Number two when cooking with charcoal (yes plain Kingsford is good stuff if you do it right, a lot of the cheaper brick and cheaper lump can put some weird twangs in your food) brick or lump can produce quality high temp steaks or slow & low bbq! To add some nice flavor add some wood, but do your homework! I think Clark ‘Smokey’ Hale has one of the best books ever for the grill and Q master, “The Great American Manual on Grilling and BBQ or something like that. Last I saw you can grab a used one on Amazon for a few cents and some shipping. The most prolific thing I read in there that so many miss, is burn your wood and your charcoal to where it is literally a coal of gray ash covered glowing ember. Do that and you will find a new flavor in your cooking! Problem is so many places think heavy smoke is great, as they are trying to imitate cold smoke flavors! They are not the same! All this talk I see here about, “I want heavy smoke flavor.” I can tell you if you burn your wood and your charcoal (and I feel even lump needs to be well on it’s way to gray ash covered or you get bitter smoke even though many say not necessary) to a red ember with gray ash covering 80 to 90% minimum preferably completely covered your flavor profile will change. Many supposedly good bbq restaurants I have been in serve something with a bitter or ash flavor, which I find much less enjoyable.
In 2010, I sprung for a discounted Rainer with $80 in tip money and a pro deal through the whitewater rafting company I worked for. It was an expensive purchase for me at a time when my monthly food budget was around $60. But hey, along with a Roll-a-Table, two chairs I “borrowed” from the rafting company, and my cooler, I had almost a full kitchen that I could deploy from the back of my truck. And the Rainier quickly proved a wise investment.
Hey Rob! First, I really appreciate you reaching out. That’s what The BBQ Beat is for! To your question, I own a Davy Crockett Tailgate Model pellet smoker and really like it. Full disclosure, it was given to me by the company to test and Jason Baker of GMG said I could just keep it. But, I get a good number of products to review sent to me and a whole lot of them don’t make it onto the blog. I’d rather “omit” than “detract” – keep things positive sharing the stuff out there that I can get behind.
Due to the lower oxygen at 9200 FASL, I cannot keep the smoker hot and I cannot get it above 250 Deg. F. I seem to be limited due to the diameter of the smoker…just can’t get enough coals and air to get and maintain temps. Therefore, I want to buy a new smoker, on that will regulate temperature at temperatures of 200 – 450 deg F. Any experience or guidance for a smoker brand and type (wood pellet, charcoal, or electric) at high altitudes? i am looking for a smaller size smoker unit.

Because the burn pot is small, there is usually a hot spot directly over it. Some units have an optional perforated section above the burn pot so you can put the meat over direct flame, but the ones I've tested still do not sear properly. And there is no way to set up a 2-zone cooking system with a cool zone. As with most other grills and smokers, the differences between lower and upper racks is not huge, so think of it as one heckuva indirect heat convection smoker with precision temperature control.


Many products have a problem at some time in their life. My Yoder 640 was one of those products. Here is what is different. You all know that sinking feeling when you have a problem....and get ready to call customer service. We sort of steel ourselves to be prepared for the response....or actually, lack thereof. NOT AT YODER. After fully explaining my problems to Joe, he and his company completely exceeded my expectations. My customer service experience was world class - rivaling famed LL Bean, Amica Insurance and other. This is old honor. They better be careful though.....this kind of customer service is going to create raving customers and more business!~

For anyone thats thinking about getting this grill and this hung up on the price, you just need to take the plunge. And when you take it home you will realize it's worth every penny. And then after your first use, you will feel that you under payed. My first smoker grill was a green Mountain and there is just NO comparison on the market to the YS640. Grill grates and other add on's are amazing as well. LOOK NO FURTHER IF YOU WANT A GREAT GRILL/SMOKER/OVEN... ECT
This next video is great because it really talks about how solid the construction of the Rec Tec Grill Pellet Smoker is. You’ll note several times that the reviewer says how surprised he was at how heavy the lid of the cooker is. Folks, nothing… and I mean NOTHING cooks as well and as evenly as Heat Soaked Metal! That’s why cast iron is so prized for cooking ability! Also pay attention to the heat probe readings you see in this video. The one thing everyone who has used this pellet smoker says is that the Rec Tec Grill keeps actual temps where set temps read better than nearly any other pellet cooker out there.

