Worst purchase of a product that I have ever made. After same issues the first and second cookings, I will use my good ole Brinkmann smoker from here on out. Shuts off with errors and after setting it on 250 will climb to over 400-450 degrees. They say you can set it and forget it, but I'm afraid that my home would burn down if I was not here watching over this junk. When you call customer service same old story. Take everything out, clean firepot put it all back together, then fire it back off. Take your screen out of pellet box and rake them. If you want to smoke meat you don't want to do this every 20 minutes or so. I gave over 600.00 dollars for this and have no more than 50.00 in my Brinkmann. Please read all problems with these before wasting your money!!!

****Update 12/2014: So I finally found something negative to report. Today I was cooking 2 pork butts and a brisket and discovered that this grill does not do well with wind on a brisk day (It was 45 degrees here today). When set at 250 degree, the smoker could barely make it up to 190 degrees. I was able to bypass the problem by throwing a cheap moving blanket over the grill (an $8 fix) but I think it's worth noting.
One comment I see a lot in various forums like PelletHeads.com is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.
I have several smokers I have used over the years. I have dialed in everyone I own over a course of trial and error. They all get great results, but require me to tend them all throughout the cook. I wanted a smoker that I could easily get to the desired temp, maintain the temp, provide good smoke flavor, and have the size to do a small or large cook, and not need me to be tending it throughout the cook. The learning curve on this smoker is super easy if you know all your temps, your first cook will give you the results your looking for. I was a little worried that I was not going to get the smoke flavor with a pellet smoker, but my brisket turned out amazing, very tender, the smoke ring was perfect. When I was searching for a new smoker I was a little shy of the Yoder based on the price, but when you figure in the ability to grill as well this became a better alternative. The quality is top tier, this is built to last a long time. I'm so glad I went with the Yoder YS640 no regrets.
Turn it on to "Smoke" mode and use the P settings, or cook mode by selecting a temperature. When you select smoke or a temp setting you start the ignition sequence. The fan, igniter and auger motor turn on. The fan stays on until the smoker is turned off. The auger motor continuously delivers pellets to the red hot igniter rod in the firebox for two minutes under normal conditions. Then the igniter rod shuts off and the pellet fire burns with only the assistance of the auger and the fan.
Traeger Smoker – Buyer beware. My Traeger stopped working both times I’ve used it. It just stops after about 2 hours. Traeger’s response is their pillory is they don’t make refunds. The nearest service is 3 hours away and it’s just too far for them. They said the solution to it stopping is for me to partially disassemble it when it stops and vacuum out the burner pot. They said they would talk me through some troubleshooting. They offered to send me replacement parts but said they don’t think it will help. I can’t return it, they can’t determine a fix for it. I’m supposed to just eat the $830 cost for a smoker that doesn’t work.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.
With the traeger, rec-tec or cam chef smokers all seem to burn 1-2lbs per hour. But for a long 18hr brisket it seems like I will have to continue to use pellets the whole time to keep the heat in range over over 200 which will mean I am using almost a 20-40lb bag depending on the time year per smoke. This is even more expensive than the bradley seems even with the wasted briquette. IS this correct or is there something I am missing?
Despite often being called “pellet grills,” they still cook via indirect heat, as opposed to flame, and are better seen as a smoker. They’re excellent for smoking briskets, chicken and turkey, salmon and other fish, but maybe not for steaks, as you won’t be able to get the same crispy, browned sear they call for, and that you can get with an open-flame grill.
With 440 square inches of cooking space, an auger-fed pellet delivery system, and a digital LED thermostat and controller, your cooking will be simple, whether it’s burgers, a whole turkey, or racks of ribs. The side shelf is a convenient place for cooking tools or plates while the bottom shelf can hold spare bags of pellets or jugs of sauces out of the way.

