2. The grill does not come back to the set temperature after the lid is opened and closed to place the meat. I start it, close the lid, set the temp (startup procedure has changed to this according to Traeger service tech) and after 15 or 20 minutes it is not at the set temp yet...in fact it is declining. Well I need to cook on it and cannot wait forever so I open the lid quickly, throw the meat on, and close the lid quickly.
Hey Brad, you’ve got 3 great grills there. Rec Tec has the edge on Pellet quantity. I like the build quality and support on the Grilla a bit better, especially with the extra insulation and updated comp wheel set up. Figure 10 min or so to get to top temps. Just remember to drop to around 300 F temp setting before going into the shut down cycle on any pellet grill if you’re cranking it up to the highest setting.
While many people enjoy pellet grills, some find it difficult to use pellets to produce true, flavorful steaks and barbecue since the fuel often lacks the same flavors as traditional grills. That smoky, wood flavor many steaks have is not impossible to get with the right pellet grill however. The Z Grills Wood Pellet Grill sports a combined grill/smoker setup with temperature control for the best pellet grilling experience available.
First, you have to figure out what your budget looks like. Of the pellet smokers I cover here, theRec Tec Grill Pellet Smoker is the most economical and best overall value — with solid construction and top end electronics controls. At just under $1,000 it’s a great buy that should last you a very long time. If you can move up from there cost wise, I’d go with the Yoder pellet smoker. While the Rec Tec looks like a beast, the YS640 absolutely IS one. Weighing in at 315 lbs and boasting solid control components and features, you won’t ever need another pellet smoker in your life unless you just want another one.
Decided that moving these beasts was a little challenging so I bought a Backwoods Party 10 years ago and loved it. But basically have about worn it out. And as I got older I don’t enjoy getting up at 2 AM and then having to get up every couple of hours, after the 45 minutes of getting it ready at 2 AM, to check it and feed it. I also bought a smaller lightly used Open Range, The Good One. Used their recommended method the first time I cooked with it and hated the Q off of it so bad most of it was wasted, wife hated it too and the son ate most of it. It was extremely ash/strong smoke flavored!
Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.
Are you sick and tired of bad BBQ? Well, so are your friends, neighbors, and family members. With the Woodwind woodfire pellet grill, mediocre grilling can be a thing of the past. Put the bland chicken and burnt steak behind you, and become the grill master you were born to be. With digital temperature control, the Woodwind does all the work for you. All you have to do is turn it on, set the temperature, and let it work while you play. Which means no more babysitting! The Woodwind doesn’t just make grilling easier—it also makes it more delicious. The Woodwind is fueled by premium hardwood pellets to generate heat and smoke, infusing your food with a savory wood fire taste that’ll make your taste buds sing. With grill temperature settings from 160° F to 500° F and the included Sear Box that reaches up to 900° F, you can achieve perfect results, whether you’re grilling, smoking, baking, roasting, braising, barbecuing, or even searing. And when you’re finished cooking, cleanup is a breeze with our patented Ash Cleanout system. Discover the heavenly taste of a woodfire pellet grill with the Woodwind. Buy now to begin your journey to grill mastery.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
This smoker has cooking area measuring 560 sq. inches, large enough to allow you to smoke food for your friends and family. This is also enough to give you the best grilling experience, as we’ve found after reviewing the top products from Camp Chef. It also has a useful rack where you can keep your smoked food hot while your waiting for your whole meal to come together or that one couple who always arrive late for the party.
My brother said his Traeger blanket saved pellets in cold weather, so after talking to him I decided to order one. Used it for the first time today. The blanket went on easily & fit the grill perfectly. The temps this a.m. was below 0 when the meat started smoking. So far so good! The grill hasn't extinguished itself, a problem we always had when cooking in the cold, the temp of the grill is cooking like it does in the summer, & the meat is smoking beautifully. If you Traeger in cold winters this accessory is a must have!
In 2008 there were only two consumer pellet grill manufacturers. Today there are dozens. The market for these relatively expensive devices is small but growing fast. Not all of these small manufacturers will survive. Forget the warranty and ask "When it breaks will the manufacturer still be in business?" They do not have repair shops near you. When it breaks will they be able to diagnose the problem over the phone? They may be able to figure it out, but then you have to buy the replacement parts and do the repair work yourself. Are you up to the task?
We love recommending and reviewing wood pellet smoker grills, but we also want you to get the most out of them once you purchase. Without proper care and maintenance, even the best pellet smoker is bound to have a shorter lifespan. Therefore, how you use your smoker and how you maintain it after use greatly determines how long it will serve you. A little bit of work will go a long way toward extending the life of your smoker. A thorough cleaning of the smoker should occur at least once a year. If you frequently use it, you should have it done at least three times a year. Buying quality pellets will extend its life as well.
Good info, but it’s missing something… the cost to use. I’ve been looking for a long time to get into smoking. I have only ever used a propane setup for grilling. My main quesion is the cost to use propane vs charcoal vs pellets. I’m very interested in pellet smoking AND grilling. A couple times a week my wife and I will grill some chicken breasts or steaks. Can you breakout an approximate cost comparison to run the different methods? Appreciate it!
The old camp chef is heading to a new home. We have been thru thick and thin, rain, or snow, on two ocations high wind blew it off the patio. A few dents bad scratches but it still works like a top. My son is driving in form North Carolina to take it off my hands this weekend it has been replaced by a yoder ys-640. The yoder is bigger and heavier with more btu output if needed. But the camp chef still is easier to clean out and cooks a fine brisket.
First impression was this thing isn't built like a mass produced unit, it's more like something you would expect from a master fabricator. The assembly instructions were incredibly detailed, and the way it was packaged made it really easy. It takes a little time to get temp steady for low smoking, but once it's there it seems to be pretty steady. So far absolutely impressed with everything about this cooker, and made in the USA!!!
Hi – my husband and I are really interested in a pellet smoker. We came across some when we were at a fair and are trying to find more information about the Traeger brand because the price seems affordable compared to all the others you mentioned. You started out talking about the Traeger but never gave any feedback on it? Little help please:) Thanks!
Wattage – With the right amount of wattage by your side, you will easily reach the temperature required, and it will stay there provided that you are providing enough pellets for it to make use of. Anything north of 1200W will easily be able to cover all your requirements, but as a rule, it’s ideal to be sheltered than sorry, so it can’t hurt to purchase a unit with a bigger Wattage than you might suspect you’ll require.
I do have a question for you that i didn’t already find answered… How important do you feel a pellet release option is for a pellet fed BBQ? I have only found 3 models that have it; Traeger, Cabela’s Pellet Grill, and Camp Chef. It seems to me that this would almost be a must to make things easier to clean up when done smoking. What are your thoughts on the pellet release, and then your thoughts on these 3 pellet grills.

