This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.

Great reviews. I have been lately looking into pellet poopers. I currently own a large Big Green Egg and a Pit Barrel Grill. My Egg has limited space. On the PBC (Pit Barrel Cooker) I can cook a ton of food as it uses hanging meat method. But it has zero temperature control on it. A set lower vent and that’s it. You have to adjust the lid to get the temps up. I have adjustable rings for my Egg that allows for increased capacity. Eggs are great smokers, grills and ovens. I do have a FireBoss temp controller for the Egg which will allow a set it and forget operations. Wifi controls also. With that being said, I am looking for increased capacity in my cooks. I was seriously considering a XL Primo Oval or a XL BGE. Then I found these pellet poopers. After reading this blog and other reviews I found some limitations. One the lack of smoke flavor. Now with my Egg I add chunks of wood into the lump for smoke flavor. Same with the PBC. The PBC has different smoke flavor as the fats and juices from the meat drip on the hot coals which ignite (according to PBC’s website) and produce a smokey flavor in the meat. I’ve read two ways to increase the smoke flavor in Pellet Poopers. One is to start at a lower temp for a few hours, then crank it up to cooking temps. Two is the smoke tubes or Mojo Bricks. My question is do these techniques work? One review on the smoking tube said that they really didn’t make that much of a difference. Another issue was for grilling and the lack of direct heat. Grill Grates would eliminate this concern correct? My understanding of Grill Grates is that they provide a way to direct grill in an indirect environment. That’s a limitation with both of my cookers. The Egg can Indirect or Direct grill. Not both. Yes I can remove the indirect piece and set up the Egg for direct grilling, but you risk burnt fingers even with welders mitts on. Wouldn’t the Grill Grates on a Pellet Pooper solve this problem? Allowing you to slow cook that steak to say 10 degrees shy of your temp range then sear it on the grill grate for the a couple of minutes on each side to get it to your desired temp range? Or go the other way, sear first for a few minutes per side then indirect cook it to the desired temp?
The MAK 1 Star General boasts our favorite digital controller: It's highly programmable and easily accessed via the internet from anywhere in the world. Made entirely in the USA, the 1 Star General is solid-feeling, with a heavy-duty powder coat. The hood is a rolltop, meaning that, unlike a lot of its competitors, the 1 Star doesn't need much rear clearance, and there's plenty of room inside. An optional upper grill grate adds 190 square inches of cook surface. Our only criticism: Not only is it built like a tank, it kinda looks like one, too.

GrillGrates(TM) amplify heat, prevent flareups, make flipping foods easier, keep small foods from committing suicide, kill hotspots, are easier to clean, flip over to make a fine griddle, and can be easily removed and moved from one grill to another. You can even throw wood chips, pellets, or sawdust between the rails and deliver a quick burst of smoke to whatever is above. Every gas grill needs them.
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
Currently, online retailers only have to charge customers sales tax who are located in the same state as the business which takes the original order. Camp Chef main offices and warehouse facilities are located in Utah in addition to Washington State. Therefore, only customers who purchase items from us and are also located in Utah, Colorado, Massachusetts, Indiana, Pennsylvania, and Washington will be charged sales tax.
Z GRILLS or Z Grills is a maker of smokers, grillers, and stainless steel prep work tables galore. It entered the world of pellet grills recently and launched an IndieGoGo campaign in order to fund its “affordable wood pellet grill” for $500,000 and currently gives even Traeger’s economical offerings a run for their money with its ability to accept all types of pellets and do all sorts of cooking styles.

The Tailgater 20 Series Freestanding Grill is one of the best wood pellet grills from Traeger for those who like to cook away from home. It’s small and lightweight enough that you can load it in your car for tailgating before the big game, cooking while camping or grilling at the park. The ash bucket collects all ash created, which makes cleaning up before heading home easier.