Kevin, appreciate your reviews and insights. I am currently looking for my first pellet cooker which will be primarily used for camping, therefore I will likely purchase a portable unit. Your review on the GMG Davy Crocket answered some questions for me. I was initially contemplating the Traeger Junior Elite and GMG Davy Crocket, but after doing some homework I’m now considering the Rec Tec Mini as well. I can purchase the Traeger and GMG now for $350 and the Rec Tec for $500. My dilemma is that I (like many others) take very good care of my gear/equipment, so whatever I purchase, I expect to get a great deal of use out of. With that said, making the wrong decision could be a 7-10 year mistake. There are aspects of each that I like, I guess my question is whether spending another $150 on the Rec Tec, in your opinion, would be worth it to you? I understand if you would rather stay away from specific recommendations, and if that is the case, any other thoughts you have would be appreciated.
Pellets are available from a number of sources because they are popular for use in home heaters, so if you are worried that you will be buying a gizmo that might be worthless someday if the pellet supply runs out, it is unlikely. As more and more pellet grills appear, and word of their excellence spreads, sources for pellets will become numerous. I've even heard of a few Home Depot's carrying them. The bad news is that I have tried several brands and I always return to BBQr's Delight. They seem to have the least sawdust, so they are less likely to clog the auger, and they have a higher percentage of the flavor wood on the label.
Another video I thought it’d be cool to show you guys is one that features BBQ Diva as she shares her thoughts about how Fast Eddy’s Pellet smokers work with BBQ Ribs. You’ve likely read the Diva Q DIY BBQ Sauce post we highlighted here. And no doubt you know about Danielle’s work with the now famous BBQ Crawl television series. Without question, she’s one of BBQ’s greatest treasures. Check out what she says here about Fast Eddy’s. The video starts out with Ed Maurin showing you the recipe he used for the World BBQ Championship Perfect Score Ribs in 2000 — using both baby backs and spares. Diva chimes in near the end with her take on how these ribs taste.
For me, grilling is a way to communicate to the people in my life that I love them and to easily involve others in my passions and hobbies. So, to be able to guarantee perfection in every meal isn’t just about eating well, it’s about reliably being able to put my best foot forward with these people who matter. And the remarkable thing about the Traeger is that you can expect to be able to do the same from the very first time you use it.
One thing we humans tend to forget amidst hustle bustle of our fast paced and commercial lives is that we should earn to live, not live to earn. So I think it is high time you ditch your shoe-box of an office behind for a day and live. Spend a day with your family at the park, or maybe catch up with your childhood friend over a beer or two and start doing barbecue. You cannot even begin to imagine how much spending some quality time with your loved ones can help you and them, revive and replenish the monotonousness. And there isn’t a better way to mingle than over a small get-together with some amazing food and great company cooked on your pellet grill.
Well, so are your friends, neighbors and family members. With the Woodwind wood fire pellet grill, mediocre grilling can be a thing of the past. Put the bland chicken and burnt steak behind you, and become the grill master you were born to be. With digital temperature control, the Woodwind does all the work for you. All you have to do is turn it on, set the temperature, and let it work while you play. Which means no more babysitting. The Woodwind doesn't just make grilling easier it also makes it more delicious. The Woodwind is fueled by premium hardwood pellets to generate heat and smoke, infusing your food with a savory wood fire taste that'll make your taste buds sing. With grill temperature settings from 160°F to 500°F and the included Sear Box that reaches up to 900°F, you can achieve perfect results, whether you're grilling, smoking, baking, roasting, braising, barbecuing, or even searing. And when you're finished cooking, cleanup is a breeze with our patented Ash Cleanout system. Discover the heavenly taste of a wood fire pellet grill with the Woodwind. Buy now to begin your journey to grill mastery.
I recently purchased a a Smoke Hollow pellet grill from Sam’s. Seems like quality is good and it was recommended by a friend. Temperature control has issues. I called for customer service a couple of times and they sent a new thermostat. Still can’t get temperature to to hold at setting. Am I missing something? Told to start and let preheat for 10 minutes and then move to desired temperature. Tried setting new thermostat at 190 and let it go for 15 minutes and it was back at 230 when I checked it. Any suggestions?

Rec-Tec has a strong following, and – as with the rest of the pellet grills in this review, will do you right. They’ve recently gone to an all black (no more red) look with their newer models. Though, you can probably still get the red. They have the most pellet holding capacity of any other grills pretty much, so that might be a plus for you. Getting temps back down is pretty fast… 5-10 minutes or so. I’d consider reverse searing, so long as your steaks are 1 and 1/2 inches or more. Thinner cuts won’t work. So, basically – you get the steak up to around 125-35 at around 225-250 F. Wrap it in foil. Then, crank your heat up to the highest setting, remove your steak from the foil, and sear it off on both sides to your desired doneness level. This limits the amount of grey – making for a more uniform pink from the top to the bottom of the steak.


This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.
I have ate a few peoples cooking that have won at the Royal, Houston and Memphis in May. They have all had one thing in common, I didn’t put one drop of sauce on them and they had not been sauced on the Q before serving! The restaurant Cackle and Oink is just a ways from where we live and the owner Aaron Vogel is there regularly. I have tasted all his sauces and they are very good, but the 3 times I have been there, his sauces never touch my ribs and brisket! Aaron does say, if you like this you need to try my competition food (which I will at one of the competitions he is in locally). None of the KCBS, Houston or Memphis in may winners Q had even a hint of ash or bitter smoke flavor. They also had a very light smoke profile. They also all say they cook over well burned down wood.