As you can see in this selection of pellet grill reviews, the act of heating pellets and generating smoke in any pellet smoker is pretty much the same. Yes, some pellet grills use thicker metal, have better thermostats, air flow, racks, drip flow, etc. But the ask any professional BBQ cooker who uses a pellet grill, and they’ll tell you that the quality of your smoke really does come down to the pellets themselves. Here’s what one very astute BBQ pro had to say over at the Pellet Smoke Ring:
Secondly, make sure you pay attention to the controls and temperature settings. As well as a thermostat, higher quality smokers come with meat thermometers built in. As you cook, the internal temperature of your meat is going to rise, and unless you’ve got a meat thermometer, there’s no way of knowing exactly how hot it’s got. If you don’t know why this is bad, when you let food sit too hot for too long, you run the risk of drying it out. You’ll undo all of your good work, plus it just tastes bad.
Is it common to have a lot of ash blowing throughout these pellet smokers? I thought it was supposed to be minimal ash and that it’s supposed to stay in the firepot. I noticed after two short cooks I have ash everywhere. The pellets are Perfect Mix from cookingpellets.com, but by “perfect mix” I don’t think they mean to mix ash from their product with your BBQ. Also, didn’t put off a lot of smoke, and really couldn’t taste any smoke at all.
Once it reaches the ideal temperature, it uses an Internal Temperature Sensor to maintain it throughout the cooking process. Forget about checking on the status of your grilling every few minutes, this unit makes sure your food is cooked thoroughly and evenly — no babysitting needed here! This way, you can enjoy your time with your friends, which is what a BBQ party should be.
The Smokepro comes with many of the extras that define the Camp Chef line of products, such as the easy-to-use ash removal system as well and an interior fan. This model comes with easy-to-use controls and an LED temperature readout so you can monitor internal temperature at all times, even if you're cooking at night. The unit also comes with a convenient meat probe for ensuring that perfect finish.
As far as size goes, bigger is usually better when it comes to pellet grills. A large hopper means a longer time you can cook without needing to refill your fuel source. A bigger grill size means more room for a variety of meats or side dishes. Look for at least 700 sq inches of cooking space (that can include the upper rack as well – remember, pellet grills work like convection ovens.)

