Cooking surface – Whole 702 square inches at our disposal, which is a lot. But if this is still not enough for you, you can buy a second shelf and expand the cooking surface by extra 352 square inches. That’s the total of 1052 square inches of meat grilling or smoking space. I think when it comes to this pellet grill, you can’t complain about insufficient space.
Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
To cook food using a pellet grill, put the pellets into a hopper. When you turn it on, the igniting rod will burn pellets in the fire. The motor-driven auger will then supply the fire pot with pellets from the hopper. The ratio that auger delivers pellets to fire pot depends on the settings you control. If you set it at a high temperature for a longer period of time, the auger will keep on feeding the fire pot with pellets. However, if you are slow-cooking and set a low-temperature one, the feeding and delivery of pellets will also slow down.
Coming over to the cooking area, you will find 2 stainless steel grill grates that give you 702 sq. in. of cooking space with an option of the second shelf that makes it 1054 sq. in. Its tall enough for turkeys and large enough to fit 6 large-sized racks of ribs. So, hosting a bunch of people for a BBQ party, and cooking delicious meat for them, would be as easy as it could get.
Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazon https://tinyurl.com/amazingribs
Apart from the aforementioned problems, you might face some minor issues like the smoker staying hot for hours in the end even after your cooking is over and it’s turned off? It’s better to check out the backdraft preventing cooling fan for your grill. Although this wouldn’t cause any major issues with your grilling experience, it’s a safety feature that is always worth checking out and fixing.
Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.
This smoker offers a massive 560 cubic inches of grilling area with a large-capacity pellet hopper. Even though it’s the perfect starter grill, it’s still packed with plenty of extras that even the pro chefs will enjoy. If the grilling space isn’t enough, the removable upper racks can be turned into extra cooking space. The smokestack behind the unit can also be converted into a prep area.
Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
It comes with some unique features, such as its proprietary “Sense-mate” technology that uses a thermal sensor to monitor the ambient temperature. If used in a cold weather, this grill fires up the turbo mode so you won’t have to wait for it to heat up before you start using it. It comes with “fan-only” mode to blow off the ash and automatically clean the grill once it has been shut off.
Customer Service: I spoke with customer service department about 10 times during this process, and every time I emailed or called I received a different person in response to my same issue. This did not feel good as I never got past the ground level in service even asking for upper management. After the initial response to the dented barrel I received a month back order request for a replacement. After this no offer was made to remedy the situation meaning no refund, or any extras were given as a sorry. I had to contact 3 more times (with three different people) asking for upper management before they agreed on making up for the situation. I ended up receiving for "free" a folding front tray. A month and week later I received my replacement barrel only with no lid, and then a week and half later received the lid.
"The Camp Chef transaction aligns with Vista Outdoor's strategy to deliver long-term value through acquiring complementary, market-leading brands that will benefit from Vista Outdoor's balance sheet, distribution network, and sales and marketing expertise," said Chairman and Chief Executive Officer Mark DeYoung. "Led by an entrepreneurial management team, Camp Chef has a nimble and responsive product development process. Camp Chef continues to grow its market share in the outdoor cooking category, and the brand serves many of our current consumers who are engaged in a wide variety of outdoor pursuits. Acquiring Camp Chef strengthens our leadership position in outdoor recreation, allows us to enter the growing camping and outdoor cooking market, and the brand's effective multi-product, multi-channel strategy increases our presence across both brick-and-mortar and ecommerce distribution platforms."
Kevin: I have a gas smoker but would like a wood pellet smoker. I’m looking at Traeger Lil Tex (due to price) but I read about Blazn Grill Works, Grand Slam, made in USA, stainless steel grates and a control unit that is very good. Cost about $1195, can’t find dealers so called and talked with the owner. What I read on web site sounds good. He claims on his short video that his auger is the best and doesn’t put torque on the drive due to the design. Any thoughts on this unit? Any advice would be appreciated. Still looking at the Yoder YS640 as price is very similar.