Now, there are different materials that certain pellet grills are made from. Since steel is such a heavy duty and heavy item, some brands have opted in for more cost-efficient materials, such as a stainless-steel lid to remove some of the weight from the pellet grill. With that said, the interior grill gates are as equally important as the exterior. For example, some grill gates are made from an easy to clean porcelain material while some are designed from stainless steel to be more user-friendly and cost-effective. With that said, let’s discuss another important element to consider when it comes to a pellet grill.
I did a lot of research, and ended up buying the Camp Chef DLX24. It was at a price that fit my budget, (under $500) and had a lot of features the others didnt. The pellet trap door for quick dumping of the pellet hopper into a bucket, and the ash cleanout under the drum was a clincher. Being able to pull a lever and dump the ashes into an easily removable cup is a great feature that all grills should include.It has a digital temperature controller, and dual probes (one inside the smoker for grill temp, one for the meat) and overall good quality construction. The second shelf inside is standard (you pay extra for that on other grills). If your budget allows, would suggest purchasing the propane powered sear box ($199) which attaches to the side of the grill and allows for reverse searing meat..
Many merchants pay us a small referral fee when you click our links and purchase from them. On Amazon it works on everything from grills to diapers, they never tell us what you bought, and it has zero impact on the price you pay, but has a major impact on our ability to improve this site! And remember, we only recommend products we love. If you like AmazingRibs.com, please save this link and use it every time you go to Amazonhttps://tinyurl.com/amazingribs
We have reviewed the best pellet smokers on the market today after doing our extensive comparative research. However, there were some hidden gems that could not make it to our top 10 product list because of one reason or another e.g. due to their high prices, unavailabilities in some regions, and other factors. Also, some just failed to get in our top 10 list only because it was a top 10 list and not a top 20 list. Regardless of the reasons, here are a few honorable mentions that failed to make it to this top 10 best pellet smoker review, but are still worthy in their own rights:
In fact, 80 to 85% of pellet smokers in the USA are Traegers. The consensus is that they are reasonably well built, though some buyers complain that quality has dropped since manufacturing moved to China. But of course we hear more complaints—as well as more praise—about Traegers, since eight out of 10 pellet smoker owners have one. Traeger can be found in many national chains, like Cabela's and Costco. It's not unusual to find special deals on this popular product line, so keep your eyes open.
With Davy Crockett’s Wi-Fi feature you will have more time to interact with your friends and family. Download the GMG’s app to your phone and you will be able to turn the cooker on and off, monitor and control internal meat temperature, and even receive system malfunction or low fuel warning. In addition, you can even add time and temperature instructions for your favorite recipes. For example, the grill can cook at 225°F until the internal meat temperature is 110°F. Then, the heat can be turned up to 500°F for browning until the temperature of the meat is 135°F. Lastly, the temperature can be dropped to 140°F to keep the meat warm.
I believe the little Green Mountain Davy Crockett is the best portable pellet smoker currently on the market. Surprisingly, many of the portables out there still have an antiquated LMH controller, while Davy Crockett employs Green Mountain's advanced digital touch-pad controller, with an integrated meat thermometer that lets you check internal meat temp with the flick of a switch. Furthermore, it includes adapters to run the electronics from your car battery or cigarette lighter. And Green Mountain is aggressively—ahem, hello, price cut—promoting its WiFi capabilities, which enable you to monitor Davy Crockett from your smartphone or laptop.
Nothing says “you are welcome to my home” than some delicious and succulent baby back ribs; some beer can whole chicken cooked your special spice mix, and some wood smoked salmon. There is no better way to wins the appreciation of your favorite people than cooking up some wood grilled steaks and baked potatoes. But there is a catch, there always is.
UPDATE 8/27 - This grill is still performing flawlessly. No error messages, maintains temperatures. I have made homeade pizzas and strombolis on a pizza stone and it actually makes them better than in the oven. Its like a restaurant wood fired pizza. I made a pork butt, beef brisket, bacon wrapped scallops....it just simply cooks everything well. Love my Pit Boss !!
If you’re one of the serious barbecue enthusiasts, you would not want to leave any stone unturned to get your hands on the best of the best pellet smoker the market has to offer, in that case, you need the REC TEC Wood Pellet Smoker. The REC TEC has a large surface which takes care of all sizes of cuts, the thermostat maintains the temperature and ranges all the way from 180 F to 500 F. It has been leading the market for so long that the company now provides warranty for 6 years.

