With a massive 700 square inches of primary grilling space, this grill impressed us when compared to other Pit Boss grills we reviewed. Its size is large enough to cook for large groups of people. It features a Flame Broiler that uses slide-plates which allow for direct flame grilling, which means you get an even cast-iron cooking each time. If the 700 square inches isn’t enough, you can make use of the additional upper cooking rack space. The racks are made of porcelain-coated cast iron for optimum grilling as well as easier maintenance.

Super excited to receive my brand new Traeger Timberline 1300 pellet smoker. When unboxing and putting together I noticed I was unable to attach legs due to damage to the unit. Instead of a nice round hole where legs would go, there was no holes, just where the hole should be smashed together. I instant contact Traeger and sent pictures of the damage requesting a new grill. They would not provide any case number and said they needed to review pictures which would take a few hours. 3 days goes but and no response. I open a PayPal dispute (NOT claim) and they contacted Traeger again. Now they refuse to do Anything unless I close the dispute but if I close dispute, I lose all my consumer protection. They could of handled this situation so much better. I will never purchase a smoker from them again. Horrible customer care.
Main Problem (Product): Main Barrel arrived damaged (bent inward on one end where the open area is located), and the replacement was sent a month and a half later since my purchase. Its an 80 lb. box, with little padding, and all of the components are placed loosely in the barrel. The small tack welds inside for the trip tray arrived broken. (One person struggles with this big heavy box) They would do better by placing more cushion for shipping.
I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
We have shifted to a new house and here we have a very nice backyard. We were thinking of having pellet grill for the backyard for friends and family gatherings for making our holidays memorable. According to your review I think Camp Chef SmokePro DLX Wood Pellet Grill and Smoker | PG24B will be a good option for us. Do you have any other suggestion for us as it will be our first and we don’t have much knowledge about it.
The Memphis Elite is the largest cooker in Memphis Wood Fire Grills' impressive line of luxury pellet smokers. They're extremely well designed and well built. The top-grade 304 stainless steel is thick and extraordinarily well machined. Fit and finish are impeccable. Meathead proclaims Memphis smokers to be "some of the best cookers [he's] ever had the pleasure to use." At $4,999, the Elite is clearly not in everyone's budget, but this beast is impressive enough for us to include in our 2016 Top 10 Luxury Grills and Smokers list, where prices go up to $50,000.
As the last criteria that we took into consideration, we have shared this a couple of times but we really wanted to focus on variety. We not only wanted to share some of the best tops of the line brands in the industry but we also wanted to share brands that may be unknown but offer excellent craftsmanship and material design. For instance, some of the grills we have shared are perfectly designed for everyday use, while some are designed for large events and parties.
WOW, that’s all I got. What an amazing piece of cooking equipment. I’ve owned mine now for a little over a year, and to be honest, each time I use it, I learn something new about it. I’ve cooked on Traeger’s and owned several Bradley smokers. But nothing compares to the versatility of the Yoder. This thing is well made (its heavy) and it cooks flawlessly. The worst thing about it is the need to empty the ashes, and it’s not that big of a deal. I will say, invest the money and buy the heat diffuser with the access door. It makes removing the ashes so much easier. Ask yourself this question, how many different flavors of propane can you use on your grill. Because with all of the different wood options for this, it’s almost limitless. Make the investment, you won’t be sorry
As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)
Wood pellet grill is a two-in-one mixture of a smoker and a grill. It doesn’t provide direct flame for your steaks or meat as a grill would which eliminates flare-ups. Since there’s no direct flame, searing meat isn’t an option and there’s a better choice if this is your desire. However, if you desire a great smoky flavor with an easy cooking process then a pellet smoker is an excellent choice.
The Z Grills Wood Pellet Grill and Smoker comes with Smart Smoke Technology, which lets you set and forget your grilling. It accurately sets and maintains the desired temperature using an automated electric feed system, heating your unit from 180 degrees F to 450 degrees F. We’ve gotten used to smokers taking around 30-40 minutes to heat up, but with this unit, it took only 20 minutes for the temperature to settle in!

Compared with charcoal and other wood-fired grills, pellet smokers are simpler and cleaner and easier, giving more control than traditional smokers. Wood pellets are dense, burn hot and smooth, and can be easily fed into the flame with an automatic auger, allowing for consistent temperature with minimal effort. Many modern smokers let you practically set it and forget it, thanks to their digital controllers. Pellet grills are also efficiently cheap, often using as little as 1lb of pellets an hour.