Kevin- super helpful article. Thanks! I just moved from a big city small apartment with no grill to a house in the country. Most essential purchase is the grill. I’m really on the fence. I like the idea of a pellet grill, but in reality- I’m mostly cooking burgers, fish, steaks, scallops, and veggies. The brisket and ribs will be more of a special occasion. From an economical perspective, am I better buying a gas grill and just getting one of those smoke tubes to add some flavor? From many of the online comments, it seems like the pellet grills benefit from additional smoke anyway, and though you can get additional grates for searing, seems like a square peg in a round hole. The gas grill is sort of the tried and true, and way more economical. Those $500 entry level pellet grills seem a little scrawny, and the next level up is a cool $grand. I’m really on the fence, and getting pressure to “just buy the darn thing” to consummate the move to the country! However the pellet grills seem like the new shiny object and have my curiosity. Any advice? PS- love the website! Thanks, Cary
Regarding getting a good draft, this is a common misconception for pellet grills. The burn pot on pellet grills receives oxygen via a fan unit. As such, there’s no need for a draft to get a measured burn in the traditional sense. Most pellet grills lack sufficient insulation / gaskets, etc to prevent smoke from leaking out of the body. So, unless you’re going with the Memphis or something that uses oven style insulation, you don’t really need a chimney at all IMHO.
I live in Florida (Ocala), and I would like to grill, but I am undecided what to buy. I would not use the grill everyday. I am not a ‘griller’, but I do enjoy grilling simple meats, hamburgers, pork tenderloin and chicken; perhaps smoking a 12 lb. turkey for Thanksgiving and Christmas. I have no knowledge as to grill veggies or fish. I am an ignoramus! I tried, but I couldn’t detect them among the ashes!
Sometimes an inexpensive, less efficient pellet blend might be just fine for burgers or chicken breasts. Other times, you may want to step it up with a premium flavored pellet where whole turkeys, prime rib roasts, or a nice brisket can really shine. No matter what you read in any grouping of pellet grill reviews, know this: pellets are not all made equally. You will wind up with one or two “go to” brands over time that you simply prefer – sometimes for their efficiency (leaving little ash), others for their flavor.
You now know more about the perplexing pellet predicament, but where do you actually buy them? Afterall, none of this matters if you cannot get them when you need them. If you are lucky you have a local store that sells one of the brands mentioned above. Definitely take the time to visit the web pages of these manufacturers and see what is available in your area. If you are not one of the fortunate grill owners who live near an Academy Sports, Dicks Sporting Goods, Rural King, etc there is a chance your local Wal-Mart, Lowes or Home Depot may carry a reputable brand.
The Silverbac wood pellet grill has a heavy-duty 12-gauge steel body and 14-gauge stainless steel lid, which makes for better heat retention and durability. This type of beefy construction is what you'd expect to find in a grills at this price point. The digital control panel is accurate every 5 degrees and the large 20-lb. hopper can hold enough pellets for your longest smokes. With nearly 700 inches of cooking area in the Grilla, you'll be the most popular house on the block.
On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.
Now, I will be very honest with this topic here. While prices vary from model to model and brand to brand, one thing to understand is that the best pellet grills are made with the best materials, made by keeping consumers needs in mind, made with intelligent designs and features that can serve and last a long time. There are pellet grills in the market ranging from extremely cheap and affordable to very expensive, and sometimes even unnecessarily expensive. While there are exceptions in many cases, the blatant truth is that good stuff will cost an extra penny. This is why I will be giving you my pellet grill review, so that you can see and identify your specific needs and buy a grill according to that instead on spending a fortune on low quality or unnecessarily multiple-feature grills.
Yoder Smokers has overcome this challenge with their YS Series of pellet grills outfitted with their direct grilling package. When fit with this package, the grate temperature on the left side soars past the 700-degree mark and produces those coveted steakhouse quality grill marks, fast cooking times, intense caramelization, color and texture common to cooking over an open fire or gas fired grill.
Hi Joshua – Rec-Tec makes a solid product. I can’t say a bad thing about them. I think you’d be very happy with the Silverbac. Email Shane Draper – Pitmaster for Grilla Grills at email@example.com. He’s super quick with responses and can answer all questions re: Grillas. The Traeger pro series is a solid buy as well. You can check them out at Ace Hardware Stores or via stores acting as dealers for the pro model (find these on the Traeger website). I have the smaller Traeger 22 pro model and have been very happy so far. Regarding controllers, my verdict is still out on whether they’re what you need. It’s almost getting to a point where I “want” some temp swing, especially at the lower settings, in order to get a bit more smoke from the cooker. 15 degrees either way on temp is pretty normal. You might find that this is the case, even when controller units “read” steady. Pellet grills all feed pellets into burn pots in cycles. So some swing is inevitable. Hope this helps.