Hey Pete, first thanks for your kind words. Traeger pellet grills fell off a bit quality wise over the past several years. That said, they’ve hired a new CEO – formerly from the Skull Candy Head Phone company – who brought that company’s valuation up considerably. I see them making moves to get back to their roots… aligning themselves with some of the more well known names in BBQ again. From a build quality, they’re making solid pellet grill bodies using fairly heavy steel. The area I’d like to see them improve on is the controllers they use. Right now, GMG is making great strides in claiming some of the entry level pellet smoker market share away from Traeger. This is due to a superior PID controller, advances in built in Wi-Fi monitoring, and outstanding customer service.
Use of the P settings in smoke mode is easy to understand. But one can also use them as a dual function feature in cook mode. Remember, in cook mode the auger idles when the temperature is correct, but the P settings continue to function in idle mode. Ortech recommends the P2 setting as the default idle rate in cook mode. However, as one gains experience, the P settings can be used to improve the grills performance. For example, when using high temperature settings, select P1 or P0 to reduce auger off time and maintain strong, steady heat. If you have trouble hitting low temperatures on a sweltering day, increase the P setting to increase auger off time. It does not have a significant effect on smoke production. The basic rule remains: Low heat = more smoke, high heat = less smoke.
One of the fun features this grill offers is that it’s WIFI enabled (controlled or monitored through an iOS or Android app). Sense-Mate, a thermal sense that constantly monitors the grill temperature, keeps you up to date on the status of your grill and your food! The digital controlling really lets you micro-manage your cooking, as you can adjust it a degree at a time. You can also program a series of temperatures and then sit back and enjoy your day while your food cooks! (Yes, you can also control it manually as well.)
As another criterion that we took into consideration, we felt that the pellet grill size was important to include in our selection process. One of the main reasons is because we wanted to share a wide variety of pellet grills that were designed for multiple uses. With that said, other reasons include the size and weight of the grill as well as the price. Meaning, the bigger the grill the more pricey it can become and the more it will weight depending on the material design. However, we also wanted to share compact varieties such as the Green Mountain Grill which is perfect for tailgates and small outdoor events or camping.
WiFi capability: Companies have started to take advantage of the fact that pellet smokers have a computer in them by design. By integrating WiFi connectivity, you can monitor and control the temperature of your grill from just about anywhere, as long as you have an Internet connection. Companies like Green Mountain Grills are now providing free apps that you can download and make use of for ultimate convenience.

Bought Junior Elite 20 pellet grill at Costco special sales event. Took it home and it simply wouldn't get up to temperature to ignite the pellets. Auger made extremely loud noises and then simply refused to operate. Packed it back up and returned to Costco with no problem. They had no inventory so I called Traeger. Woman on phone was very pleasant and helpful. Asked if I could get Traeger to simply replace the grill at the same price I purchased it for. Her supervisor said no and if I wanted it for that price I would have to drive to another state and purchase it at one of their event presentations. Made no sense to me why they would sell it to someone else for the "event" price but not to me who had already done. Poor customer support and silly supervisor. I will look elsewhere.

Just finished my first smoke on the YS640, ribs and chicken thighs. This machine is amazing. It couldn't be simpler to use. The chicken was the best I have ever tasted. The ATBBQ team was great, with fast shipping and they threw in some extras. I could not be happier and can't wait for years of great food off the YS640. Don't hesitate to buy this cooker or to order from ATBBQ.

To solve this problem, several companies have come up with alternative ways to expose food to the flame by allowing you to use the small area directly above the fuel pot. It's still not as good as a charcoal or sear burner, but better than the designs that are strictly indirect. Check out the Memphis Elite, Fast Eddy's by Cookshack PG500, and the Yoder YS640 for this feature. Camp Chef also recently introduced its Woodwind pellet smoker, which has a super-hot gas-fueled sear box attached to the right side.
This is the second one I have received as the first one was a lemon. The first one worked great the first 3 times I used it, but then I started getting "Err" message, as well as an overheat message randomly that would not go away. I returned it to Amazon and promptly received a replacement. I have used this one heavily for 7 days now and have had no problems. I will check back in in a couple weeks with my results. It is very well constructed, holds its temperatures well and cooks pretty evenly. I have smoked/grilled ribs using the 3/2/1 method, made stuffed hamburgers, a whole chicken, and a porterhouse steak so far. For the price you cannot beat it. The searing option where you can open the heat shield/drip tray to expose slots directly over the flame is great for cooking steaks and a nice option that you don't see on other models. The removable side tray is also nice for bringing out your meat and placing your finished product on it. The bottle opener is weird...u have to really put the bottle at an angle to open and you lose part of your beer....but it looks cool...lol. A few tips: Cover the heat shield/drip tray with new tin foil each use or else it is almost impossible to clean it. Make sure the knob is in the off position before plugging it in and wait for the numbers to stop flashing before adjusting the temperature. Always start out in the smoke position until it is smoking and a a flame has started, then turn it to your desired temperature(about 5 min). Vacuum out the firepot and inside of the barrel every other use. Most importantly....use this thing as much as possible in the first 30 days to make sure it is functioning properly so if you do have problems you can return to Amazon. I love Amazon. As soon as I clicked on 'Return' and printed the free return shipping label, they had already ordered me a new one and I had it in 3 days!!! In case you would have to return it, mark your boxes that everything came in and take pictures of how it was packed. Took me over 2 hours to pack this thing back up. Most importantly....use this grill as much as you can in the first 30 days to make sure it is functioning correctly, otherwise you will have to deal with Pitboss ...paying your own return shipping and replacing parts on your own.Also don't forget to register your grill right away on the Pitboss website, in case you have problems after the 30 day Amazon window. Checkout the Pitboss website for their recipes....some of them are quite good...the bacon wrapped asparagus tastes just like Carrabas. Just sprinkle some balsamic vinegar on it after grilling. The Pitboss spices/rubs, while expensive are very good. The sweet heat is good on anything and the mandarin habanero is amazing on wings. I sprinkle and toss after cooking. Good luck !!
If you’re gonna set it and leave it to do the magic, you’re going to have to be careful, too. A major contributor to how long you can leave a smoker is how many wood pellets the pellet hopper holds. Pellet smokers run the gamut in how much fuel they use per hour, with anywhere from half a pound to two pounds of pellets being standard. Always check how much the model you’re looking at holds, and make sure that it’s going to last long enough, especially if you plan on leaving your smoker to cook whilst you do other things, especially if you’re going away from home. It’s simple math, and better that than coming home to a bunch of chargrilled ashes.

Worst purchase of a product that I have ever made. After same issues the first and second cookings, I will use my good ole Brinkmann smoker from here on out. Shuts off with errors and after setting it on 250 will climb to over 400-450 degrees. They say you can set it and forget it, but I'm afraid that my home would burn down if I was not here watching over this junk. When you call customer service same old story. Take everything out, clean firepot put it all back together, then fire it back off. Take your screen out of pellet box and rake them. If you want to smoke meat you don't want to do this every 20 minutes or so. I gave over 600.00 dollars for this and have no more than 50.00 in my Brinkmann. Please read all problems with these before wasting your money!!!


This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
This unit will not let even a single pellet go to waste. No need of worrying whether you’re out of pellets or not. You can carry pellets at a maximum of 20 pounds, with the digital thermostat ensuring the pellets are being used properly. This saves you loads of cash and gives you smoking food simultaneously without wasting time in refilling pellets.
To sear a steak you need direct radiant heat. I don't care if you can heat the air to 1000°F, it is still indirect heat and that does not deliver as much energy as direct radiant heat. It's physics, but not hard to understand. In short, heat is not the same as temperature. It feels hotter at 80°F if the sun is shining on you than if it is 80°F in the shade. I discuss the concept in more detail in my article on thermodynamics of cooking.
Camp Chef Smoke ProDLX Pellet Grill:Stainless steel lid and handleElectronic auto-start ignitionDual LED temperature readout: inte...rnal cooking temps and internal food tempsEasily choose your smoke settings or desired temperatureAutomatic auger dispenses pellets as needed for improved smoker efficiencyStainless steel probe measures internal food temperatureBuilt in sensor gauge reads cooking temperatureIncluded warming rack provides additional space to cook your favorite foodsClean-out ash can makes clean up simpleLarge capacity pellet hopper means less filling, more smokingNew hopper clean out makes changing pellet flavors easier than everIncludes recipe ideas in manual SpecificationsGrilling Area Dimensions: 19.5" x 22"Smoking/Warming Rack Dimensions: 6" x 24"Total Rack Surface Area: 560 sq inHopper Capacity: 18 lbs of pelletsCooking Height: 32.5"Overall weight: 127 lbs read more 

On Tabletop Models: I didn’t include them here because though extensive, this post is more of an overview of a few select makers of Pellet Smokers I think do a fine job with both manufacturing and product support. The one exception is that I did include a link to where you can find the Rec-Tec mini. That’s Rec-Tec’s answer to the smaller, tabletop or tailgating models.
Speaking of competition cooks, you’ll find that many competition BBQ pitmasters who use Pellet grills as their primary means of cooking are among the more well rested come Saturday. The next step we’ll cover in this selection of Pellet Grill Reviews is getting your pellet grill / smoker up and running. Again, what you may not see in may Pellet Grill Reviews is repeated mention that you’re not going to get that “deep smoke” flavor profile using a pellet smoker. Though, this can be achieved by using something like the Amazen Pellet Tube Smoker 12″.

Cleaning up after grilling is every cook’s dreaded part of the process, but this pellet grill simplifies that. Its warming rack comes with a patented ash-catcher system, the Ash Can Cleanout System, that allows for an easier cleanup of the unit. Additionally, it also features a grease drip disposal system that comes with a bucket. You won’t have to waste precious time cleaning up afterward!
12 Month Financing: For a limited time, purchase $599 or more using the Amazon.com Store Card and pay no interest for 12 months on your entire order if paid in full in 12 months. Interest will be charged to your account from the purchase date if the promotional balance is not paid in full within 12 months. Minimum monthly payments required. Subject to credit approval. Apply now.
This cooker is still the best value for the dollar for pellet grills I have been looking again for a larger rig, but haven't found one better. If you are looking for an entry level pellet grill this is the one you want. Don't be discouraged by the reviews that talk about leaking smoke or not sealing well because it does leak smoke everywhere. Look at the pic I attached to my review you can see it for yourself it does, but isn't it silly to buy a smoker that doesn't smoke. If you ever go to a BBQ competition you will see most of their smokers leak smoke also.
Now, what that means is that if you have a lower hopper capacity, your pellet smoker will run for a smaller period of time. It also depends on the cooking temperature you have selected for your cooking purposes. However, at higher temperatures, they will provide less smoke; thus would be more suitable for grilling and barbecuing, but not so much for smoking.
I have been cooking Southern BBQ for 40 years, my Dad did the same. I have bought ever kind of grill on the market, built many of my own because none of the store bought grills cook very well and don't last because of cheap construction. Had been researching Pellet grills for some time and decided on the YS640. Received the grill yesterday and very impressed on everything from boxing to construction of the grill. Just fired it up to burn it in. Temp stays @350. This grill is well made, USA made ! Which is important to me. Cant wait to cook on it, know it will do the job. Thanks..All Things BBQ.....
Now, what that means is that if you have a lower hopper capacity, your pellet smoker will run for a smaller period of time. It also depends on the cooking temperature you have selected for your cooking purposes. However, at higher temperatures, they will provide less smoke; thus would be more suitable for grilling and barbecuing, but not so much for smoking.
Thank you all for a great site and an informative discussion. I am a newbie to smoking and presently have a charcoal grill for when I have more time and a gas grill for a fast meal. Its time to replace my gas grill so I am looking at alternative options. Is a pellet grill overkill, or a timely expedition, if I want to grill a couple steaks or chicken breasts during week nights? I’d also be interested in smoking larger hunks of meat (and ribs!) less often, but am wondering if a pellet grill can cover both? How long does it take a pellet grill to get to temp (e.g. 450°)? With the indirect heat, can you get char marks on your meat? Thanks in advance for the info!

A: This may be considered the million-dollar question for many reasons. When it comes to a pellet grill, individuals have to clean it out a bit different than a regular grill because there are unique elements to clean. Many individuals recommend cleaning a grill after every use depending on the size. However, for larger grills, it is recommended to clean it after four or five bags of wood pellets. Now, what you do is vacuum out the ashtray. Some brands do have an automatic ashtray cleaner. If not, then you have to vacuum it out with a vacuum. Other aspects to clean include removing the grease drain pan, removing the porcelain grills, the heat baffle, and properly washing with warm water and a bit of soap. Most brands will have cleaning instructions in the guidelines.
All of GMG’s like of product lines like the Daniel Boone and Jim Bowie come with similar features. In fact, the Daniel Boone will always be a better alternative to the Davy Crockett. However, the Daniel Boone line isn’t winning any spot in our budget pick due to its higher price tag. With its build and quality, it does become one of our honorable mentions, if not the pick; and the Davy Crockett continues to be the top choice for the grillers on budget.
Am considering adding a pellet grill to my fleet, have champagne taste on a beer budget. Have a smoke hollow smoker (lp) that works awesome, a cheap charbroil gril, and a holland I picked up used. Tried the holland because I got tired of flareups but it is slow, a coffee can over the stacks until it warms up helps but you don’t want to walk away from it that way. I like the idea of something you don’t have to baby sit. Any reviews on the traeger grills? I like the looks of the traeger jr, has nice features, portable and enough room for most of the things I want. Also are these grills affected by wind and do they work in cold weather? I live in ND and like to use them in the winter as long as the temp is above 10 degrees or so.
The Camp Chef Collapsible Garbage Can is a handy container for removing leaves, cleaning up after parties or for use on camping tr...ips. This camping garbage can contains spring-loaded setup for fast and easy use. Two plastic toggles keep it collapsed for transportation and storage. Made from Polyethylene construction with metal coil support, this collapsible garbage can is rugged. The 35 Gallon Garbage Can provides for cleaning up a large area without having to stop to dump in between. Featuring dual carry handles and a built-in zippered lid, this garbage can is convenient for tailgating, backyard barbecues and more. read more
The small burn pot is covered with a large deflector plate that absorbs the heat and spreads it out below the cooking surface making them essentially wood-fired convection ovens. Flare-ups are a thing of the past. You need to keep the plate clean because it is right below the food and if you leave sauce and grease on there, it can smolder and leave soot on your food. Carbon buildup will also diminish its heat transmission.
You visited your friend’s house and saw his amazing pellet smoker. Now you want one. But you don’t want just any pellet smoker. You want the best pellet smoker that you can afford. Now, you could spend a lot of time reading hundreds of pellet smoker reviews, or you could spend a few minutes going over this comprehensive guide that we have prepared.
True blooded grill sweethearts out there might value this item. It is a minimized, full-included pellet barbecue that can take care of their grilling needs. You may need the item that accompanies all that you may require. When you have warmed it up, you can anticipate a perfect temperature and warmth in view of what you have chosen. Much the same as when you have found a reasonable latte machine for you, you would feel pleased with yourself for picking an extreme item that stays aware of your needs. Another element you may acknowledge in the item is that can keep the correct temperature all through the barbecuing or cooking process—regardless of whether you burn, grill, smoke or prepare. The cooking instrument is an exact griller that won’t make you stressed over any temperature variance. So whether you are an amateur or a pit ace, you might need to investigate this item that can take your grilling to the following level.
One of the most outstanding features of this smoker is its digital thermostat controller. It is also small enough to be used for family gatherings but large enough to be used for tailgating parties. With it’s 292 in.² of cooking space, you can cook a lot at one time. The entire cooking surface is 15 x 20″. It is made from steel and has a porcelain coated grilling grate.
I bought this grill in May 2018. Had to return it to Ace 9 days later because it wouldn’t keep temp or would go out and fill up with pellets. I had to have the GM of Ace fight for me to get a new grill from Traeger. Once I did the new one seemed to work for about a month. Since then this one does the same thing as far as heat and pellets. I thought this thing was supposed to be a set and forget grill. If I don’t watch the heat it will be 200+ degrees over the set heat or sometimes be at ambient temperature and I have to pull me meat, grill and grease tray out so I can empty the heat pot of all the Unburned pellets. This thing is nothing but trouble. Does it cook great meat? Yes! When it works and you babysit it the whole time. On top of that customer service is about as useless as ** on a boar! They will try and tell you it’s something you’ve done wrong. I will be buying another brand smoker and giving this one to someone who like to deal with troubles.
12 Month Financing: For a limited time, purchase $599 or more using the Amazon.com Store Card and pay no interest for 12 months on your entire order if paid in full in 12 months. Interest will be charged to your account from the purchase date if the promotional balance is not paid in full within 12 months. Minimum monthly payments required. Subject to credit approval. Apply now.

