From the models and brands that I have reviewed here, I highly recommend the REC TEC 680 Wood Pellet Grill as the best pellet smoker. This comes with a grill technology, which gives you more convenience, whether you are a novice or an experienced grill master. If you have found this article to be helpful, please share it with your friends and family and help them make the right decision.
You want even grilling: One of the downsides of using a charcoal grill is ensuring that the entire grilling area is evenly heated. Spreading the charcoal evenly and avoiding hot spots is difficult. Traeger’s pellet grilling system overcomes this problem with a fan that evenly distributes the heat throughout the grilling area, much like a wood-fired oven would have.
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!

After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.
I would make that decision based upon desired temperature. Very few of the smokers on your list can surpass the 485 to 500 degree mark. You’ll read a lot of discussion about grill grates helping you get into those higher temperatures and that product does work. I would simply pick a smoker that can get to the desired temperature you want like the Louisiana and the Memphis. Both can exceed 500 degrees and both can hit 600 degrees without problems.
The simplicity with which you can use this product is outstanding. From the time that you put it together to the time you smoke meat to the time you clean it, the entire process is extremely simple. It has a power failure restart and a dump tray that can easily be cleaned out. The cooking surface is so large that it is possible to smoke two turkeys at once. 

Thanks for your question! I think you’ve actually selected the grill that I’d recommend too. The Camp Chef pretty much has it all. It’s quality, it’s priced nicely, it does a great job smoking… and honestly, that ash cleanout feature is pretty much something that I wouldn’t want to do without. Especially if you’re new to pellet grilling, anything that makes the job smoother and simpler will be appreciated!
It also has the standardized dial-in digital control with LED readout (not to the point that it has WiFi like the Green Mountain Grills Davy Crockett Pellet Grill, but still quite convenient). However, it’s rated low on this list because of poor quality control. Too many customers ended up with bad Pit Bosses that have inconsistent temperature control (going all the way to 615° Fahrenheit).
Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.
An electric smoker and a pellet smoker, according to the reviews, both allow you to set the temperature and walk away. However, the flavor that you’re going to get from a pellet smoker is a lot stronger as compared to an electric one. Pellet smokers allow you a little bit more versatility than an electric smoker, whereas electric smokers are better at maintaining and controlling the temperature inside the cook box.
Auger Making Weight Noises: It’s usually indicating a problem with the motor that’s responsible for rotating the augers. Under such circumstances, you would be left with no other choice than to replace the motor completely. Since the motors and augers are usually packaged together, this can get quite expensive. In such scenarios, it’s better to let it make noises and run for as long as it would serve you before going to replace it. However, once that problem occurs, you’d often find the auger not feeding the pellets at the expected rate and thus, the desired temperature might not be reached in some cases.
A pellet hopper is what you put your pellets in. The grill will automatically help itself from the hopper and use it to maintain the temperature you want it to. More heat requirement will use more pellet, and less heat will use less. What you need to make sure is that you have a good sized pellet hopper so that your grill can keep using from it and you do not have to keep refilling the hopper too often. There are pellet grills out there that are powerful and gentle enough to be cooking for hours, and sometimes overnight, all thanks to its large pellet hoppers that keep replenishing and refueling the fire all throughout.
So that brings me to the one thing I have learned in all this that I basically read when I was getting started. One of the biggest keys is “Temperature Control”! If you want consistent food make sure you get that under control. It is the key to solid consistent food! Once you get your food consistent you can experiment with a lot of other things. But if you can’t get that down, you will always be looking for another magic bullet. The number one magic is temperature!
Hi i would like to buy my boyfriend a good quality smoker but can’t seem to find one that’s small for people just starting out with smoking for our small backyard. Does anyone have any suggestions? I don’t want to invest too much to start incase it’s too difficult to use or we find we don’t like it. I’ve read some reviews on little smokers that catch on fire and that worries me since we live in a townhouse. I figured someone on here would know of a well made brand that is on the smaller/less expensive side.
When starting on a grilling project, it’s important to know at what temperatures should a food be allowed to settle inside a pellet grill before it reaches its desired doneness. Of course, the time it spends on the grill also plays a major role in it, but you have to understand that cooking on a high heat for long time periods can leave the meat charred while on a low heat can turn it into soft and mushy.
For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