My wife purchased this cooker for me for Christmas three years ago when I was working on the road. I had been a gas man for years and had converted to charcoal with great success and enjoyment. I built a UDS smoker and was really getting into the slow smoking with better temp control. Then my son ratted on me and told my wife that I had been drooling over a Yoder Pellet Grill. She surprised me to say the least as I would have never bought this unit myself. I've had several cars that cost less than this smoker! Wow. In person, this grill is build by people that love their job. The smoke flavor compared to a Weber kettle is more delicate than harsh. Temperatures are very even across the grill with warmer sides within an inch of the body of the grill. Being able to start it in two minutes and get to cooking in ten is very handy. Being able to run downtown without worrying about the temp is awesome. I've had it get a little lower than where I had set it, but not by more than 15 degrees. It has great reliability in any weather. We live in northern Montana and this thing just does what you want it to do. Great for making jerky, slow smoke, grilling, and baking. Wood fired cookies are one of our favorites. I've smoked cheese on it during the dead of winter at -15 degrees. Bacon...wow. If you have never had slow smoked bacon I feel sorry for you. Don't worry about not liking this unit after the purchase. I've thanked my wife more times than I can remember and I've received just as many compliments back from everyone who has sampled the food. Great job Yoder!
Kevin, Im about ready to pull the trigger – im pausing for a moment to consider your thoughts as you mentioned Grilla Silverback or Camp Chef. How do these compare to the Rec Tec on quality and price? (as they are less than Rec Tec) And reverse sear…how well does this work on pellet grill, ie how long does it take to go from 200 cooking temp to 500 searing temp (with grill grates)? Thank you for your time
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy
Pellet smokers can be used as a charcoal grill by adding the lit charcoal into the charcoal tray. Some of the best pellet smokers allow users to attach a propane tank to the stove to convert them into a gas grill or a kitchen oven. With a flat-top accessory, it can even be used as a griddle. A pellet smoker is an all-in-one solution for the hardened grill masters.
Food not cooking evenly or at desired times: It’s worth checking out the health of the fans in your pellet grill. Usually, if the fan is unable to distribute the heat properly throughout the whole smoker, these problems occur. Fans are relatively inexpensive and very easy to replace. Even if you see the fan working and still getting these problems, it might be that the fan is working intermittently or at slower speeds that it needs to. Have it replaced: it would be the best course of action and won’t be heavy on your wallet.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
A: This may be considered the million-dollar question for many reasons. When it comes to a pellet grill, individuals have to clean it out a bit different than a regular grill because there are unique elements to clean. Many individuals recommend cleaning a grill after every use depending on the size. However, for larger grills, it is recommended to clean it after four or five bags of wood pellets. Now, what you do is vacuum out the ashtray. Some brands do have an automatic ashtray cleaner. If not, then you have to vacuum it out with a vacuum. Other aspects to clean include removing the grease drain pan, removing the porcelain grills, the heat baffle, and properly washing with warm water and a bit of soap. Most brands will have cleaning instructions in the guidelines.
Hey Oscar, based on what I think and my discussion with my buddy Shane Draper of Draper’s BBQ, you’ll probably only need to run 14 hours for a brisket cook – given the convection nature of your pellet grill. You’ll probably go about 1 lb per hour or a little less – depending on the weather and other variables you mentioned. Again, pellet cooking is a little bit give and take where you’re getting ease and a more set it and forget it cook experience in exchange for some additional fuel use.
We are going to take the guesswork out of it for you. Here at Grills Forever we have seared, smoked and grilled on grill after grill so you can have the latest information on what smokers are the best pellet smoker grills. These best pellet smokers can sear and cook the most delicious foods, they are easy to control and convenient to use. We took all these features and more into consideration while compiling the top 10 wood pellet smoker review.
This review is just a repeat of many already submitted. Got my Traeger Elite 34 this summer at a trade show. It would not get up to temperature, wouldn't go about 360deg with food inside. Empty it would hit 390 max. Most of the 'infamous' Traeger recipes call for 400+. If you raise the lid, the temp falls to the low 300's and takes 15 minutes to recover. I called Traeger and they claimed their grills 'never do this'. After reading dozens of reviews since, the truth is that they seem to 'usually do this'. The big grilles just do not have enough BTUs to heat up properly.
Bought the Costco trade show model after about 4 years of debating the purchase... OK, first one broke on day one as "auger" stopped spinning. Returned and received a new unit. 2nd one smoked a turkey for 4.5 hours. After 4 hours temp. dropped to 100 degrees and it was set to 350. When I opened the smoker to check on why this happened, it exploded into a ball of flames! There was fire shooting out from all sides of the grill and smoke and heat coming from the feeder side of the grill... This was SCARY and could have absolutely caused a major fire, and/or injury!!!