You like the idea of cooking different types of foods on the grill: If you’re someone who wants to grill food other than meat, the Traeger grilling system gives you this option. With the precise temperature control of the Traeger, cooking things like fruit pies can be a successful endeavor, something you wouldn’t dare try with a propane-fired grill.
If you’re in the market to buy a grill, yet you’ve only grilled with propane or charcoal in the past, wood pellet grills may have piqued your curiosity. These grills use a very different cooking method than the direct flame of propane, resulting in more even heating and more precise temperature control. A wood pellet grill is more like a smoker than an open flame grill, as it’s difficult to sear meat with a wood pellet grill. Purchasing and using a wood pellet grill is going to be more expensive than propane and charcoal grills.
This grill produces fall off the bone ribs. I've also cooked a brisket to perfection. My only issue is that I have to clean it after every use. If it isn't cleaned properly (I remove all of the grates and use a shop vac to suction all ashes and unburned pellets) the pellets will back up and when they finally push through, you will have a huge flare up that will potentially burn whatever you are cooking as well as take the paint off the grill itself. Also, I find it works better if you set the dial to OFF and then back to whatever temperature you want. Other than those few quirks, I love this grill. I did find a larger Pit Boss after I bought this one, but it was about $150 more.
I've had my ys640 for almost a year now. I absolutely love it! I debated for a long time before my purchase. I'm an old school charcoal guy at heart. I used to have a gas grill and a coal pit. I got tired of replacing gas grills every few years and having two grills is cumbersome. I considered an egg but the pellet grill is so convenient. I'm impressed by the build quality of the ys640. It's so heavy. It won't be rusting through any time soon. No regrets. My treager owning buddy is buying a yoder as soon as his treager quits because he has grill envy

Bought my Texas Elite 34 Traeger pellet grill last summer at Oshkosh Fly-in. Received it and assembled it with no issues. Began using it and discovered it will not make temperatures above 375 deg F. Most of the Traeger recipes need 400+ deg, so this wouldn't work. Called Traeger. They started sending me replacement parts, first the combustion air fan, then the auger motor, then a digital temp controller. None of these new parts had any effect on the problem. I have probably called Traeger 10 times, finally getting a hold of a second level supervisor named Jessie. He decided to send me a whole burner module; pellet hopper, auger tube, burner bowl, fan, controller... everything in one assembly. I installed it and no improvement. I did a time vs temp test for them at their request. They finally agreed it wasn't working properly.


Words like Grilling, Barbecuing and Smoking are often used interchangeably by us. However, when looking at them from a grill master’s point of view, there are some subtle methodological differences among these three: One is done with the lid up, BBQ is done in a closed circulation with the lid down, and smoking is a slow cooking process in a closed circulation.
I didn’t actually learn to cook—at all—until after college. So my parents, who I now see only once a year or so because they live in France, have never really gotten a chance to try my food. One of the first nights after they flew over to see our home, I cooked them perfect lobster tails on the grill. When a long-lost cousin showed up one day during their visit, I ran to the store, bought two chickens, threw them on the Traeger, and we had a feast. Everyone agreed that those chickens were the moistest and most evenly-cooked they’d ever had. 
The smoker is great. (5 stars) Assembly went well. It's pretty straight forward. Operation is easy as well. Just set and pretty much forget it. This is a large smoker. If you need space, this is the one for you. This is my first pellet smoker so I can't offer any comparison to others. I've used a Brinkman horizontal smoker for the last 20 years that has worked well but it was a pain to keep the smoke and temperature where you want. The constant tinkering was getting tiresome. The ease of use of the Camp Chef makes things so much more enjoyable.
There are several types of grills and these are charcoal, gas, wood, electric smokers, open fire grill, and pellet grill. Each of them offers different benefits. In terms of comparison, pellet grill is still superior because it is the combination of all such grills. You can use it to smoke that way charcoal grill does. You enjoy the wood flavor of wood grill using pellets, and it is also electrically and electronically-operated.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
If you’re looking for very portable smoker on a budget, we recommend the Davy Crockett by Green Mountain Grills. However, if you’re looking for a small backyard smoker that you can use at the occasional picnic, tailgate, or cul-de-sac party, we recommend the Traeger Tailgater. We think the slight increase in cost is justified by the bigger grill space, which comes in handy if you’re using your smoker frequently or to cook for more than two people.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 — using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
PID Controller–PID Controllers (Proportional Integral Derivative) are devices that most of the grill manufactures don’t fully utilize yet. They can be found as a separate device attached to the grills if you’re handy enough, but all the manufacturers aren’t fully considering them yet. Using a PID controller, you can accurately maintain the temperature while cooking and ensure that the food is cooked automatically to perfection without much supervision.
The Camp Chef Lumberjack Over the Fire Grill is a simple solution for cooking while on a camping trip. Simply place the Camp Chef ...Grill over the campfire coals and get to cooking. The durable plated steel body will stand up to the occasional knocks and bumps that happen outdoors. Foldable legs ensure that this camping grill will pack up quickly and transport easily. The large cooking surface of this Over the Fire Camping Grill is large enough to accommodate almost any camping cooking equipment you might want to use. The steel mesh top on this grill is well-suited for grilling a variety of foods, including steak and vegetables. Whether you are sitting down for a meal after a long day on the trail or you have been out on the lake, the Camp Chef Lumberjack Over The Fire Grill is an smart choice for your campfire grilling needs. read more 