Computers Electronics Appliances Automotive Beauty & Health Furniture Sports & Outdoors Kids Goods Home & Garden Computers Softwares Fitbit Galaxy Gaming Chairs Smartphones Perfumes Shoes Digital Cameras Iphone Headphones Juicers Smart Watches E-Readers Iphone 6 Scooters mopeds Used crossbows Propane gas refrigerator TV Ultra 4k Clothing accessories
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
Once you start paying more than $500, you’re looking at a big boy professional level machine. It’s going to be big enough that you don’t have to worry about having the neighbours over as well as the family. You’re also looking at more expensive sensors and thermostats, so you get a more consistent temperature, which leads to a much better end result, and there’s generally some sort of cleaning assist built in, which makes cleanup and putting it away at night so much easier.
Hey Kevin great article. I too am currently looking for a pellet smoker. I’ve narrowed it down between a Yader, Memphis Pro and the Rec Tec. The Green Mountain did not seem very well built. The wheels looked liked the would break on the first roll and the stainless steel door was flimsy and did not have a good seal. I know the Rec Tec has a 6 year warranty. Do you know how long the warranties are on the other two?
This review is just a repeat of many already submitted.  Got my Traeger Elite 34 this summer at a trade show.  It would not get up to temperature, wouldn't go about 360deg with food inside.  Empty it would hit 390 max.  Most of the 'infamous' Traeger recipes call for 400+.  If you raise the lid, the temp falls to the low 300's and takes 15 minutes to recover.  I called Traeger and they claimed their grills 'never do this'.  After reading dozens of reviews since, the truth is that they seem to 'usually do this'.  The big grilles just do not have enough BTUs to heat up properly.
Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:
Less smoke and less heat – Pellet burners do not produce a strong smokey flavor like stick burners, for example. As we mentioned earlier, they also do not reach the same high temperatures as other types of grills, so you cannot expect great sear marks either. Some model like the Camp Chef PG24 Deluxe let you get around this by purchasing a sear grill attachment.
Something you may not have read in other Pellet smoker reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average. So, if you want to do a pellet smoker cook using 100 percent cherry wood pellets, you’re going to use more fuel than you would with a cherry/hardwood blend, and it’s going to cost you more as well on average.
From USA,ItWalmartes to you in New and Fresh state What is an Aebleskiver you ask? The exact description can be found online and i...t says: "Æbleskiver (Danish meaning apple slices in English (singular: æbleskive) are traditional Danish cakes, somewhat similar in texture to American pancakes. A pan with several hemi-spherical indentations in the bottom of the pan. Batter is poured into the indentations and as it begins to cook it is flipped with a skewer to give the cakes their characteristic round shape." They were traditionally cooked with bits of apple (æble) or applesauce inside but these ingredients are not normally included in modern Danish forms of the dish. Æbleskiver are not sweet themselves but are traditionally sprinkled with powdered sugar, aWalmartpanied with raspberry or sometimes strawberry jam. The title you see is what you will get read more
In my experience, running Traeger pellets, the grill has functionally three temperature settings;  1) Off. This is self explanatory. Looks very pretty on a picnic table in the campground or on your patio table.  2) Hot and Smoky. Wide temperature swings, over-fueling, massive smoke followed by high temps. The controller gets into a "correction induced oscillation" of ever wider swings in temp potentially resulting in either Ler or Her shut downs.  3) Very, Very Hot. This is the high setting where it will run 500+ temps and gets the deflector/drip pan very hot even with the lid open. Burner sounds awesome in Open Lid Mode. Very Macho.

Most pellet smokers are wood-burning ovens: great for ribs, turkey, brisket, and pork shoulders, but not so great for grilling steaks and burgers. The FEC PG series was one of the first lines of pellet burners to offer a sear station, a cast iron cooking grate right over the fire pot where the wood pellets burn. It isn't the best setup for searing, but it's better than most other pellet searing schemes. The real beauty of the Fast Eddy's design is that it produces meat with a deep mahogany finish, much like a competition-grade offset smoker. It also has two upper-level heat zones, for a total of four distinct temperature zones.


Wood pellet grill is a two-in-one mixture of a smoker and a grill. It doesn’t provide direct flame for your steaks or meat as a grill would which eliminates flare-ups. Since there’s no direct flame, searing meat isn’t an option and there’s a better choice if this is your desire. However, if you desire a great smoky flavor with an easy cooking process then a pellet smoker is an excellent choice.
Yoder's Variable Displacement Damper is another unique feature: Essentially, it's a metal plate that may be moved from left to right along the lower smoke box. Positioned all the way left, it concentrates heat directly over the fire pot for conductive searing with optional aluminum GrillGrates. Move it back to the right for even heat across the entire smoke box. Yoders are sold primarily through independent retailers.
×