The Yoder YS640 is a more professional pellet smoker which maintains consistent temperature across the cooking grates. This means that you will never have to move your food to avoid overcooking because of the hot spots within the smoker. In addition, cold weather and winds won’t affect the temperature within this smoker as they do with some other pellet smokers.
Now, for the good stuff: do not hesitate to spend an extra or even two bucks for a feature that you will use and appreciate. Consider your pellet grill as an investment, something you are going to buy, and be using and enjoying for years and years to come. Features like meat probes to check the internal temperature of foods are excellent for taking the guess work away from cooking meat to a particular doneness. You will never end up with an overcooked and rubbery, or undercooked and raw steak ever again! Features like smartly designed grills that consume and spread heat evenly are also great for cooking food to perfection without having to move it from side to side to find the right temperature spot.
With the Camp Chef PG24S, you won’t have to constantly refill your hopper. Your pellets will be used as efficiently as possible, as this product comes with a hopper that can hold up to 18 pounds of wood pellets. With the digital heat control system, it instantly feeds the pellets into the grill to maintain the ideal cooking temperature. This ensures that food is cooked most satisfyingly.
One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
To see if ShippingPass is right for you, try a 30-day free trial. Also, with ShippingPass, there is no need to worry about commitment. If you decide you want to discontinue the service, you can cancel your subscription at any time. No matter what your shipping needs, Walmart's got you covered. Sign up for ShippingPass so you can shop more, save money and live better.
GrillGrates(TM) amplify heat, prevent flareups, make flipping foods easier, keep small foods from committing suicide, kill hotspots, are easier to clean, flip over to make a fine griddle, and can be easily removed and moved from one grill to another. You can even throw wood chips, pellets, or sawdust between the rails and deliver a quick burst of smoke to whatever is above. Every gas grill needs them.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 — using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
Bullet Smokers: They come in the shape of a bullet and works in a similar fashion as kettle grills. However, the main advantage it has over kettle grills is that you don’t need a charcoal chimney starter to light it up. Plus, the shape will allow the users to cook at a lower temperature and smoke for a little longer than they can on a kettle grill.
Hey Jennifer, I think a pellet grill/smoker would make a great addition to your cooking arsenal. You can get a pellet smoker up to 450 degrees in about 10 or 15 minutes. The following article gives you a good idea of what you might do to reverse sear a nice thick steak using a pellet smoker. note, that this method employs the use of GrillGrates, which you can find easily on Amazon. Here’s the article:http://blog.greenmountaingrills.com/rib-eye-reverse-seared/
Temperature range is an important factor. What you’ll need will depend on what kind of cooking you want to do. Top pellet grills can hit temperatures between 180 F to 425 F, enough for baking, smoking, roasting, and grilling. On the other hand, ioif you want to sear meat you need something that reaches the 500-550 F range. A functioning thermometer is a must. You’ll need a precise and accurate reading so you’ll know you’re cooking your meat at the right temperature.
The first name to kick start our list of the best pellet grill review is the Camp Chef PG24 Pellet grill. It measures 45 inches by 21 inches by 51 inches, in dimensions. This pellet grill weighs 127 pounds and capacitates a 550 cubic inch cooking surface. It has a removable upper rack, and it comes with a stainless steel food probe. Camp Chef PG24 Pellet grill comes with an LED digital temperature control system, and has a patented down cleaning system. It can provide temperatures from 160 degrees to 500 degree Fahrenheit, and has an internal sensor.
Before buying, please note that pellet smokers need access to electricity to run the digital controller, the auger that transports the pellets to the firebox, and the convection fan that circulates the air in the cooking chamber. These cookers can use a lot of pellets at high temps. At high temps there is little or no smoke, and at low temps smoke is unavoidable. So if you want to cook, say, a chicken breast low and slow to retain juices, but you don't want any smoke flavor, you're outta luck. If you want to torch a thin burger to get a crunchy crust and add a little smokiness, you'll get great smoke flavor, but it is hard to get the crust. But if you want killer ribs, bacon, smoked salmon, etc., pellet burners are hard to beat for convenience and quality.
Apart from the replacement parts for a pellet smoker, there are also certain accessories that one can use to increase the range of its usefulness as well as improve its performance. A user can attach a griddle attachment to a pellet grill to use it as a flat top griddle, or use a hopper extender to increase the pellet hopper capacity; there is an attachment for every purpose to suit all of your needs. Let’s take a look at the types of accessories commonly found: