Thanks for all the great information. This article was very useful on my most recent purchase. Sorry for the long book but tends to be my style of sharing. Hope others get some use out of my lessons learned. Killing (literally, dried out, burned, inedible) a thousand dollars or so of briskets over the last 20+ years should help some save a little pain as they are stepping out.
Pellets look like rabbit chow. They are about the width of a pencil and as long as a couple of erasers. If they get wet they turn into a pile of sawdust. The beauty of pellets is that they have none of the additives and fillers in charcoal briquets, so they combust almost completely. Almost zero ash. The pellets provide the heat as well as flavor. No need to add wood chips. Surprisingly, they do not produce overly smoky food. If anything, the food is undersmoked to some people because the combustion is so complete.

Third, we’re experienced: We have burnt our foods and fingers; and while we were at it, we learned from our mistakes. In doing so, we’ve managed to become the best and mastered the art to perfection. So, we went through the same learning curves that you did or might do. So, we’re aware of the things that matter and we’re going to impart that knowledge with you, so that you don’t make the same mistakes as us.

Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.
Another option is to put a griddle (or GrillGrates) on the pellet smoker when it's cranked to high heat, get it blistering-hot, add just a little oil to prevent sticking, and sear by conduction on the metal. It should take only two to three minutes per side. This is a good technique for reverse-seared meats: You start them indirect, low and slow on the cooking grate, with a little smoke, and then sear the surface with direct contact to the hot metal griddle to create a delicious brown crust. It's not as good as searing directly over hot coals or gas, but it's a good compromise.

There are no food probes with this controller as there are on the MAK Pellet Boss, and the controller is mounted to the surface with two screws and no gasket so I fear rain could get into the electronics, but after more than a year of sitting out without the cover in rain and snow, the controller on the IPT I tested is still working fine. Ortech recommends covering your smoker.


To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
Thank you for stopping by to read this article pertaining to Pellet Grill Reviews. If you’re here, it’s likely you’ve already read a few reviews about pellet smokers. As such, you’re in the process of figuring out whether Pellet Smokers are a good choice either for personal backyard BBQ cooking or as a means of getting started on the BBQ competition circuit.
Even if you’ve got a meat thermometer at home, it’s not a bad idea to pick up a smoker with one built in. This is because the built in thermometers send their readings straight to the smokers computer and it automatically adjusts how it’s cooking based not just on how hot it is inside, but how this affects what you’re cooking. Now, unless you’re Gordon Ramsey you probably can’t tell what’s going on inside that turkey you’re cooking, so this is obviously a major plus.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.
The Camp Chef Lumberjack Over the Fire Grill is a simple solution for cooking while on a camping trip. Simply place the Camp Chef ...Grill over the campfire coals and get to cooking. The durable plated steel body will stand up to the occasional knocks and bumps that happen outdoors. Foldable legs ensure that this camping grill will pack up quickly and transport easily. The large cooking surface of this Over the Fire Camping Grill is large enough to accommodate almost any camping cooking equipment you might want to use. The steel mesh top on this grill is well-suited for grilling a variety of foods, including steak and vegetables. Whether you are sitting down for a meal after a long day on the trail or you have been out on the lake, the Camp Chef Lumberjack Over The Fire Grill is an smart choice for your campfire grilling needs. read more
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
Three stage controller – there are three options to choose from, smoke ( or low), medium and high. It’s an old and very poor controller. It only has three options to choose from, it’s very poor at maintaining temperature. It doesn’t take weather and other factors into account. The result is that the temperature inside the grill can significantly rise or drop without you knowing. Such solution makes it impossible to set a precise temperature and limits the cooking options.
Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born from love of crisp brick-oven style pizza. It’s been designed with the cooking ability of professional brick ovens but with the accessibility ease and size of a portable grill. Whether you’re holding an impromptu family pizza night inviting the friends over for ...  More + Product Details Close
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users.
You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
It’s built pretty solidly, which is what you want with a portable system as it’s obviously being moved around a lot more. I’d say it’s similar in build quality to the Traeger Junior Elite, which as a top of the line smoker says all that needs to be said. If something does go wrong, there’s a two year warranty. I’d have liked more, but it’s there, and that’s good enough.
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
UPDATE 8/27 - This grill is still performing flawlessly. No error messages, maintains temperatures. I have made homeade pizzas and strombolis on a pizza stone and it actually makes them better than in the oven. Its like a restaurant wood fired pizza. I made a pork butt, beef brisket, bacon wrapped scallops....it just simply cooks everything well. Love my Pit Boss !!
Loved the idea of a "pellet smoker" - less stress, delicious meat. Bought mine at Costco 1 year ago and have used it many times with mixed results, not exactly stress less. Last time using it the pellet hopper caught on fire, turns out the auger chamber is packed full of pellets and won't move. Attempted to open chamber to clear and with this model it is extremely difficult (with unit sold thru Costco - newer ones look easier...) so I called customer service hotline. Called different 4 times and talked with a different live person each time and was promised a call back to schedule an in house repair. Never received one call back so I tried to email and again never received a return email. I have no choice but to return smoker to Costco.

