I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.
If cost isn't an issue, check out the Elite Wood Fire. This 200+ pound behemoth from Memphis Grills costs more than some used cars, but it's fully loaded. Wifi-enabled, an extraordinary temperature range, and a cooking space large enough to be used by a small restaurant - the Elite has it all. The pellet hopper is built to match capacity, with enough fuel space to smoke for up to 62 hours straight.

Traeger pellet grills pack big hardwood flavor, from sweet cherry, to savory mesquite, into everything you grill, smoke, bake, roast, braise, & BBQ. Traeger's wood pellets are made with 100% pure, natural hardwood giving you authentic flavor and nothing else. Grilling has never been easier—just set it and forget it and let the Traeger work its wood-fired magic.
This is a nice article for people new to pellet grill/smokers. Like jennifer, we have a vermont cast ing cast iron gas grill that has ‘rotted out’ internally. Calls to vermont cast ings has resulted in ‘we no longer support, make or sell parts for grills made before 2008’ and other run arounds. As a result we are looking for other options. We like the cast iron grills and grill heat but are considering other options, (Webber, Pellet, gas).

I have used Bradley, Masterpiece, Green Egg, New Braunfels, Oklahoma Joe, Weber and now Traeger. So there is some experience in these comments. The “set it and forget” it is a misnomer and should not be used with Traeger (or any smoker/grill.) With Pellet Drive before you buy Read up on Er codes. The worst is when the fire pot fills up with pellets because the fire can’t keep up with the auger push and the whole cook is ruined or delayed. You have to pull everything out and basically start over while your expensive prime brisket is trying to be saved in the oven. Doesn’t matter what the weather is or wind conditions. Doesn’t matter if you stare at it and stir the hopper continuously. It will happen. Customer support at first was well you are at fault (didn’t leave the lid open on fireup for exactly 2 to 4 minutes or didn’t vacuum out the firepot between every cook) which is crazy. Finally, after so many calls over the past 6 months they are trying to make it right. Problem is, DO NOT believe the “set it and forget it.” That does not exist with any good cook. I have replaced the controller the fan and now getting a new probe. Do not waste your money. Unless someone out here in BBQ land can give me a recommendation on a product that won’t do this stay away from Pellet Drive?
Hey Chris, IMHO the Blazing Pellet Smoker looks like a solid unit. There’s a good review of it here. I think between the units I might give them a run. Yoder makes quality stuff, and if made in the USA is important to you, they fit as do the Blazings. All this said, if you’re basically using the pellet smoker like a Cambro, you could opt to save a little money and go with the Rec-Tec. Good customer service and solid following.
Pick an item that is anything but difficult to clean and store. Stay away from massive units on the off chance that you don’t need your grill to stick around in the kitchen when not being used. You may likewise need to pick one that your space can suit. And afterward, search for a model that can be effortlessly cleaned and that accompanies a deplete framework and an oil/dribble plate/gatherer.
I think you get the picture. In any case, you can see how pellet smoking really does have its own culture to it. I really hope you’ve found value in this selection of Pellet Grill reviews. If so, please consider sharing it with your BBQ friends! And for sure comment below and let me know about your favorite pellet grills, pellet blends, and methods!
Take your outdoor cooking to the next level with the Camp Chef Pellet Grill and Smoker. Designed with the home griller in mind, built-in features simplify the process of smoking. The included digital temperature readout takes the guesswork out of the cooking process. An advanced digital temperature chip gives a more steady smoke and temperature, eliminating large temperature swings and giving a more consistent cooking temperature. The Pellet Grill and Smoker features range from innovative digital smoker controls to dual temperature sensors. Discover the real secret of award winning BBQ cooks, low and slow smoking.
Camp Chef SPG-90B 30,000-BTU 3-Burner Big Gas Grill:3 burners30,000-BTU burnersAppliance-style control knobsIndependent leveling l...egsCamp Chef gas grill has a removable grilling attachmentConvenient carrying handles on the barbecueGas grill hose and regulatorSide shelf and a hinged-lid barbecue box that covers 2 burnersCast-iron, pre-seasoned grate to sear in flavorMassive grilling surface30,000-BTU gas grill is a versatile outdoor kitchenAllows you to barbecue and grill meats quicklyBurners produce three times the heat of a normal kitchen stoveUse for tailgating and other outdoor eventsAllows you to switch out cooking accessories to meet your needs16" surfaceUse the 3 stove burners in any pot, pan or skillet configuration read more 

