Just putting a stamp on your info and recommendations. The Pro is definitely a Pro! Consistent, excellent temp control, juicy and great flavor. Smoke ring, some of my ribs are pink all the way through and dripping with juice. Smoke profile, good, not over powering. I have used 45# of hickory so far, 20# of cherry and a few pounds of apple and pecan. Have not tried anything but Lumberjack but that will be the next experiment. I have tried the smoke tube and it is ok. I was worried about getting an ash or bitter taste as the smoke is fairly heavy and a little acrid smelling if you let it burn from bottom to top. So I lay it down and light on my wife’s Weber gas grill side burner and get the whole thing burning good and then blow it out. If it smells acrid your meat will get some of that taste. Starting the tube this way it is still going an hour later.
Compared to the features, Daniel Boone’s price is quite reasonable. But with brands like Camp Chef and Traeger in the market, it has been difficult for GMG to take more than one spot in our top 10 list. Regardless, this is the best product GMG has to offer, having a balance between price, cooking space and features, bringing it to our honorable mentions list.
The entire system was designed in order to make smoking fun and easy. Cleanup is easy, getting everything going is easy, and food turns out great every time. The main cooking area 292 in.², which means you can cook a lot at one time. Since it uses convection technology, the smoky hot air can circulate around the food in order to cook everything evenly.

Hey Charlie – I’d leave that grate wide open if you want maximum heat. If the grates are only over the burn pot, then you can do sort of a two zone cook (indirect vs direct heat) by putting a thicker steak, chop, or piece of chicken on the ‘non direct’ side to get up to a temp that’s 15 or 20 degrees lower than your target. Then, finish off over the burn pot area. Just one idea.


Ordering through All Things BBQ was VERY simple and easy. In fact, my YS640 arrived a few days sooner than expected/quoted. These grills are expensive, but I am a firm believer in "you get what you pay for". There is no doubt the quality of Yoder craftsmanship is exceptional. So far, I have only been able to use my YS640 a coupe of times. However, I'm looking forward to many meals being cooked on it going forward. If you buy one, you will not be disappointed!
I have had a Traeger Junior Elite for 4 years. In that time I have used it < 50 times. I have replaced a fan motor, a fuse, and now I have been trying to get a thermometer replaced. First time, the service guy dropped the ball and never sent it. Second time- the thermometer got sent around to multiple post offices. Third time, never got to me- apparently they sent it to the wrong address. Fourth time- still waiting. It's been 5 weeks now, and I cannot get the part, and have no idea if the part will fix the grill. Everyone in service has been polite, but incompetent as well. I have had 2 flash fires in the grill from the auger pushing too many pellets into the hot pot, the temperature fluctuates wildly. Save yourself the frustration: avoid Traeger at all costs!
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
This is best pellet smoker for the money if you are a newbie but want to cook like a pro. It is super easy to use and allows you to set up the whole system and then walk away. It has an electronic autostart ignition, which means you don’t even have to start a fire. Just plug it in, do a little prep work, add some pellets, and it will not be long before you have some delicious food to enjoy with your family or serve to your friends.
I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
It’s capable of many of the same feats as its sibling grill and other top-rated competing grills, but its piece de resistance is its Smart Grill Technology that allows you to control the temperature as easily as conventional ovens. Just don’t let it sit in direct sunlight and muck up its temp. The bottom line with this “smart” grill is that it has more pros than cons.
Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.
In my experience, running Traeger pellets, the grill has functionally three temperature settings;  1) Off. This is self explanatory. Looks very pretty on a picnic table in the campground or on your patio table.  2) Hot and Smoky. Wide temperature swings, over-fueling, massive smoke followed by high temps. The controller gets into a "correction induced oscillation" of ever wider swings in temp potentially resulting in either Ler or Her shut downs.  3) Very, Very Hot. This is the high setting where it will run 500+ temps and gets the deflector/drip pan very hot even with the lid open. Burner sounds awesome in Open Lid Mode. Very Macho.
Words like Grilling, Barbecuing and Smoking are often used interchangeably by us. However, when looking at them from a grill master’s point of view, there are some subtle methodological differences among these three: One is done with the lid up, BBQ is done in a closed circulation with the lid down, and smoking is a slow cooking process in a closed circulation.
Versus other hardwood pellet grills, Traeger represents a good value whether for a gift or for general use, although if you’re looking for a fully Made in America grill, you’ll want to consider other options. If you decide to go with Traeger, be certain you’ve thought about how much grilling area for food you’ll need and pick an adequate model, as the various Traeger grill price points depend heavily on available grilling area.
Accurate, powerful, with a lot of options, good build quality and a nice set of features, all at an excellent price, the Camp Chef PG64 is our best overall pellet smoker. Of course, the RecTec still offers more options, but it’s more expensive, so if you want the absolute most for your money, without breaking the bank, you’re going to want to look closely at this.
How? I just sold my house and left the Traeger with it. Now in Mexico and thinking of buying a Green Mountain. I would like to get a little more smoke flavor than what I was able to with my Traeger (which I loved). So how can you use other hard wood to enhance the smoke flavor? Also comment on how to use the tube smoker in one of these pellet fed grills. With 1 1/2″ rib eye, I would smoke for 45 minutes then crank up the heat to about 350 for 13 minutes and it would provide a perfect rare steak every time.
Does anyone know how to set up a pellet grill? Since pellet grills are a bit less common than a regular conventional gas grill, we had to conduct a bit of research and realized that pellet grills are as easy to set up, they just have more components. The components of the grill include a lid, which is designed to cover the contents of the grill as well as keep the heat in. Other than that, the ‘hopper’ is known as the area of the grill where an individual places the wood pellets and the grill drips the pellets onto the fire to keep the heat going.
Barbecuing is supposed to be hard. It should involve chopping wood, breathing in charcoal dust, and hours upon hours to keep a constant temperature from your grill. A pit master would never subscribe to the “leave it and forget it” philosophy that a pellet smoker brings to the table, right? The best pellet smoker reviews show that this isn’t necessarily the case.
This is a great smoker for beginners who are willing to take the time to understand how pellet smokers work. You can follow the instructions in the video provided on the manufacturer’s website to see how to put it together. It is also great for people who have been pellet smoking for years. It has a huge cooking surface, which is perfect for entertaining large groups of friends.
Now comes the best part about pellet smokers: they can conveniently do all these three. Coming with a large cooking space and a lid, the top rated pellet smokers would allow you to keep them open or closed, depending on what results you are looking for. With a dedicated space for putting your charcoal, you can use it as a charcoal grill, smoker or a barbecue. Or you can use it like a kitchen oven using the direct fire from the firepot. Finally, it does what it was made for – pellet smoking. Using small hardwood pellets running over the firepot in a corner, this smoker uses a fan to distribute the heat and smoke throughout the grilling area. This indirect heat ensures that the food is slow-cooked and smoked over long periods of time.
Just what I needed for my Traeger Pro 22. Fits like a glove, simple install, and makes adding and pulling rib racks off the smoker much easier. No longer a balancing act trying to get a tray to stay put on top of the pellet hopper lid. This also fits perfectly under Traeger's cover for the Pro 22 models. Have to be a little care you dont pinch your fingers when folding it down (would be a nice future mod if it could somehow be spring assisted), but thats my only gripe.
×