Hey Jimmy, thanks for commenting here about your experience. I’m sorry to hear your experience was less than optimal. I have only cooked on the Traeger pro models. I do know that it is good practice to vacuum out the burn pot after cooks of a few hours or more. Not sure this was where your problems were initiated. Did you contact Traeger support? If so, what was their response?
According to Bruce Bjorkman of MAK, his cookers use about 1/2 pound of pellets per hour when set on "Smoke" (about 175°F). At 450°F, the high temp, they burn about 2.3 pounds per hour. This is about the same average as I have experienced on a variety of pellet eaters. The burn rate will vary somewhat depending on the outside air temp, and how much cold meat is loaded in the grill, but cooking load should not have a major impact. Cooking pellets run about $1 per pound depending on the wood flavor, brand, if you get them on sale, and if you have to pay shipping. As a point of comparison, Kingsford briquets list for about $0.75 per pound, but they don't pack the same BTUs because there are fillers. I usually buy 40 pound bags of BBQr's Delight pellets from BigPoppaSmokers.com for $45 and shipping is free to IL. That's $1.13 per pound. That means that if I cook a slab of spareribs for six hours at 225°F I will probably burn about 4 pounds at about $4.50. If I put 8 slabs in there in rib holders, and allocate 1/2 slab per person, my cost for 16 people is about $0.28 each. If I grill a mess of chicken parts at about 325°F for about 1 hour, I will use about 1.5 pounds of pellets for a cost of $1.70.
You want even grilling: One of the downsides of using a charcoal grill is ensuring that the entire grilling area is evenly heated. Spreading the charcoal evenly and avoiding hot spots is difficult. Traeger’s pellet grilling system overcomes this problem with a fan that evenly distributes the heat throughout the grilling area, much like a wood-fired oven would have.
I think a lot of reviewers here don't have enough experience in pellet grilling to recognize how many features are packed into this unit for the money. I'm not going to talk about the usual advantages of pellet grilling in general in this review (i.e., clean flavor, "set and forget", less ash,). Instead, I'm going to focus on what makes this one uniquely better than the other grills in it's class.
So which pellet smoker is worth your hard-earned dough? We've put together a list of the ones we think make the cut, organized from lowest to highest price. Sorry for the sticker shock—even a low-priced pellet smoker will cost more than many grills, and our first selection lists at $333. These motorized, digitally controlled devices just plain cost more, but believe you me, they are worth it! And all of these selections have won the AmazingRibs.com Best Value Gold or Silver Medal.

Watch movies outdoors with the Camp Chef Outdoor Movie Screen 144". This product features a 44" (12 ft) diagonal screen with a wid...e screen, 16:9 aspect ratio for optimal image sizing and viewing. The 600D x 600D oxford nylon material offers a striking, quality picture. Protected with a 1" diameter frame and 18-gauge powder-coated steel tubing, this Camp Chef screen is durable for long-lasting use. It also comes with a carrying bag for easy transportation and storage. read more

After about 10-15 hours of cooking, you should remove the burn cup and dump the ash. If the ash builds up it can prevent ignition. Ash also accumulates in the bottom of the unit, but doesn't impact cooking. A vacuum cleaner with a hose makes short work of it. Only a few manufacturers, such as Blaz'n Grill Works and Camp Chef have a slide out combustion cup that makes cleanup much easier, but you still have to get underneath the deflector occasionally and suck out fly ash that has scattered around the lower part of the grill body.

One final word of caution when it comes to pellet pricing.  If you see a price on pellets that seems too good to be true, there’s probably a reason for it. If the pellets you got an amazing deal on creates twice as much ash, doesn’t burn as well, generates wild temp swings and ends up ruining a $65 brisket were they worth it?  What about if that flame out or temp swing cost you a whole pit full of meat and ruined the family reunion the next day?  We are all for saving money as much as anyone, but perspective is key here.  We are in no way saying that great pellets cannot be had for pennies per pound, but we are definitely saying, that if those pennies saved are not on a proven brand that you can trust then it’s probably not a bet worth taking.
The Fast Eddy by Cookshack is an American designed and manufactured Pellet Grill with a riveted stainless steel body and solid digitally controlled system to maintain the consistent temperature. The name of the game here is sturdy reliability. What it lacks in little extras like wifi controls it makes up for inconsistency. Whether you're smoking, grilling, or searing, the Fast Eddy performs.
The single biggest advantage though, especially for beginning outdoor chefs, is that when you’re paying this much, damn near everything is automatic. As an example, if we look at our number one choice, the Camp Chef PG64 pellet smoker, literally everything can be controlled by the built in systems, so I could grab a friend who’d never cooked anything more complicated than boxed mac and cheese over, give em a five minute masterclass and be confident that the automatic systems would do most of the heavy lifting when it came to getting everything right.