The biggest cleanup issue is the buildup on the heat deflector under the cooking grates. You'll need good gloves and an apron. On most models, a thorough cleanup means a 30 minute process of taking out the greasy grates and the gooey deflector plate, scraping them and washing them. You should do this when the carbon and grease cover the deflector plate. Stainless parts can go in the diswasher, but I wouldn't do it. That grease is like tar and it could get all over the insides of the dishwasher and hang on for dear life. I use a handheld steamer like the Steamfast SF-320 Portable Steam Cleaner shown here.

With the upcoming and already existing new features, you can achieve an easier and much better smoking experience than ever before. Always look for features that can help bring out the real taste of food, and give you more control and convenience. Keep visiting this page because we will always be the first ones to bring you the newest and the best news about the innovations in grills and smokers.
Pit Boss Wood Pellet Grills are filled by all regular BBQ wood pellets. The computerized control board lights the grill and permits you to set the cooking temperature from 180° to 500°F. Fan constrained convection cooking takes out the requirement for a rotisserie and makes an adaptable situation for grilling, simmering, smoking, braising and preparing. The Pit Boss 340 has 340 sq. in. total cooking surface with porcelain covered cooking grids. With complete structural quality and strength, the Pit Boss 340 is made to last.
Hey Mike, thanks for touching base. It’s always a pleasure to connect with you, man! If you have the space, I’d go with the JB. You can always cook under your pellet smoker’s capacity, but you can never cook more than it will hold! As such, you can always find use for the extra room in the JB. It’s like the umbrella and the rain scenario – bring one and you’ll never need it. Go out without one, and it’ll pour on you! Holding temp and managing the cook is the same for each of these GMGs. You’ll have smooth going with both, I’m sure. If you are cooking in very cold temps, you might want to consider the thermal blanket GMG puts out. Helps a bit re: getting to / maintaining temp. Some folks use it all the time as they feel it keeps more smoke in the chamber. As you know, nearly all pellet smokers produce a bit less smoke than your barrel smoker will. Hope this helps, bro! Thanks for your comments!
Brought it home and set it on my prep table with the controller in a cubby hole with all intentions of building a cart for it later. So I have made a killer rib eye on it and tried to burn it down with a couple rib eyes cooking at 600 F. Gotta figure out a little better method of catching drippings as they will catch on fire and you have a runaway! But you can make a great rib eye. Ribs, every set has turned out awesome, everything from low and slow to a high temp cook process on them. Probably made 8 racks of great ribs. Wasn’t impressed with the hamburgers on it but will try again later. Made a pretty good brisket but used Rudy’s rub as I like their store sandwiches and I don’t have the method down. Next one will be back to salt and a touch of pepper. Chicken thighs (thighs are the perfect chicken part for Q, their rather uniform thickness makes getting them all consistent and cooked even a slam dunk) with a light coat of mustard and Tony Chachere’s lightly sprinkled is to die for. Simply squeeze them when they should be close and if the juice is clear, no pink or red they are perfect. If you cook the juice out, well they make decent tasting blotter paper 🙁 Pretty much killed a spatchcocked turkey for Thanksgiving, good thing the wife made an over baked one too. It did make great gumbo though as does the blotter paper chicken if you ruin any thighs or the whatever chicken. Also have a pile of hot links I put on at 180 for 2 to 3 hours. They are great for reheat with sauerkraut and roasted pabs or in the gumbo. Hot links should be a staple, ha ha! Gotta try my great pulled pork on it and we do Prudhomme pizza sauce on a Brown Eyed Baker crust and this Pro should rock it!
Not only do cheap grills not hold up as well, but there are additional benefits to better steel and construction, too. Construction quality matters in wood pellet grills, no matter the price. Take the video below where we compare Grilla Grill’s double wall insulation to Camp Chef, which is not a cheap grill by any stretch. This video shows how well the Grilla Grills pellet grill is able to retain heat, keep the cool out, and use less fuel than many other wood pellet grills. Now imagine how much difference this would make compared to a bargain basement pellet grill from a big box store!