In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?
The Camp Chef Collapsible Garbage Can is a handy container for removing leaves, cleaning up after parties or for use on camping tr...ips. This camping garbage can contains spring-loaded setup for fast and easy use. Two plastic toggles keep it collapsed for transportation and storage. Made from Polyethylene construction with metal coil support, this collapsible garbage can is rugged. The 35 Gallon Garbage Can provides for cleaning up a large area without having to stop to dump in between. Featuring dual carry handles and a built-in zippered lid, this garbage can is convenient for tailgating, backyard barbecues and more. read more

First, you have to figure out what your budget looks like. Of the pellet smokers I cover here, theRec Tec Grill Pellet Smoker is the most economical and best overall value — with solid construction and top end electronics controls. At just under $1,000 it’s a great buy that should last you a very long time. If you can move up from there cost wise, I’d go with the Yoder pellet smoker. While the Rec Tec looks like a beast, the YS640 absolutely IS one. Weighing in at 315 lbs and boasting solid control components and features, you won’t ever need another pellet smoker in your life unless you just want another one.
To your question regarding Traeger, I’ve not reviewed their grills of yet. I do know that Traeger as a company is taking steps to up their game some, as quality/reliability of their pellet grills has diminished over the last few years. The new CEO – Jeremy Andrus – they hired comes from the Skull Candy company and brought that headphone company from annual sales from less than $1 million to nearly $300 million. I know also that a few big hitters in the BBQ world are being contacted by Traeger to bring the brand back to its former prominence. You can read more about that here from the site of one of the company’s that now has an ownership interest in Traeger: http://www.trilantic.com/News_Story.aspx?StoryType=1&ID=56.

Technology is a focus of many pellet grill manufacturers today including features such as Bluetooth temperature controls with an option to download an application on your smartphone. While these features are great, they can sometimes get in the way of the actual materials used to create the structure of the grill. At Grilla Grills, we’ve always put the focus on what we, and our customers, believe are the most important components of the grill. That means you’re paying for high-quality components in the places that tend to be most likely to fail on other cheaper grills, and many in the same price range that have more bells and whistles.
The Ortech has two knobs. The large one, the "Cook Control" has settings for: Off, Smoke, 180, 225, 250, 275, 300, 325, 350, 375, and High. One smoker manufacturer says that the "Smoke" setting is about 160°F and "high" is about 525°F, but both can vary due to ambient temperature, humidity, fuel type and quality of the smoker. Another knob, a teensy weensy knob to the right of the LED screen looks more like a push button. Labeled "SMOKE" and called the "Smoke Control Knob", it is meant to turn, not push, and it controls the pellet feed rate with auger on/off sequences indicated by "P settings". The P settings range from P0 to P15.
Moving on from the orangish-red looks of the predecessor RT-680, this newer model has a black hood, with stainless steel built. It is 2.5” taller than the RT-680 and has 2 stainless steel bull horn handles on the outside that will have you falling in love with its built. Everything from the towel rings, the controller shelf, the hopper lid to the spill-proof bucket hook is stainless steel and even the smallest of details like the laser cutout of “Rec Tec Grills” on the side will never fail to impress.
OK. I’m rambling a bit. To your point regarding Traeger. I think that the models you can buy at big box stores (Costco etc) are OK. I still hear a few complaints about blistering paint etc. But… their Pro Series Models are a different story. The new management at Traeger has come a long way in their efforts to reaffirm the Traeger brand as a legitimate BBQ Pellet Smoker brand that everyone from the backyarder to competition pitmasters can get behind. To that end, they only allow specialty retailers carry the Pro Series models, which are built with a bit more heft and better PID controls, electronics, etc. You can find these at Ace Hardware stores, places like the Whiskey Bent BBQ Supply store we have here in Lakeland, FL (there is now one in Odessa, FL) as well. You can find a Traeger Pro model by going to http://www.traegergrills.com/dealers.
Traeger sent me replacement; fan motor, auger motor, temp controller, then a whole burner module assembly.  None of these parts helped my problem at all.   After working with them thru about 10 phone calls, I finally talked to a second level supervisor named Jessie.  He agreed my grille wasn't working properly, but would not let me return it.  I told him I would accept a replacement 22 inch grille, which I believed would get up to temperature.  He agreed, but would not agree to refund the $200 difference in price.  I decided to cut my losses and accept this offer.  He said he would call and email back with shipping details.  That was over 2 months ago and no call.  I've since called them 3 times.  The phone help doesn't know Jessie and always claim to leave him a message...but still no call.   I'm way past the time limit to protest the charge with my credit card, so I guess I'm stuck with this piece of junk.  This kind of lack of integrity from a company does not deserve anyone's business.
Most grills feature a primary cooking area (the main grate) and a secondary cooking area (additional racks). In a pellet grill, there’s less difference between the two grilling areas because it mainly cooks by indirect heat, so the temperature is the same throughout the grill. It’s best to pay attention to a pellet grill’s total cooking area because it is the sum of the primary and secondary cooking areas.
×