Many products have a problem at some time in their life. My Yoder 640 was one of those products. Here is what is different. You all know that sinking feeling when you have a problem....and get ready to call customer service. We sort of steel ourselves to be prepared for the response....or actually, lack thereof. NOT AT YODER. After fully explaining my problems to Joe, he and his company completely exceeded my expectations. My customer service experience was world class - rivaling famed LL Bean, Amica Insurance and other. This is old honor. They better be careful though.....this kind of customer service is going to create raving customers and more business!~
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
The Texas Elite 34 pellet grill is a fairly basic pellet grill that still gives you lots of versatility: you can grill hot and fast, or smoke low and slow, you can bake, braise, roast, or bbq all sorts of food to juicy perfection! Just like an oven, you set the temperature and the Integrated Digital Elite Controller keeps the temp within +/- 20 degrees F for as long as you need it!
Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.
Just started shopping around for a pellet smoker. Am also going to need a new gas grill soon. Stopped in at the local BBQ supply store today and they showed me the Memphis Pro and said it would function well for both smoking and cooking steaks/burgers. Price point on that one is pretty high. Would any of the others reviewed above offer similar functionality? Do you have a recommendation of which will work well for both functions? I live in KS so kind of like the idea of sticking with the local guys from Yoder, but Fast Eddys in OK isn’t too far away either. Thanks.
Through the years, pellet smokers have gained popularity. The fact that they give you the convenience of being able to hold a barbecue from the comfort of your home is what makes them ideal. However, not all of them will match up to the needs that you have and this is why I put together this guide with reviews. Following this guide, you should be in a position to make a comprehensive decision on the specific model to buy.
First one, had an auger problem... told that this never happens. Returned to Costco, now on 2nd Unit. FIRE HAZARD, fire pot overloaded after temp dropped from 375 to 100 on a four-hour turkey. When I opened the lid to see what was going on it EXPLODED into a fireball and then had flames shooting out from all sides of the grill. There was even smoke and heat felt from the firebox side of the grill and it looked as though the overloaded firepot was burning into the auger line as well. DANGEROUS PRODUCT!!!
Traeger pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger's wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
This Bayou Classic outdoor patio stove offers a This Bayou Classic outdoor patio stove offers a wide range of cooking options operating from a bare simmer to a full blast flame. This outdoor grilling alternative is portable enough to take around with you camping tailgating hanging out in the backyard and road tripping in your RV. Despite its ...  More + Product Details Close
If you’re a BBQ fan and you cherish cooking meat, then you may require a grill or a smoker. Similarly, as a kitchen won’t be finished without a microwave, a porch/cultivate/lawn/kitchen won’t likewise be without it. With a Traeger smoker, you can cook sound gourmet sustenance for your children and friends and family. Utilizing it, you likewise spare cash for not expecting to request nourishment and have it conveyed to you now and again.
From grilled beef, salmons to grilled turkeys I love them all. My passion for grilling delicacy gradually built during the time I was living with my parents. My family members especially my mother was a great fan of grilled dishes to and from the love of food. I started preparing smoked food with my mom. This bonding helped me to know more and more about to smoke, grill delicacies and also with smokers. So, in a word you can tell me a BBQ lover.
Worst purchase of a product that I have ever made. After same issues the first and second cookings, I will use my good ole Brinkmann smoker from here on out. Shuts off with errors and after setting it on 250 will climb to over 400-450 degrees. They say you can set it and forget it, but I'm afraid that my home would burn down if I was not here watching over this junk. When you call customer service same old story. Take everything out, clean firepot put it all back together, then fire it back off. Take your screen out of pellet box and rake them. If you want to smoke meat you don't want to do this every 20 minutes or so. I gave over 600.00 dollars for this and have no more than 50.00 in my Brinkmann. Please read all problems with these before wasting your money!!!