Compared to the Traeger Pro and the other smokers we’ve reviewed, there’s not much not to like about this bad boy. It’s significantly cheaper, packs ample cooking space, and a good, consistent temperature controller. At 173 lbs, it is quite heavy, and not at all portable like the Davy Crocket, and we’d love to see it come with more precise temperature control, and maybe even WiFi in the future. But for the price, it’s a beast of smoker that is almost as good as the Traeger.
Regardless, it’s worth mentioning the basic types of pellets available on the market to get you started. First there are the hardwood pellets, made from the sawdust from any specific type of hardwood, such as ash, cherry, maple, etc. Then there are different organic hardwood blends: a combination of different types of wood shavings and dust, giving them a customized, special flavoring. For beginners, we’d suggest getting a premium blend, just to be on the safe side (because you can’t go wrong with these). Even then, we’d like to mention a few types of pellets commonly used for different purposes:
Their behavior is sometimes counterintuitive. The hotter they get, the less smoke they produce, and at their top settings, they don't produce much smoke at all. This is good for when you are baking cakes or pies or doing dishes that don't need smoke. But down under 250°F, they produce plenty of mild, elegant smoke. And even though the fuel is wood, it is hard to oversmoke with a pellet smoker. Burning wood on a charcoal grill produces much more intense smoke flavor.
The Redwood Portable Fire Pit is an upgrade from the original Gas Fire Ring. A taller, more sturdy base stand, safety ring/carry h...andle, matchless ignition, and a laundry list of other features, the Redwood is the next step in portable propane fire pits. Camp Chef Gas Fire Pits are allowed for use in most fire ban restrictions, check with the local Ranger Station before use. read more
Traeger Junior Elite Pellet Grill is a great model for those who want to start up the smoker, add some meat, and let the work be done for them. It is also extremely versatile, allowing you to grill, smoke, roast, and bake. It is perfect for individual households, college students, and even tailgating. And it’s a great option for first timers as well as those who have experience using pellet smokers.

Consistency is the key to having the best results. If you want to make a tender brisket, your cooking temperature should be close to 250 F during the entire 12-hour cooking period. The control board is responsible for precision. There are three types of controllers – PID multi-position, non-PID one-touch, and 3-position. Check out the different types of controllers for the one that is right for you.
Now we come to the part no one likes and that’s cleaning. This smoker won’t clean itself but it does make the process a lot easier. PG24 by Camp Chef Pellet Grill is created in a way that gives you easier access to the fire pot making cleaning out the ash effortless. It also has trap door that allows you to clean the unit without scouring through grease and ash. Anyone who has ever had to clean a smoker grill knows how time-consuming and enormous the task can be. This trap door is only present in expensive units, but you’ll be glad you paid a little more when cleaning becomes effortless. You could also buy the other version that could come with cover (which is $50 more expensive) to make sure the smoker is in the best condition at all times.