I have owned my YS640 for about 9 months now. Before I bought this I researched smokers/grills for about 2 years because I had very little experience with them & cooking in general. With the help of a few good websites I have produced some great food. There is a ton of room to cook on & the heat stays pretty much where you want it. Only a few issues I have had is that where the stack mounts to the side of the grill it drips. I did have a scratch on mine from the shipper & when I called about it I was sent a can of matching high temp paint very quickly. One thing that I like the most about this smoker is it is heavy. You can tell that this thing was built to last.


I did a lot looking around at pellet smokers before buying the ys 640. This thing is amazing! I have been cooking BBQ for about 15 years. I owned a Gator pit entertainer which is made in Houston Texas (stick burning pit) and I currently own a $25,000 Ole Hickory Pit EL-EDX which can cook 700 lbs of BBQ at once. I wanted something smaller to cook for family. The ys 640 turns out PERFECT Q every time! The amount of smoke is just right. Plenty of smoke flavor without over smoking which is very easy to do in my other pit. This is an EXCELLENT product which I strongly recommend.
Convection is achieved using a number of techniques. Air is fan forced into the grill and channeled throughout by our arched flame broiler. Our exhaust design allows air to circulate evenly along the length of the grill and to the top shelf. This combination allows us to achieve uniform heat throughout the unit whether your smoking at 170°F or cooking all the way up to 600° Fahrenheit.
It’s got built in manual controls, but there’s also the option to download an app to your phone so you can control your smoker through your wifi! Honestly, this really impressed me, and I don’t know why other manufacturers aren’t all over this. Apparently there’s a cloud based app coming out soon so you can control your grill anywhere you can get internet, so you could be sitting at your kids football game whilst checking the status of your post-victory feast! The controls are also fully programmable, so you could for example set it to smoke for 5 hours and then cook for 2, finishing just as you pull up onto your drive.

Eric, I’m sorry for the trouble you’ve had with your Traeger. Not sure this will help, but here is how I make sure I don’t have the problem you had. When I start after a long previous cook or any cook at all really, I vacuum out all the dust and vacuum out the burn pot. Then, I put a handful of pellets into the burnt pot, insert the heat deflector, the drip tray, and grate. I find that this keeps things working well. Sometimes, the burn pot will get too full of ash and this can cause the problems that you had. Give it a try. If it works, please let me know.
My propane smoker lived a good life, but after just 18 months it's another rusted out piece of junk that's was unsafe to use. I wanted to replace it with something that would last so I began researching the internet. I was delighted to stumble upon 1) pellet smokers and then 2) the Yoder 640. This is a premium price item that had me wondering if I should spend that much, but I was sold by the online reviews and YouTube video's. ATBBQ had it at my house in less that 5 days and the build quality, ease of use, and the food it helps produces are all second to none. I'm thrilled companies like Yoder can build the best products in the industry right here in America! Its a large investment in cooking, but worth every penny.

