Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
With the Yoder YS 640 you won’t have to worry about scooping the ashes anymore. This pellet smoker burns the pellets so efficiently that there will be almost nothing left to clean. All you will have to do is empty the ash tray every now and then and wipe down the grates. You can spray the grates with PAM prior to use which makes clean up even easier.
Pit Boss wood pellet grills make it easy to prepare and serve the finest in wood-fired gourmet goodness. Using 100% all natural cooking-grade wood barbecue pellets for fuel, no gas, propane or charcoal is needed! turn a simple dial to start the grill, and you can sear a steak, bake pizza or cookies, smoke jerky, ribs or brisket, all with natural flavored wood pellets. With a dynamic range of cooking temperature from 180 degree to 500 DegreeF, you have complete control with the turn of a dial. The digital control board, along with the oven-like meat probe, result in precise cooking control. Fan forced convection cooking seals in meat juices and eliminates the need for a rotisserie. The 340 is the smallest in our pit boss wood pellet grange. But it doesn't hold back. It still offers all the great benefits of a pit boss wood pellet grill, just in a smaller package. This is perfect for a small family that wants that 100% natural wood pellet flavor.
love your article and got lots of good info from it….i do have a question tho that i didnt see an answer to…..do pellet grills have to use just pellets?….i have 3 acres full of oak branches that could be shredded. my question is can a pellet grill use home shredded wood chips to burn and cook with or is it mandatory that the fuel be in the pellet state?….would be great if i could find a good use for all these fallen branches….
Cleaning and Maintenance: Keeping the grill clean is critical if you need to get the most out of the unit. Old debris can influence the viability of the unit thus normal cleaning is vital. In addition, while moving it around, take alert not to thump it since it accompanies little legs which can without much of a stretch tip over the unit when thumped.
Hey Kim – thank you for this. I’ve had this happen with numerous pellet smokers, including GMGs. What happens most often when it happens is that I’ve been remiss in properly cleaning the grill out after several uses (vacuuming the fire pot out). This causes the ash etc to cover up the heating rod, thus making the temperature lower than expected. The auger keeps feeding the fire pot to compensate and you get what you’ve described.
Temperature: Most of all, you have to pay attention to whether your pellet grill maintains a chosen temperature. People buy a pellet smoker because it makes it possible to smoke meat for long at fixed low temperatures. Very convenient and simple, and a grill that always maintains a selected temperature guarantees that the meat will be perfectly cooked.
With a temperature probe for the meat inside the chamber, this allows you to keep an eye on the temperature of your meat without opening the grill. Nothing ruins a brisket or roast faster than the griller who constantly fiddles with the meat on the grill. Opening the chamber lets the heat out and that can quickly make for some tough meat. This handy feature takes the guesswork out of how ready your meal is, helping you get the best outcome.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
Download an iOS or Android app and connect using WI-FI. The app enables to do many different things such as remote control of the grill temperature, control of temperature inside the meat or the ability to check the amount of pellets inside the hopper. You can get the temperature higher or lower while away from the grill. You can learn more about how this function works on the manufacturer’s official website.
Camp Chef does offer one key accessory that most other pellet grills don’t have. We’re talking about the SmokePro BBQ Propane Sear Box. Most pellet smokers aren’t that good at searing. However, the Camp Chef made sure to address this issue. The sear box can reach up to 900°F and reverse sear four steaks perfectly. If you’re willing to overlook some inefficiency with the smoker, and searing your meat at high temperatures is important to you, then the Camp Chef SmokePro DLX could be the right smoker for you.
Hey David – in my opinion, you’re going to find hot spots in any entry level pellet grill/ pellet smoker. I include GMG, Rec-Tec, Traeger, etc. When you start moving into the higher pellet smokers/grills – Memphis Grill, MAK, etc, you can minimize these to some extent. If you experience higher heat on one side, put the thicker cut of meat (pork butt, point of brisket) near that part.
So, I say go for the best pellet grill you can get within your budget. I reviewed the little GMG Davy Crockett pellet grill recently and was impressed. At just under $400, it’s a good option. That said, I would like to see them put the unit on fold down legs with casters or some other option to make it easier to move around. You’ll see what I mean in the post. Hope this helps.
If cost isn't an issue, check out the Elite Wood Fire. This 200+ pound behemoth from Memphis Grills costs more than some used cars, but it's fully loaded. Wifi-enabled, an extraordinary temperature range, and a cooking space large enough to be used by a small restaurant - the Elite has it all. The pellet hopper is built to match capacity, with enough fuel space to smoke for up to 62 hours straight.
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.