limited warrantyModel# SPLG read more

It’s also worth double checking the precision of the controls. Less expensive smokers sometimes have cheap control panels that only allow you to set the temperature to a few discrete settings, for example just low and high. This is, generally speaking, awful, and leads to improperly cooked meat and a whole host of other issues. Avoid it if you can.
The Camp Chef Italia Pizza has all the tools you will need to make you feel like a professional pizza chef. The artisan pizza kit ...includes two pizza peels to move your pizza from the counter to the oven and vice versus. Your pizza will slide right into the pizza oven or stone with ease just like a true artisan. Made of eco-friendly, renewable bamboo. Do not wash in the dishwasher. Dimensions: 11.75 Inch x 19.25 Inch x 0.35 Inch. Weight: 1.3 lbs. read more
Each of the alternatives to the Traeger Pro we’ve reviewed above is an excellent choice for an affordable pellet smoker. We think the Z Grills Master 700D is worth every penny and competes with the Traeger for even less money. We highly recommend you check it out. It has an even larger grill area, a larger hopper, burns just as consistently, and produces some perfectly smoked and grilled meats.
One comment I see a lot in various forums like PelletHeads.com is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
Just what I needed for my Traeger Pro 22. Fits like a glove, simple install, and makes adding and pulling rib racks off the smoker much easier. No longer a balancing act trying to get a tray to stay put on top of the pellet hopper lid. This also fits perfectly under Traeger's cover for the Pro 22 models. Have to be a little care you dont pinch your fingers when folding it down (would be a nice future mod if it could somehow be spring assisted), but thats my only gripe.

Overall, I think you would be happy with the smaller smoker / grill. I really like what Green Mountain grills has done with the Davy Crockett model, and that is the unit I have personally. That said,Rec-Tec makes a great product, and some people prefer the cart stand it comes with rather than the fold up legs that Green Mountain grills uses on the Davy Crockett modeling. Either choice would be good for you if you are looking for a smaller unit. I am of course speaking about the mini version of the Rec-Tec. The larger version is excellent as well.
The digital controller controls temperatures from 150F to 500F in 5-degree increments; that’s the most precise we’ve found on a pellet grill, and gives you a good, precise burn. There’s also Sense-Mate, a thermal sensor that monitors the smoker’s internal temperature, so you can keep an eye on it remotely on your phone via Wifi, letting you adjust the temperature from the app.

The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
Hey Vernon – Yoder warranty is is 1-year on the igniter, 3-years on the control system and 10-years on the cooking body. Products manufactured by Memphis Wood Fire Grills carry a seven (7) year Limited Warranty from the date of purchase by the original owner against defects in material and workmanship. Electronic and electrical components carry a three (3) year replacement warranty when subjected to normal residential use. Limited Warranty does not apply to burn pot, meat probe, grill cover gaskets or damage caused by corrosion. The meat probe is under Warranty for 30 days from the date of purchase. (Both warranty blurbs were pulled from the respective company websites) Yoder: http://www.yodersmokers.com/pellet-frequently-asked-questions.html Memphis Grills: https://memphisgrills.com/warranty/
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
Accurate, powerful, with a lot of options, good build quality and a nice set of features, all at an excellent price, the Camp Chef PG64 is our best overall pellet smoker. Of course, the RecTec still offers more options, but it’s more expensive, so if you want the absolute most for your money, without breaking the bank, you’re going to want to look closely at this.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
From among these 65 products, we have selected the top class pellet smokers out there shortlisting 18 of the best candidates. Then, we have conducted a secondary research and compared their features against each other to find the best 10. Finally, we have compiled this review list of top 10 best rated pellet smokers considering their features, reviews, ratings, review frequencies and how great they were when we tested them out during BBQ parties.
Central to all pellet cookers is a digital controller similar to the controllers on modern indoor ovens. You select a temp you want, and there is an LED display that tells you the actual temp. Some of the controllers also are programmable so you can cook at a certain temp for a determined time. Some have leave-in meat probes that can dial back the ovento a holding temp when the meat hits its mark.
It’s also worth double checking the precision of the controls. Less expensive smokers sometimes have cheap control panels that only allow you to set the temperature to a few discrete settings, for example just low and high. This is, generally speaking, awful, and leads to improperly cooked meat and a whole host of other issues. Avoid it if you can.

Hey Jimmy, thanks for commenting here about your experience. I’m sorry to hear your experience was less than optimal. I have only cooked on the Traeger pro models. I do know that it is good practice to vacuum out the burn pot after cooks of a few hours or more. Not sure this was where your problems were initiated. Did you contact Traeger support? If so, what was their response?
Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
Big Horn’s largest available grill, the XL 1093 comes with a large cooking area of 1093 sq inches. With it’s low price tag of around $300 and a high cooking area, this product could have been a great choice for pellet smokers. However, we’d rather not suggest something that’s susceptible to rust and weather conditions to be kept outdoors at all times.
This pellet grill has a 440 square inch cooking surface and weighs 73 pounds. It measures 36 by 18 by 39 inches in dimensions and is made out of durable steel and heavy duty 16 gauge steel construction. It has a dial-in control with an LED read-out. Its temperature reaches from 180 degrees to 500 degrees Fahrenheit. It also comes with a meat probe. This Pit Boss is a worthy name to be in our pellet grill review’ list.
These food grade wood pellets contain only the best and the pure compressed sawdust from hardwood and are sometimes added with natural vegetable oils, perfectly safe and healthy for your food. However, the carbon in the soot and ashes that fly off the firebox can get embedded into the body of the food, which can get inside your body. The good news is problems such as these can be easily avoided if you can keep your smoker clean.

Kevin- I’m in the process of researching to get my husband a grill for Christmas. I’m torn between the 820 you mentioned above and the Traeger Pro Series. As far as I can tell they are basically the same except that you get a larger cooking area on the pit boss for the same price you pay for a small cook space in a traeger. I would like to spend around $600 on the grill but would possibly go up to $800 and want 500 sq in cook space or greater. Which do you prefer? Pit Boss, Traeger or another brand?
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking. 

This is a fantastic grill for the money that’s dependable for outdoor cooking and smoking (hence its name, “Camp Chef”). It’s not quite 9.9/10 that is the Camp Chef SmokePro DLX Pellet Grill got, but it has more than enough features and benefits to spare to honor the Camp Chef brand (even though at first glance the PG24 and the SmokePro are practically the same units with color differences).
×