The Green Mountain Grills Davy Crockett smoker lets you get more than what you paid for. At a surprisingly low price, you get to have tons of great features commonly found in other GMG products that are sure to elevate your BBQ experience. For its price, we were quite surprised to see that it satisfied most of the features on our review. We tested over fifty products, and even the expensive ones were no match for this product. In terms of value per dollar, this product deserves the top spot.
Hey Ben – thank you for your comment. From a retail user standpoint, I think you’d be happy with either a Yoder or FEC. I really like the PG 500 for the purpose that you’re looking at. Best of both worlds it seems the more I’m looking at it. You can see how they approach grilling steaks in this video. You can incorporate the use of GrillGrates in either pellet grill. Both companies make their units in the USA. Both have great reputations. I’m just partial to Cookshack’s pellet smokers over Yoder as I know more folks who use them.
Like the Z GRILLS Wood Pellet Smoker, the REC TEC Grills Mini Portable Pellet Grill is capable of going up or down by 5° Fahrenheit increments, leading it to heat up from 180° Fahrenheit to 550° Fahrenheit. At full power, it can reach a temperature of 600° Fahrenheit. The mini size is enough to fit in a turkey or maybe three slabs of ribs, so that’s portability without sacrificing quality and capacity too much.
Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.
When buying an item as important as a grill, it is evident that an individual should look for the best quality for what they desire as well as learn properly what are the best in the industry. With that in mind, pellet grills are even more unique than a regular grill because of the design and the way the grill functions. With that said, the quality of a pellet grill is the first criteria we took into consideration because there is a slew of different elements that have to ensure the grill is made of the best possible quality design. With that in mind, one important aspect of quality design that we took into consideration is how all of the functions are built. Meaning, we wanted to make sure that no area was designed and manufactured in a cheap way. Other than that, one method in which we figured out the best quality grills is how the grill cooked and how the items tasted. However, since we cannot buy every single grill and spend weeks cooking steaks and vegetables, as nice as that sounds, we relied a lot on individual reviews and what people had to say about that particular grill.
This smoker is one totally awesome product. It is more that just a smoker, it is a true convection oven, we have baked bread in it! As for being able to hold the temp for low and slow, wonderful. The beef that I smoked was delectable. I just this week smoked 10 venison loins at the same time; it took 1 hour for the most tender, delicious venison I have ever tasted!
Just what I needed for my Traeger Pro 22. Fits like a glove, simple install, and makes adding and pulling rib racks off the smoker much easier. No longer a balancing act trying to get a tray to stay put on top of the pellet hopper lid. This also fits perfectly under Traeger's cover for the Pro 22 models. Have to be a little care you dont pinch your fingers when folding it down (would be a nice future mod if it could somehow be spring assisted), but thats my only gripe.
Many of the models require you to clean them up for 30 minutes because you have to take out the gooey deflector plate and the greasy grates in order to scrape them off and wash them until they’re shining. Careful cleaning is required when the grease and carbon are covering the deflector plate. The easy-clean grills typically make the parts more accessible but the amount of cleanup remains the same.
What makes it stand out from the crowd is that it’s the only pellet grill on the market (so far) that has an ash cleanout system… no more hauling out your vacuum to the patio to suck out the ashes when it’s time to clean out your grill! You just need a small cup… and with a simple turn of a small lever, the ashes drop out! You’ll LOVE this feature!
The greatest thing about pellet smokers is that you don’t have to do much to get perfectly smoked dishes. Simply set the digital controller to the desired temperature and the smoker will do the rest. These smokers are pretty much set-and-forget, which means that you’ll be able to spend more time with your guests and still serve them food that has wonderful smoked flavor. It’s this convenience that’s led to the recent rise in pellet grills and other electric smokers.

Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!


Cleaning up after grilling is every cook’s dreaded part of the process, but this pellet grill simplifies that. Its warming rack comes with a patented ash-catcher system, the Ash Can Cleanout System, that allows for an easier cleanup of the unit. Additionally, it also features a grease drip disposal system that comes with a bucket. You won’t have to waste precious time cleaning up afterward!

Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.


My brother said his Traeger blanket saved pellets in cold weather, so after talking to him I decided to order one. Used it for the first time today. The blanket went on easily & fit the grill perfectly. The temps this a.m. was below 0 when the meat started smoking. So far so good! The grill hasn't extinguished itself, a problem we always had when cooking in the cold, the temp of the grill is cooking like it does in the summer, & the meat is smoking beautifully. If you Traeger in cold winters this accessory is a must have!
Camp Chef have been a notable and solid producer of grills for some time now, and have earned their position in the market, with straightforward, yet proficient outlines, which offer purchasers great outcomes. They had stated, prior to release, that the PG24 Pellet Grill and Smoker, would give clients brilliant elements and a high level of usefulness, with exact temperature readings, and I needed to see whether this genuine. This Camp Chef PG24 Review expects to give purchasers all the data they have to settle on an educated purchasing choice.
As you can see from the image of a Traeger Pellet Grill above, pellets move from a hopper (left) via an auger to a burn pot (far right). The rate at which the pellets are fed into the hopper is dictated by your Pellet grill’s thermostat. Extra fuel in the form of oxygen is blown over the burn pot to increase the burn rate and help regulate a nice, steady, and efficient burn. The lower your temp, the more smoke is created.
"The Camp Chef transaction aligns with Vista Outdoor's strategy to deliver long-term value through acquiring complementary, market-leading brands that will benefit from Vista Outdoor's balance sheet, distribution network, and sales and marketing expertise," said Chairman and Chief Executive Officer Mark DeYoung. "Led by an entrepreneurial management team, Camp Chef has a nimble and responsive product development process. Camp Chef continues to grow its market share in the outdoor cooking category, and the brand serves many of our current consumers who are engaged in a wide variety of outdoor pursuits. Acquiring Camp Chef strengthens our leadership position in outdoor recreation, allows us to enter the growing camping and outdoor cooking market, and the brand's effective multi-product, multi-channel strategy increases our presence across both brick-and-mortar and ecommerce distribution platforms."
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).
Before talking about its features, we need you to close your eyes and ask yourself these questions: Does it grill? Does it smoke? Can it ever replace a gas grill? Does it work like a charcoal grill? Now, open your eyes and listen to the answer: Yes. With GMG Daniel Boone’s motto “Think Everything”, you can be certain that it will provide the all-in-1 solution you seek.
Keep your Pellet Grill and Smoker fired up Keep your Pellet Grill and Smoker fired up with Camp Chef’s Premium Hardwood Pellets. Made of 100% natural hardwood these food grade pellets are an excellent way to add that unique smoky flavor. Choose from 4 distinct flavors. Smokehouse Hickory impart a rich and smoky bacon-like flavor to all meats ...  More + Product Details Close
Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born Cuisinart's CPO-600 Alfrescamore Outdoor Pizza Oven was born from love of crisp brick-oven style pizza. It’s been designed with the cooking ability of professional brick ovens but with the accessibility ease and size of a portable grill. Whether you’re holding an impromptu family pizza night inviting the friends over for ...  More + Product Details Close

Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.


Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.
To start using the grill, pour wood pellets into a hopper (pellets are usually are made from compressed sawdust). Press the start button to ignite the pellets, which are fed into the fire box with an auger, where a controlled number of pellets are lit and burned (depending on the temperature setting selected). The auger adjusts the number of pellets entering the fire box to maintain the desired temperature.
 When you think of a pellet smoker, what comes to mind is the rich taste of BBQ, better manipulation and convenience. These are exactly what the best pellet smoker should give you. To find out the best, among the many out there, you should think of various features. A burner that can give you control, comfort, long service, and great flavor in food is something a top rated pellet smoker should have. Let’s take a look at all the factors you should consider when making your purchase.