With modern advances in the outdoor cooking appliances due to their high demands, you too can cook up a great BBQ spread now with the help of a pellet grill! Gone are the days of overcooked and burned steaks. With the pellet grill on your backyard, you can BBQ to standards that even pit masters will approve. So today I will be giving you a 101 class on pellets grills, also including a list that will provide you with some great pellet grill review so that you can make the right decision when deciding to purchase one for you and your specific needs.
Sometimes an inexpensive, less efficient pellet blend might be just fine for burgers or chicken breasts. Other times, you may want to step it up with a premium flavored pellet where whole turkeys, prime rib roasts, or a nice brisket can really shine. No matter what you read in any grouping of pellet grill reviews, know this: pellets are not all made equally. You will wind up with one or two “go to” brands over time that you simply prefer – sometimes for their efficiency (leaving little ash), others for their flavor.
If you live in an area where wood furnaces are used (not like down here in FL where a few heat strips will do the trick), you may also be familiar with pellet furnaces. In short, pellets compressed from sawdust and wood shavings fill a hopper and are then fed into a burn pot using an electric auger system. The auger, which is basically a long screw, delivers pellets to the burn pot based on the speed dictated by the unit’s thermostat. As the burn pot ignites, the pellets burn. Heat then carries through the home via convection (air driven) means, thus allowing air flow and a blend of warm and cool air to maintain steady, even burn temperatures. A heat exchanger separates the smoke fumes from the warm air, thereby warming the room without smoking everyone out.
We have already mentioned this product in our review once and we’re talking about it again. Whenever you are thinking of Green Mountain Grills, Daniel Boone should always be your first choice; it’s simply the best among the GMG products we reviewed. Due to having other products at much lower prices with the same features, we could not include Daniel Boone in this review. We have, however, included the Davy Crockett in our review as our Budget Pick.

I brought my YS640 to Mexico on a friends recommendation, he was right. I takes the complexity of smoking away but this is not the reason why I got it. We live in south of the Sonoran desert and we are over the 100F most of the year, its almost impossible to stay close to your smoker to watch the fire and temperature. Plus, wood is not as easy to get in the desert. Since I got it, I have been selling food on Sundays, I was sold out since day one. Flawless food time after time. I am planning to get the old time offset cooker to smoke in the winter just for fun. There is really no need for it.


Hi – my husband and I are really interested in a pellet smoker. We came across some when we were at a fair and are trying to find more information about the Traeger brand because the price seems affordable compared to all the others you mentioned. You started out talking about the Traeger but never gave any feedback on it? Little help please:) Thanks!
The cleanout for both the pellets and ash is a huge perk to the grill. The patented “Easy Ash Cleanout” does not require the user to take apart the grill. Instead, they simply have to twist and dump the container. The 18lb pellet hopper is similarly an easy cleanout. The stainless steel also makes it easier to clean the grill because of the steel’s properties.
While using and running a pellet grill is child’s play, catching the right offer on pellet grills can be a hassle for consumers who have little to know clue about it can prove a costly bargain. Knowing your facts prior to buying one is always a good a smart idea. My pellet grill review will do the best it can to educate you on the things you need to look out for when purchasing your perfect grill. Here are a few heads-up:
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?

Less smoke and less heat – Pellet burners do not produce a strong smokey flavor like stick burners, for example. As we mentioned earlier, they also do not reach the same high temperatures as other types of grills, so you cannot expect great sear marks either. Some model like the Camp Chef PG24 Deluxe let you get around this by purchasing a sear grill attachment.
The best thing about pellet smokers is that unless you’re buying the absolute cheapest models, there are no bad choices. In this list for under $500, you’ll find pellet smokers and grills perfectly suited for dropping a few burgers at home use like the Traeger Junior Elite, for throwing in the back of the van and using anywhere like the Green Mountain Davey Crockett, or for cooking whole turkeys when you have ten people round on Thanksgiving, like the Camp Chef Smokepro.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.

Something you may not have read in other Pellet grill reviews is that there are two key concerns: flavor and fuel consumption. As previously stated, pellet smokers are not known for producing a strong smoke flavor, no matter what pellets you use. Though, some brands can be more pronounced than others. Hardwood pellets provide longer overall burn times per pound than fruit wood pellets. 1oo percent fruit wood pellets will also be more expensive on average.

Although I marked price high. I would buy it again, tomorrow. I was a novice. I had never smoked anything when I bought this. It is amazing and if you asked my friends and family I should have opened a bar & grill. It's grills better than any gas grill u can buy. The YS640 only gets better with time you get good at using it. It's the best cooker on earth. If your considering paying over $800 for a cooker. Spend the money... you will not regret it. My cousins have Traegers.. and they smeared by them. One weekend at my cabin one has ordered his the other don't have the money yet. I have used it a minimum of 2 days a week and have already got my money out of it by not ruining meat. The guys at Yoder have a monopoly. No one makes a cooker that could stand up to it. THANK YOU YODER. YOU HAVE MADE SOME GREAT HOLIDAY MEMORIES FOR ME AND MY FAMILY. Remember if your on the borderline don't know if it's worth a little more. By the 12th month of owning it. You will look at your wife or girlfriend and say "I'm so glad I spent a little extra and got that. It's beautiful.