They had the field to themselves for a few years, but the idea was too good to go un-imitated, and soon competitors began popping up. In the early days, most pellet smoker controllers had only three settings—low, medium, high (LMH)—and there was no temperature probe in the oven to create a feedback loop. So, whether you were smoking a few slabs of ribs on a scorching summer day or six pork butts during a blizzard, the controller only knew pellet-feed on and off times for its standard settings. It had no information on the actual temperature inside the cooking chamber.
Hey David, Is there a particular reason why the Grilla grills interest you? I tend to find they’re great smokers, just expensive for what they are. If you’re working with limited space (say smoking on a condo balcony) then the Grilla models vertical footprint can make all the difference between having a smoker or not. But for the price, and for a standard model smoker, the Traeger models tend to be better all around.
You prefer a direct heat method of grilling: The Traeger grill uses an indirect heating source, much like an oven, so you won’t be able to sear meat, as many people like to do when grilling a steak. The Traeger system is better for those people seeking more of a smoker type of cooking system, although you can sear your meat by using a frying pan with a little oil initially before you finish cooking it with the Traeger grill. You can use the frying pan on a stove top burner or on the surface of the Traeger grill.
Pit Boss have made this heavy duty beast as a semi-professional pellet based smoker, and it shows. It’s absolutely massive, with a colossal amount of cooking space and a lot of tech that makes using it a serious pleasure. It’s actually probably too big for most households, but if you need the most cooking space possible, this is the biggest on our list.
UPDATE 8/27 - This grill is still performing flawlessly. No error messages, maintains temperatures. I have made homeade pizzas and strombolis on a pizza stone and it actually makes them better than in the oven. Its like a restaurant wood fired pizza. I made a pork butt, beef brisket, bacon wrapped scallops....it just simply cooks everything well. Love my Pit Boss !!
OK. I’m rambling a bit. To your point regarding Traeger. I think that the models you can buy at big box stores (Costco etc) are OK. I still hear a few complaints about blistering paint etc. But… their Pro Series Models are a different story. The new management at Traeger has come a long way in their efforts to reaffirm the Traeger brand as a legitimate BBQ Pellet Smoker brand that everyone from the backyarder to competition pitmasters can get behind. To that end, they only allow specialty retailers carry the Pro Series models, which are built with a bit more heft and better PID controls, electronics, etc. You can find these at Ace Hardware stores, places like the Whiskey Bent BBQ Supply store we have here in Lakeland, FL (there is now one in Odessa, FL) as well. You can find a Traeger Pro model by going to http://www.traegergrills.com/dealers.
With a massive 700 square inches of primary grilling space, this grill impressed us when compared to other Pit Boss grills we reviewed. Its size is large enough to cook for large groups of people. It features a Flame Broiler that uses slide-plates which allow for direct flame grilling, which means you get an even cast-iron cooking each time. If the 700 square inches isn’t enough, you can make use of the additional upper cooking rack space. The racks are made of porcelain-coated cast iron for optimum grilling as well as easier maintenance.
Controlling temperature is the best way to get the desired piece of cooked meat. This smoker grill has a built-in thermostatic control and a digital thermometer, so that means you won’t have to do much guesswork during barbecue. If the sensors sense a fall in temperature, more wood pellets are added to the burner, which allows you to place the meat on grill and relax.
Once it reaches the ideal temperature, it uses an Internal Temperature Sensor to maintain it throughout the cooking process. Forget about checking on the status of your grilling every few minutes, this unit makes sure your food is cooked thoroughly and evenly — no babysitting needed here! This way, you can enjoy your time with your friends, which is what a BBQ party should be.

The cooking surface is relatively small – the grill surface 12” x 16” (192 square iches) with the hood being 7” tall at the highest point. This is just big enough to cook some larger cuts of meat like tri-tip or brisket. However, small size is not necessarily a downside. While you won’t host a 4th of July cookout with this pellet grill, the small capacity and the compact size of the Davy Crockett pellet smoker makes it a perfect choice for condo dwellers or for picnics.
×