With a large cooking space and the most advanced cooking techniques, this is easily one of our favorite products among our top ten. While it lacks some of the features that the other grills and smokers in this review have (such as an ash and grease cleanup systems), it does deliver fine-dining quality foods, which is the ultimate goal of every grilling enthusiast. For its price, it offers some of the best features you can find in high-end products.
You now know more about the perplexing pellet predicament, but where do you actually buy them?  Afterall, none of this matters if you cannot get them when you need them.  If you are lucky you have a local store that sells one of the brands mentioned above.  Definitely take the time to visit the web pages of these manufacturers and see what is available in your area.  If you are not one of the fortunate grill owners who live near an Academy Sports, Dicks Sporting Goods, Rural King, etc there is a chance your local Wal-Mart, Lowes or Home Depot may carry a reputable brand.
A pellet grill like the Rec-Tec is a breeze to use; subsequently, you won’t need to manage a migraine when barbecuing or smoking. Most models now accompany an electronic start highlight, which means you don’t need to use gas or charcoal for grilling or smoking (Read here). Furthermore, with this element, you don’t likewise need to manage the temperature changes in the earth on the grounds that the unit will be lighted by its electric igniter whatever happens, and after that, it will begin warming and cooking your nourishment. Furthermore, regardless of you are a piece of a little or a major family unit, there is the correct model with the size perfect for your family’s cooking needs.
Hey Drew – thank you for your comment. All told, most pellet grills are going to average about 1.2 to 1.5 lbs per hour. of pellets per hour at 225, and closer to 1.75 lbs. as you get up to 275. It’s tough to gauge, which is why you are probably seeing different figures across the web. Ambient temperature and pellet composition play a role as well as grill temp. Sorry I don’t have better information for you.
Hi Dillon, thank you for commenting here. As to your question, I think you’d be happy with either a Weber Smokey Mountain cooker 18 inch, or a Daniel Boone Green Mountain Grill pellet smoker. Each are on the smaller side of BBQ Smokers and BBQ Pellet Grills, with just enough extra space to make food for a small family get together as needed. My brother lives in Colorado Springs and had trouble getting his Weber Smokey Mountain cooker to get hot enough and/or regulate temps. He built a wind screen for it at first which helped a ton. Then, he constructed a kind of smokehouse for it to sit in. Works great and functions as desired. You can see more on the Weber Smokey Mountain cookers here. For GMGs, you can find Colorado dealers by visiting this link: http://greenmountaingrills.com/find-a-dealer/.
Also own a Big Steel Keg which I love! Didn’t want an egg or a Primo while I was up north WY & CO as I had to many friends complain about cracking when trying to use them in cold weather! Many times at Thanksgiving or Christmas I have cooked on any or all of these devices at -5 to -10. It can be done but with a strong wind it is quite a challenge! My Weber (been thru a couples) and my Keg still have high ratings for great steaks and burgers. But for low and slow you are pushing it to get there and my friends with the ceramic style units say it takes some practice and close attention. What I don’t like about and Egg or my Keg is if you do need to end up feeding the fire on a long cook it is a real serious challenge!

OK. I’m rambling a bit. To your point regarding Traeger. I think that the models you can buy at big box stores (Costco etc) are OK. I still hear a few complaints about blistering paint etc. But… their Pro Series Models are a different story. The new management at Traeger has come a long way in their efforts to reaffirm the Traeger brand as a legitimate BBQ Pellet Smoker brand that everyone from the backyarder to competition pitmasters can get behind. To that end, they only allow specialty retailers carry the Pro Series models, which are built with a bit more heft and better PID controls, electronics, etc. You can find these at Ace Hardware stores, places like the Whiskey Bent BBQ Supply store we have here in Lakeland, FL (there is now one in Odessa, FL) as well. You can find a Traeger Pro model by going to http://www.traegergrills.com/dealers.
For example, many grills use and charge for collaborating with a software application on it. I, personally, think this is an absolutely silly feature to include on a pellet grill. Yes, it does start on and off from your phone and change temperatures while you are at Switzerland enjoying Swiss cheese on a lake, but really, is it even logical? I mean, pellet grills have already made the cooking experience as easy as a dream, the least you can do is set the temperature by the click of a button on the appliance yourself! You can’t possibly be that lazy!
When buying an item as important as a grill, it is evident that an individual should look for the best quality for what they desire as well as learn properly what are the best in the industry. With that in mind, pellet grills are even more unique than a regular grill because of the design and the way the grill functions. With that said, the quality of a pellet grill is the first criteria we took into consideration because there is a slew of different elements that have to ensure the grill is made of the best possible quality design. With that in mind, one important aspect of quality design that we took into consideration is how all of the functions are built. Meaning, we wanted to make sure that no area was designed and manufactured in a cheap way. Other than that, one method in which we figured out the best quality grills is how the grill cooked and how the items tasted. However, since we cannot buy every single grill and spend weeks cooking steaks and vegetables, as nice as that sounds, we relied a lot on individual reviews and what people had to say about that particular grill.
First one, had an auger problem... told that this never happens. Returned to Costco, now on 2nd Unit. FIRE HAZARD, fire pot overloaded after temp dropped from 375 to 100 on a four-hour turkey. When I opened the lid to see what was going on it EXPLODED into a fireball and then had flames shooting out from all sides of the grill. There was even smoke and heat felt from the firebox side of the grill and it looked as though the overloaded firepot was burning into the auger line as well. DANGEROUS PRODUCT!!!
Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
Whenever you want to smoke with a pellet smoker, you will have to make a choice: What type of wood pellets should I use? Well, the answer may sound simple – whichever flavor you like the best – but might be pretty difficult if you’re smoking for the first time. Unfortunately, the only way to know which flavor you like most is to try them all at least once and then decide upon which one floats your boat.
×