Editor's Note: If you're looking to upgrade your backyard cooking setup this summer, you're probably in need of a little advice. We're longtime admirers of the folks behind AmazingRibs.com, the site dedicated to unraveling the science of barbecue and grilling. Please welcome back Max Good, the only person in the world whose full-time job is testing, rating, and reviewing grills and smokers. The database he maintains includes over 500 grills and smokers, ranging in price from $30 to $50,000. When it comes to barbecue equipment, nobody knows it better.
Though it is technically a grill, you can carry out so much cooking styles in it. It can be used to sear meats and other food to a perfect golden crusty perfection; it can be used to bake quiches just like you would in a normal indoor oven. This is absolutely a trademark appliance that can also be used to smoke food, it can also be used to slow braise food, making it ideal for cooking up winter stews and casseroles. And very obviously you can grill in this thing. The lid on the pellet grills also aid in fast cooking by trapping smoke and heat and allowing the food to cook and flavor through quickly and more evenly.
One of the higher end pellet smokers you might want to check out, and one I’ve had the opportunity to try out myself, is the Memphis Grills Pro model. Running in the $3,000 range, this pellet grill is not for the faint of heart price wise. However, I can attest to the fact that it is one of the most robust, versatile, and pleasurable pellet grills I’ve used.

Product is decent but customer service really didn't help me out when they sent me a wrong accessory part that was ordered by their customer service department. Explained that the representative misunderstood my request for an inside shelf  but I was sent outer shelf which I have already . Tried to be fair and asked them to pay for the return shipping so I could return it back. They said we will gladly return your $ . Well till this day after numerous calls and false promises for the credit return .. there still is no refund. They seem to care but actually they did nothing. It's been 3 months of calling. Sorry to say we are Done with this company. If they can't settle a small concern and have A + service then don't bother! Good thing they are not the only smoker on the market. Shop around folks.

One comment I see a lot in various forums like PelletHeads.com is that you want as much efficiency as you can get. As with lump charcoal, this means burning as clean of a cook as you can with as little ash as possible. Different pellet mixes will produce differences in what you get in this area, and the cooker you’re using will dictate this to some degree as well.


PG24 by Camp Chef Pellet Grill also brings along a digital controller which you could use to set your desired temperature and at one point the heat in the chamber will be automatically adjusted. It allows meat to be smoked for hours at a temperature of 150 degrees F. You could increase temperature to 500 degrees F for searing and grilling. With convection, the cold and hot areas of the grill can be replaced with even heat.
Warranties are an important part of purchasing a new pellet grill because it assures that the manufacturer stands behind the build quality of the product.  It’s just like buying a new car – you want a warranty that will cover the costs of a repair if something happens to go wrong after buying. Depending on the pellet grill that you buy, there is a wide range of different warranties that are included. Cheap pellet grills will sometimes include a short-term, limited warranty that covers next to nothing. A quality manufacturer will be willing to add some years onto their warranties and cover all the components you’d expect (for example, Grilla Grills offers a 4-year warranty with VERY little fine print on the popular Silverbac model). So, if your cheap grill magically makes it past its warranty date unscathed and then something happens to it, you will be left paying out of pocket for the costs of fixing it or replacing parts. By comparison, pellet grills that have a lifetime or long-term warranty will give you more peace of mind rather than worrying about how you will pay for the next component that malfunctions or breaks suddenly.
You want longevity in a pellet grill: As the Traeger brand name has been around for a few decades, you can have some peace of mind that you’re purchasing a grill that should have replacement parts available for the foreseeable future. And Traeger grills tend to have good longevity ratings, working in top condition for several years, as long as you follow the manufacturer’s maintenance recommendations.
The monster of the Traeger Pellet Grill line, the XL boasts 850 square inches of cooking space, which is big enough for a small whole hog or 16 racks of ribs. At around $2,000USD, this is Traeger's largest and most expensive pellet grill. The pellet hopper holds more than 42 pounds of pellets in front of the cooker, under what serves as a work space. This is big enough for catering or competing, but ultimately it is still a Traeger which means a little less than ideal quality.
If the metal is too thick, you will also use a lot of pellets. The walls of a thick-bodied smoker act as a “heat sink”. Heat is taken away from the cooking area and stored in the walls of the cooker. So, it will take a lot of pellets to get the cooking area up to the desired temperature. While thick walls are desirable for some types of cookers, they are not required in pellet smokers.
Pellet Hopper – One of the reasons we all buy a pellet smoker for is the long cooking time. It’s an automated grill, but it needs to be provided with the right amount of pellets in the hopper. Those grills are used for long, often all night long meat smoking. That’s why it’s important for the pellet container to be very big. Here you get a 40 pound hopper capacity. You can be sure you won’t run out of fuel during longer cooking.
×