On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.
You aren’t limited to basic barbecuing. For us, what really stood out was its ability to deliver pro chef-level cooking even at home. This smoker lets you explore all there is about cooking, letting you braise, grill, smoke, bake, roast, braise and BBQ all kinds of food. Using only the best and the purest hardwood pellets, you’re sure to have the juiciest and tastiest meats and vegetables every time you host your outdoor parties. If you think you have to give up quality because of the quantity of foods it can cook, that’s not the case. Quality is maintained whatever it is you’re cooking.
One option is to put a griddle or a frying pan on the grill, high heat, get it blistering hot, add just a little oil to prevent stickling, and sear by conduction on the metal. It should only take two to three minutes per side. This is a good technique for reverse seared meats. You start them indirect, low and slow, with a little smoke, and then Maillard the outside in a hot pan or on a griddle. No, it's not cheating. It's making food better.
You can make changes to your order anytime during the checkout process prior to submitting the order. Once you have submitted the order you cannot make any changes through the website. If you have submitted the order in error or need to make a change please contact customer support so we can assist you. Have your order invoice handy so we can more efficiently help you.
All this said, I believe the girls you are looking at already will both provide you with long lasting grilling and smoking satisfaction. Honestly, when you get to a point where are your in the price range that you are in, it’s really hard to choose a bad option with pellet grills. The biggest Advantage you have over the ones you’re looking at and the Yoder models is that they are heavy built giving you excellent heat retention over your Cooks.
The unique TRU-infrared technology cooks meat in an even way and helps to retain moisture. The great thing is there are no flare-ups. There’s a roasting basket for ribs, poultry, and other meat. The roasting basket can hold up to 25 pounds. The cooking area were grilling can be done has 180 in.². You can adjust the temperature, which ranges from 9000 to 18,000 BTUs, in the smoker box in order to add flavor.

Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
I didn’t actually learn to cook—at all—until after college. So my parents, who I now see only once a year or so because they live in France, have never really gotten a chance to try my food. One of the first nights after they flew over to see our home, I cooked them perfect lobster tails on the grill. When a long-lost cousin showed up one day during their visit, I ran to the store, bought two chickens, threw them on the Traeger, and we had a feast. Everyone agreed that those chickens were the moistest and most evenly-cooked they’d ever had. 

From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.
Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.
You have some solid reviews out there. I have been in pursuit of getting exactly what I want for about 25 years now LOL. Started with a Weber Kettle cooked some great meals on it and made that tasted more like eating a chunk of lump coal 🙁 Over the years I have built a couple 55 gal barrel smokers they were challenging to hold the temp, an old Kenmore stove oven into a propane starter wood smoke unit, a monster 24″ pipeline pipe 5′ long and a warming oven, a 40″ stainless grill made from an industrial engine catalyst that I could direct and indirect cook on and a few other small grills. Working in the oil & gas business and having poor welding skills with a good welding machine in the garage made for some great experiences. Most generally have cooked for 2 to 4 people but have fed up to 70 a time or two.
It is different with REC TEC Wood Pellet Grill, here the solid construction is made of high quality materials. On the outside, high temperature powder coat and porcelain enamel finish. While inside, the manufacturers use stainless steel of very good quality for all the major parts. On the official website, we can read that you can find over 40 pounds of 304 stainless steel parts in this grill ( see for yourself ).
We are going to take the guesswork out of it for you. Here at Grills Forever we have seared, smoked and grilled on grill after grill so you can have the latest information on what smokers are the best pellet smoker grills. These best pellet smokers can sear and cook the most delicious foods, they are easy to control and convenient to use. We took all these features and more into consideration while compiling the top 10 wood pellet smoker review.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.
×