Hi Brad! Thanks for your comment. I’d give Grilla Grills a hard look. Their Silverbac model is as solid as they come. The sear box on the Camp Chef is an interesting addition. Given that it’s propane powered, it would be pretty much light, turn and go. So, as you said, low maintenance. Still… with a set of grill grates, you should be able to get a sear at top temps on most pellet grills that would meet your expectations.
Hey Pete, first thanks for your kind words. Traeger pellet grills fell off a bit quality wise over the past several years. That said, they’ve hired a new CEO – formerly from the Skull Candy Head Phone company – who brought that company’s valuation up considerably. I see them making moves to get back to their roots… aligning themselves with some of the more well known names in BBQ again. From a build quality, they’re making solid pellet grill bodies using fairly heavy steel. The area I’d like to see them improve on is the controllers they use. Right now, GMG is making great strides in claiming some of the entry level pellet smoker market share away from Traeger. This is due to a superior PID controller, advances in built in Wi-Fi monitoring, and outstanding customer service.
Second, you’ll have to figure out what BBQ pellets you want to use. There are many different brands, blends, and mixes to choose from, and you’ll likely want to do some side by side testing to see what you like best on what meats. My very good friend and BBQ buddy Shane Draper really likes to make his own blends  – using different woods in different proportions depending on what he’s cooking.
Is it customer support? I ordered a grill cover(made by a outside vendor in Kansas as well) for my YS640. It ended up with a small leak. I called Don, and by the end of the week I had a brand new one. Also, I was getting ready for my first cook on my brand new YS640, and I invited the whole family over for baby back ribs. I called Joe, and he talked with me on the phone for 20 minutes explaining how the grill worked, what temp to set the pit at, when to rotate the ribs and even which ribs will need to be rotated. Joe was spot on! Best ribs I have ever had!!!
My wife and I were one of the first buyers of the YS640 in 2010. We had owned a couple of gas grills that, of course, eventually rust out. My wife saw the YS640 at the Kansas State Fair and called me and said that I HAD to look at this smoker! At first, the smoker had many problems--inaccurate temps, huge swings in temps, etc. Don and Joe kept working on the problems and installing updates--never charging us for updates or service calls. Finally, in about March of 2011, they installed the update that really was the solution. Since then, the YS640 has been a consistent workhorse that does everything as advertised. Built like a tank. built to last. Don and his staff stuck by his product and by his customers. In this day and age, customer service is uncommon. By the way, I thought the YS480 would have been big enough, but my wife said, "our family isn't getting smaller,".....I'm very glad we got the 640 and the second shelf. I have needed it many times. Thanks Don!
Barbecuing is supposed to be hard. It should involve chopping wood, breathing in charcoal dust, and hours upon hours to keep a constant temperature from your grill. A pit master would never subscribe to the “leave it and forget it” philosophy that a pellet smoker brings to the table, right? The best pellet smoker reviews show that this isn’t necessarily the case.
Next in our pellet grill review is the Green Mountain Davy Crockett pellet grill. Its small size makes it a portable grill. It weighs 57 pounds and measures 14.5 by 20 by 29.5 inches in dimensions. The Green Mountain pellet grill has 110V or 12V adaptors for 3 power options. It has foldable legs that also function as handles. This pellet grill also features a thermal sensor which monitors the grill temperature called Sense-Mate. One coveted feature on this pellet grill is that is Wi-Fi compatible.
Camp Chef Stainless Steel with Beveled Edge Large Spatula:Larger surface area to better handle larger amounts of foodsSturdy bevel...ed edge perfect for scraping griddlesLarge comfortable handle with hole for easy hangingDurable stainless steel constructionBlade size: 8.5" x 3.75"Blade width: 3.75"Handle length: 8.5"Overall length: 18.5"Blade material: stainless steel90-day limited warrantyModel# SPLG read more
The cooking surface is relatively small – the grill surface 12” x 16” (192 square iches) with the hood being 7” tall at the highest point. This is just big enough to cook some larger cuts of meat like tri-tip or brisket. However, small size is not necessarily a downside. While you won’t host a 4th of July cookout with this pellet grill, the small capacity and the compact size of the Davy Crockett pellet smoker makes it a perfect choice for condo dwellers or for picnics.
×