Thank you so much for this very informative post!! My husband and I just bought the Traeger Select Elite Pellet Grill On Cart yesterday as a somewhat impulsive buy on a Costco shopping trip. It was the last day in the road show so I figured we could always return it if we have buyer’s remorse. Having no past experience with pellet smokers/grills, I am doing my due diligence in researching the reputation of this company and comparing to others in the market. The selling point for us with this particular Traeger grill was the ability to convert this to a built in unit by simply taking off the right side shelf. The sales rep at Costco had a picture of one that his parents had built into an attractive brick surround and we liked the option, however, after reading your post and several other sites, I am finding that Traeger may not be the best investment comparatively and with a purchase this expensive, long-term quality is extremely important to us. In staying within the same price range, I am very interested in the Rec-Tec and it’s stainless steel build. My question is, do you know if the Rec-Tec or another pellet grill @ the $1000 price point can be made to look “built-in” and if so, are there any dangers or potential problems with this.


This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.

Multi-position and digital controllers ( LED display ) - a much better solution, but it does have its flaws. First a multi-position controller, then a digital controller that allows to set the temperature at intervals of +/- 25 degrees F. It’s a controller that also has poor responses to weather. A great advantage of a digital controller is that it allowed to implement other innovative solutions. It helped introduce such technologies as alerts, timer or better meat control.
Pellet smokers heats up faster than charcoal grills, but slower than gas grills. It reaches satisfying temperatures of up to 500 degrees F ( with more expensive models it’s even up to 600 degrees F ), of course it’s much less than gas grills. But the upside is that pellet smoker can maintain low temperatures even at 160 degrees F for many hours. Some of the models are equipped with a gas powered sear box that heats up even up to 900 degrees F.
Up next to find its place in our pellet grill review is the REC TEC’s mini portable pellet grill. It has a 341 square inch cooking surface with 180 degrees to 550 degrees Fahrenheit temperature limit, with 5 degrees increment. But it can easily reach 600 degrees Fahrenheit in full mode. It has a satisfactory pellet hopper capacity and has folding legs. It is great for travel and movement as it is compact and small in size.

The digital controller has a temperature dial (180 F to 400 F), shutdown cycle setting and an on/off switch which is very basic. Compared to the Camp Chef, it misses out on bypass startup button, food probe, feed button, lo smoke/high smoke settings and most importantly access to the fuse. In order to change the fuse in the Traeger, you’ll have to remove both screws on the digital controller and pull out the controller.
The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here. 

The Camp Chef PG24S uses three cleanup and maintenance systems. The Ash Cup Clean Out System collects leftover ash in a cup for easy cleanup. The Grease Management System instantly drains grease into a bucket for easy disposal. Finally, the Pellet Purge System helps you clean out pellets from your auger with ease. Cleaning up has never been so easy.
Louisiana Grills was one of the first companies to muscle in on Traeger's one-brand show. The smallish CS 450 is one of its more popular models. In 2014, Louisiana upgraded all of its pellet smokers to include digital touch-pad controllers with integrated meat probes. Set it and forget it; the thermostat will maintain cooking temperature just like your indoor kitchen oven does. As a safety feature, the meat probe can be set for your desired target temp. When the internal meat temp rises to within 10°F of the target, the controller automatically drops the smoker down to 170°F (77°C) to avoid overcooking.
Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
The built-in cords on outdoor cooking devices are often not long enough, and although regular household extension cords will work for rotisserie kits, they will not carry enough juice to keep you pellet smoker or electric smoker going. They could become a fire hazard as they heat up trying to deliver power to the unit. To extend the cord you need a large capacity cable as measured in amps. Here's how to figure out what you need:
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)
Fast, easy assembly. Was ready to smoke my first three racks of babybacks in less than 90 minutes! And the results were spectacular . . . fall off the bone tender. Doesn't quite develop the deep smoky flavor I enjoy, but makes my wife happy because it doesn't. Happy wife, happy life. Only regret is not being able to dial in the temperature to a specific setting. The calibration seems to be off (low) by 20 degrees or so, and Camp Chef has not responded with an answer to my question about whether there is a way to adjust the calibration more precisely. I'm not sure whether running at a higher temp to achieve the setting I want is actually burning more pellet wood than it should. But 30 pounds of hickory pellets lasted more than 20 hours of smoking at 250-300 degrees on the thermostat (smoked three racks of ribs -- 4 hrs, two pork butts -- 6 hours, 90 pounds of turkey (2 x 25 and 1 x 25 + 1 x 15) -- about 13 hours total). A 12-hour smoke of a whole brisket with Rec-Tec Ultimate pellets at about 250 used about 10 pounds.. Am completely amazed at the small amount of ash left behind -- especially compared to the grilling I do over mesquite charcoal..
Currently, online retailers only have to charge customers sales tax who are located in the same state as the business which takes the original order. Camp Chef main offices and warehouse facilities are located in Utah in addition to Washington State. Therefore, only customers who purchase items from us and are also located in Utah, Colorado, Massachusetts, Indiana, Pennsylvania, and Washington will be charged sales tax.
Loved the article and read the entire thing. Thank you so much for taking the time to write such an in-depth piece to help the rest of us out. With that said, I now want one of each!! It’s really so difficult to purchase one without being able to compare the taste side by side for each. We also just bought one of the Traeger’s on the last day of a Costco show. We have LOVED the taste, and aren’t looking back, from a pellet perspective that is. However, we’ve already had a couple of issues that concern me from a longevity and a safety perspective. So we’re going to return it, and ‘upgrade’ to something more substantial. I was leaning pretty hard toward Yoder, and then after reading the article, the Memphis really intrigued me (could have something to do with being born there, and raised on southern pulled pork). And then, Fast Eddy came into the picture. Any advise on how to make a decision without being able to conduct taste comparisons, which is really the most important thing. (We’ve been smoking a brisket and pork shoulders every week, with the occasional steak and veggies. So we’d like something that does both smoking and grilling, so both important, with the smoking component being the feature we’ll use a bit more of.)
just received my new YS-640 two weeks ago and I absolutely love it. The shipping process and delivery was just as described. The delivery guy unloaded it off the truck, and wheeled the pallet into my garage. Everything was perfect. I am very impressed with the build quality...this thing is a tank. So far have smoked ribs and a brisket, and grilled chicken breasts. The grill heats up much faster than I expected. Temperature holds very steady over the long cooks. I love having the built in probe ports. Still figuring out and tweaking the baffle to control different cooking zones. Only negative thing I say is it can be difficult to manouver in tight quarters because it's so heavy and only the small caster wheels turn. So if you need to move your smoker around a lot, consider the comp cart.

I think you get the picture. In any case, you can see how pellet smoking really does have its own culture to it. I really hope you’ve found value in this selection of Pellet Grill reviews. If so, please consider sharing it with your BBQ friends! And for sure comment below and let me know about your favorite pellet grills, pellet blends, and methods! 🙂

The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.
We have already mentioned this product in our review once and we’re talking about it again. Whenever you are thinking of Green Mountain Grills, Daniel Boone should always be your first choice; it’s simply the best among the GMG products we reviewed. Due to having other products at much lower prices with the same features, we could not include Daniel Boone in this review. We have, however, included the Davy Crockett in our review as our Budget Pick.
The Tailgater 20 Series Freestanding Grill is one of the best wood pellet grills from Traeger for those who like to cook away from home. It’s small and lightweight enough that you can load it in your car for tailgating before the big game, cooking while camping or grilling at the park. The ash bucket collects all ash created, which makes cleaning up before heading home easier.
“We love pellet grills but didn’t like the designs of the models on the market. They are more like an oven than a grill. MAK Grills are designed to be the best in class. You get outstanding BBQ flavor and safe cooking with real wood, along with an automatic lighting and fuel feed system. Simply turn the grill on and you’re cooking in minutes! Our direct heat FlameZone ® feature is pioneering the industry for “gas grill like” cooking without the hassle of flare-ups and burned food.” — MAK Grills

Take your outdoor cooking to the next level with Camp Chef's newest and largest Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. Our patented Ash Can Cleanout System makes clean up the easiest out there. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking. With the extra large grilling area you will be ready to grill for all your family and friends. For best performance use Camp Chef Pellets. Camp Chef pellets burn hotter, meaning they last longer and are purer wood so they leave a better flavor.
You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.

Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
Hey Jay – Yoder makes a great product. Price not being an option, I’d probably go MAK, Memphis Pro (I go back and forth between the two personally!), then the Yoder. I’ve heard good things about the Louisiana pellet grills, just haven’t featured them here so haven’t done a lot of in-depth research. I’m inclined to rate it below the ones I just mentioned – but not by tons. I will say that if American Made is a factor, MAK, Memphis, and Yoder are a go there.
We are going to take the guesswork out of it for you. Here at Grills Forever we have seared, smoked and grilled on grill after grill so you can have the latest information on what smokers are the best pellet smoker grills. These best pellet smokers can sear and cook the most delicious foods, they are easy to control and convenient to use. We took all these features and more into consideration while compiling the top 10 wood pellet smoker review.
Dealers are happily selling these while Traeger is aware per 1-800 call that they need to replace thousands of drip pans/heat exchangers on units that have been shipped because the ones in the units shipped allow heat to fluctuate widely. Traeger recommended NOT USING THIS BRAND NEW GRILL until I receive the replacement part which they will not receive until the last part of August and they will not commit to expedited shipping when they finally ship.

Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
Accurate Temperature Control: The Davy Crockett has better temperature control that permits us to program a great deal more correct temperatures (one-degree changes possible) using their application (the control board permits us to alter temperatures 5 degrees at any given moment). It uses a PID controller […] controller to expect and fine micromanage the temperature by controlling the wood screw speed and the fan speed.
Our Privacy Promise, Terms of Service, Code of Ethics. AmazingRibs.com promises to never sell or distribute any info about you individually without your express permission, and we promise not to, ahem, pepper you with email or make you eat spam. We are GDPR (the General Data Protection Regulations as passed by the European Union). GDPR requires that we be willing to delete any info we have about an EU resident if you request it. We go a step further. We extend this right to anyone, EU resident or not. For more about our privacy promise, code of ethics, terms of service, and how we operate to insure you unbiased info, click here.

Bought the Costco trade show model after about 4 years of debating the purchase... OK, first one broke on day one as "auger" stopped spinning. Returned and received a new unit. 2nd one smoked a turkey for 4.5 hours. After 4 hours temp. dropped to 100 degrees and it was set to 350. When I opened the smoker to check on why this happened, it exploded into a ball of flames! There was fire shooting out from all sides of the grill and smoke and heat coming from the feeder side of the grill... This was SCARY and could have absolutely caused a major fire, and/or injury!!!


Pellet Kettle - compact design with back hopper Pellet Kettle - compact design with back hopper wide range of control from Smoke to 450°. High setting provides 500° plus searing temperatures stainless steel handles open cart with storage shelf large folding side shelf chimney and adjustable damper. Electric power required (110-Volt) has cord wrap locking casters full length ...  More + Product Details Close
Tech geeks: A tech geek will also prefer a Pellet smoker grill and some of the latest grills including Green Mountain Grills came up with some exciting tech functionality like Wi-Fi! Just imagine, hanging with friends and monitoring your pork with your smartphone? You can increase and decrease temperature and control pellet feed without even touching the grill. This gives you the ability to cook while you work!
The seventh pellet grill to achieve its place in our pellet grill review is the YOYO wood pellet grill and smoker. It is a 679 square inch griller (1 cooking surface) with 2 level cooking levels surface. This pellet grill weighs 170 pounds. It maintains temperature from 180 degrees to 475 degrees Fahrenheit. Another feature of this pellet grill is that, it has a digital thermostat controller and comes with the assembly tool kit included.
Some cheaper models, such as the Brinkmann, have a controller with only three settings, Low, Medium, High (LMH), and there is no temperature probe in the oven to create a feedback loop. We do not recommend these units. You actually have less control over temp than you do on a gas or charcoal smoker. The whole reason to buy a pellet grill is because it is set-it-forget-it and it hits a temp and holds it regardless of the ambient air temp outside, winter or summer. On these LMH controllers, the temp fluctuates widely and it cannot correct itself for the weather. They just aren't as smart as a digital device. Whether you're smoking a few slabs of ribs on a scorching summer day, or six pork butts during a blizzard, the three position controller only knows auger on and off times for Low, Medium, and High. It has no information on the temperature inside the cook chamber.
Alex Coleman’s family has been farming in the Piedmont region of North Carolina longer than anybody remembers. The area is famous for “Lexington Style” barbeque, which focuses on pork shoulder barbeque served up with a variety of sauces based on ketchup, vinegar, and peppers. But Alex’s daddy taught him so much more than that about grilling and smoking...Read more
The Pit Boss really is the boss with its 700 square inches of cooking surface. The space alone isn’t what makes the Pit Boss 71700FB one of the best wood pellet smoker available. If you thought the Traeger TFB29LZA Junior Elite Grill had a lot of space at 300 square meters, then get more than double that with Pit Boss (the Rec Tec grill below beats it by only 2 inches).
So after some research I felt like I had two choices. I could either spend $1800 on a new Traeger Timberline and double down on Traeger (hoping like crazy they fixed the heat issue) or spend literally half the money and get the sure thing. And by the way, if you feel like you absolutely Must have wifi to monitor, just buy a Woodwind and an iGrill 2 (wifi enabled) and you'll still save $800!
×