There is a bit of a learning curve when cooking with pellet grills. This unit can smoke, grill or bake similar to an oven. The Traeger smokes at 180*, but can cook up to 450*. It is indirect heat, so you can grill a ribeye without flare ups. My unit holds temps within 5+/- of the setting. Yes, you do have to clean it like a fireplace, it doesn't run on gas. The build quality is amazing, especially for a PRC manufacture. If you are interested in a pellet grill, buy a pellet cookbook. Something that gives smoke and cook times for an easier introduction into pellet cooking. The only knock against the unit is that for $800 it should have came with the "optional" folding shelf...

My budget range is $1200-$1500. The same as the cost of the XL Primo or BGE. I’ve looked at the Rec-Tec. They look like a great deal. I did notice that they were made in china. Also read they assemble them in Ga. I have concerns with the durability of the lower priced ones. I looked at the Fast Eddie PS 500 also. Now that one is cool. Those are the two I have looked at. The Yoders are getting above what I want to spend.
Hi there i want to recommend the CAMP CHEF pellet smokers you get the bang for your buck with these smokers i know a lot of you out there are turning up your noses but these smokers have all the extras at a very good price well under a $1000 customer service second to none you get the pellet clean out in the hopper they have a ash tray under the body you just pull a lever and all your burnt ash is cleaned out digital temp for the food digital temp for the chamber lo smoke and high smoke setting and it goes up to 500 degrees at 25 degree increments mine coast me $359 out the door includes shipping it dose a wonderful job holding the temps with a 10 to 15 degrees swing i bought mine at CAMP SAVER.
Words like Grilling, Barbecuing and Smoking are often used interchangeably by us. However, when looking at them from a grill master’s point of view, there are some subtle methodological differences among these three: One is done with the lid up, BBQ is done in a closed circulation with the lid down, and smoking is a slow cooking process in a closed circulation.
The Sense-Mate feature is another one of the best additions to this smoker: it is a thermal sensor system that monitors and reads the internal temperature of the grill within 5ºF of the actual temperature! Once you set your desired temperature using its digital controls, the Sense-Mate technology reads and monitors the temperature, while displaying it on the LCD display. Sense-Mate makes sure that heat is kept at a constant temperature, so whether you are cooking at 150ºF or 550ºF, you can rest assured that your meats will be evenly cooked.
I have owned this pit for over a year and a half now. I previously had a stick smoker which I achieved really good results with but it was time-consuming. But this baby takes it up to a whole new level.everything comes out amazing competition quality. My Family and friends are amazed by these results , The ribs and pulled pork are the best I have ever eaten. My brisket used to always come out average not on this machine.It's extremely juicy and mouthwatering. I would definitely recommend the top shelf and two side probe ports. The heavy duty cover is also top notch I have extremely Highwinds where I live here and the cover works perfect.everything that I have smoked has come out amazing. The juiciest turkey and chicken and even ham first class.I use mine all year even when it's 0° outside just amazed. Pull the trigger and buy this baby you'll never look back. Thank you Yoder for making a great product.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.
Grill will not maintain temperature with temperature set at 275 the grill temperature will range from 200 to 320 and this continues throughout the entire time it takes to cook the food. Customer service is giving me the runaround and no resolution has been made. I have been on the phone two times and they say that the pellets are not dropping into the screw. I have done everything they have asked me to do and still have same issue.
Traeger invented the original wood-fired grill over 25 years ago in Mt. Angel, Oregon, and continues to lead the industry as the worlds #1 selling wood-fired grill, perfected by decades of mastering the craft of wood-fired cooking. Fueled by 100% pure hardwood pellets and controlled with a digital controller, means from low and slow to hot and fast grilling, you'll fire up deliciously consistent results every single time. The Texas Elite 34 packs a huge punch with 646 sq. in. of grilling area, new wider legs for added stability, and an upgraded Digital Elite Controller. It combines powerful, wood-fired convection performance with simple operation. So invite the neighbors and taste the wood-fired difference.
×