In smoke mode the controller is no longer controlled by the thermometer, it merely switches the pellet feeding auger on and off. On time is 15 seconds, off time ranges from 45 seconds at P0, to 165 seconds at P15. Temp and smoke are controlled by the duration of off time: the auger always runs at the same speed. More smoke is produced at higher P settings and lower temp settings because longer off times allow the pellets to smolder. At P0 in smoke mode or "High" in cook mode the auger replenishes the pellets at a faster rate, creating more flame, less smoke.

If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
My wife and I just purchased a Yoder YS640. After looking at a lot of other smokers we finally settled on this one. It weighs in at over 300 pounds and is built like a tank. You can see and feel the difference between this unit and others. We brought it home, put it together and did the initial burn in for 1 hour. We then made some ribs for dinner. The temp was set and only had 10 degrees fluctuation up or down. The meat was very moist and had just the right amount of smoke flavor. We are very glad we made this purchase.
Pellets are made from different woods, each of which imparts a distinctive flavor to the meat. Hickory, oak, maple, alder, apple, cherry, hazelnut, peach, and mesquite are among the flavors available. For more about pellets, read my article, The Science of Wood. There is a pretty good forum for people who have pellet cookers at PelletSmoking.com and of course our Pitmaster Club has a lively discussion on them with many active users. 

As far as backyard cookers go, Pellet Grills are the newest products on the market. With their roots in the 1970’s, these versatile outdoor grills combine the capabilities of a traditional grill, with the wood-fired flavor of a smoker, and even the convenience of a modern oven. The “Pellet” in the name refers to the specific variety of fuel used. These are specially made cylinders constructed of compressed sawdust. The grill is powered by electricity and doles out specific amounts of pellets to maximize fuel efficiency. The primary benefit of these types of grills is their versatility. Wood pellets can be burned at all different temperatures and volumes, making it possible to sear, smoke, or slow cook a whole array of meats in an infinite variety of styles.


I use to have a charcoal/wood fired smoker and it was a nightmare maintaining temperature especially on a long brisket cook. Instantly I've fallen in love my YS640 coupled with a fireboard. You literally set the temp load it up and walk away with no stress or worries about maintain temperature. It provides great smoke flavor too. Yes it is an expensive purchase but that is because this thing is built like a tank and will last for decades.
I purchased a Traeger Lil Tex 22 yesterday. I “grilled” a whole chicken. It overshot the temperature by nearly a hundred degrees which wasn’t a bad way to crisp up the bird but I was afraid it was going to melt itself down so I shut it down. I was up by 5 this morning to smoke a pork butt for pulled pork sandwiches. My wife’s family is coming over for dinner tonight and time being a concern I fired up the “smoker”. It snowed 12 inches last night so the next hour I was shoveling my walks. Imagine my surprise when I checked on the Traeger and it had shut itself off . The meat was colt to the touch. I read through the instructions to make sure I started it up correctly and I did. I removed the meat and restarted the smoker. It smoked for awhile then quit. The temperature never got above 140. I called Traeger technical support twice and each rep gave me a different answer as to why it wasn’t working. After 3.5 hours I gave up on the Traeger for a more conventional method. I purchased the Traeger for the the set and walk away feature. It let me down!! It is 34 degrees outside today so I will wait until it warms up to try again. Should it fail me again I will sell it for scrap! So far I am not impressed. My wood smoker takes time but it is reliable.
Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.
The single burner Camp Chef Barbecue Box Accessory turns your outdoor gas stove into a portable barbecue grill. This grill system ...will greatly enhance your outdoor cooking experience with a wider variety of meal choices. With the patented diffuser plate you don't have to worry about hot spots. The diffuser captures and vaporizes the grease, infusing your food with a rich BBQ flavor. The cast iron cooking surface holds the heat and sears the meat. A vented lid is included to help keep the heat in. This system covers one burner on the Camp Chef Professional, Sportsman, Outdoorsman, Explorer, and OSD Models. It does not fit the Sport Utility Stove. read more
I live in Florida (Ocala), and I would like to grill, but I am undecided what to buy. I would not use the grill everyday. I am not a ‘griller’, but I do enjoy grilling simple meats, hamburgers, pork tenderloin and chicken; perhaps smoking a 12 lb. turkey for Thanksgiving and Christmas. I have no knowledge as to grill veggies or fish. I am an ignoramus! I tried, but I couldn’t detect them among the ashes!
Something you may not have read in other Pellet smoker reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average. So, if you want to do a pellet smoker cook using 100 percent cherry wood pellets, you’re going to use more fuel than you would with a cherry/hardwood blend, and it’s going to cost you more as well on average.
As another one of the most important criteria to consider, we read a lot of the reviews that individuals had to say about the controller system and how simple they are to use. With that said, we can say that all of the grills we have shared have a simple digital controller design that makes the grill simple to use and easy to adjust. Now, the digital controller is the way in which an individual will be able to adjust the temperature of the grill, which can range from an incredibly low temperature to as high as 450 degrees. Now, another really cool aspect of a digital temperature reader is that most brands have an LED display that makes it easy to read the temperature of the grill.
From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.
The Fast Eddy by Cookshack is an American designed and manufactured Pellet Grill with a riveted stainless steel body and solid digitally controlled system to maintain the consistent temperature. The name of the game here is sturdy reliability. What it lacks in little extras like wifi controls it makes up for inconsistency. Whether you're smoking, grilling, or searing, the Fast Eddy performs.
Most grills feature a primary cooking area (the main grate) and a secondary cooking area (additional racks). In a pellet grill, there’s less difference between the two grilling areas because it mainly cooks by indirect heat, so the temperature is the same throughout the grill. It’s best to pay attention to a pellet grill’s total cooking area because it is the sum of the primary and secondary cooking areas. 
×